Académique Documents
Professionnel Documents
Culture Documents
Roll No.
1. Before commencing to write anything on this booklet ensure that the Booklet has 100 questions, there is no
misprinting, overprinting and/or any other shortcoming in both the Question Booklet and the OMR Answer
Sheet. If there is any shortcoming, intimate the same to your room invigilator and get the Booklet changed.
Only on being fully satisfied, write your Roll No. etc on the question booklet and on the OMR answer sheet.
Once the Roll No. has been written on the question booklet and on the OMR answer sheet, it will not be
exchanged.
2. Mark your answer on the OMR Answer Sheet which is provided separately. Please use Black ball point
pen provided to you, for completing your work on the OMR Answer Sheet.
3. Write your Roll No. Question Booklet No. (as given on the right hand top corner of this page); Question
Booklet Series Code A,B,C & D (as given on the left hand top corner of this page); at the appropriate places
provided on the OMR Answer Sheet & shade the appropriate circles with black ball point pen.
4. This is an objective type test. Each objective question is followed by four responses with serial numbers a,b,c
and d. You have to answer by shading/filling with black ball point pen the relevant circle a,b,c or d on the
OMR Answer Sheet. Mark your answers on the OMR Answer Sheet only. Also see relevant instructions
provided on the OMR Answer Sheet.
5. Mark your answer with utmost care. You are not allowed to change the answer, once marked, by adopting any
method (including correction fluid).
6. Take care that you mark only one answer for each question. If more than one answer are given by you for any
question, that answer will be treated as wrong answer.
7. All questions carry equal marks. One (1) mark will be awarded for each correct answer. If a candidate gives
more than one answer, it will be treated as wrong answer. No marks will be awarded or deducted for un-
attempted questions& wrong answers.
8. Use only black ball point pen provided to you at the test centre, for writing your answers and other
details on the OMR Answer Sheet.
9. DO NOT scribble or do rough work or make any stray marks on the OMR Answer Sheet. DO NOT
wrinkle or fold or staple it.
JOT/C/1
6001/02
10. Use of calculators, slide rules and any other study/references materials is not allowed. Do not bring mobile
phones, scanning device, pagers or any communication device etc. to the examination hall.
11. Rough work is to be done in the blank space (if available) in the Question Booklet. No other paper will be
allowed/ provided.
12. Please note that it will be your responsibility to carefully handover your OMR Answer Sheet to the Room
Invigilator at the end of the examination. If your OMR Answer Sheet is found missing, necessary action
will be taken. You are not allowed to carry the question booklet with yourself after examination, and the
same has to be submitted to the invigilator after examination.
13. Keeping in mind the limited time allowed for examination, candidates should attempt those questions first
about which they are sure and then proceed to other questions. This is only an advice to the candidates.
JOT/C/2
6001/02
JOT/C/3
6001/02
Direction (Q.1 to 2) select the missing number from the given 5. Rahul and Robin are brothers. Pramod is Robin’s
responses father. Sheela is Pramod’s sister. Prema is Pramod’s
niece. Shobha is Sheela’s granddaughter. How is
1. Rahul related to Shobha?
? 9 a) Brother
b) Cousin
33 17
c) Uncle
d) Nephew
a) 60 b) 68
6. If ‘×’ means ‘addition’, ‘-’ means ‘division’, ‘÷'
c) 55 d) 65 means ‘subtraction’, and ‘+’ means ‘multiplication’,
then which of the following equations is correct?
2.
1 2 3 a) 16 + 5-10×4÷3=9
b) 16-5×10÷4+3=12
4 5 6
c) 16+5÷10×4-3=9
7 8 9
d) 16×5+10÷4-3=19
27 38 ?
7. Arrange the following words as per order in the
dictionary.
a) 49 b) 50 1. Noble 2.Nobilitary 3. Noblesse 4. Nobility
5.Nobble.
c) 51 d) 52
a) 1,4,3,2,5
3. Which diagram correctly represents the relationship
between human beings, teachers, and graduates? b) 3,4,1,2,5
c) 5,2,4,1,3
d) 2,4,3,5,1
8. 123: 4: :726 : ?
a) 23 b) 26
a) North b) Leaves
b) South c) Fur
c) West d) Skin
d) East
JOT/C/4
6001/02
a) OMKI a) Geographer
b) RSTU b) Lexicographer
c) QSRC c) Lapidist
d) RPOM d) Linguist
SECTION -2 ELEMENTARY ENGLISH (Direction Q. 16 to 17), Out of the four alternatives, choose
the one which best expresses the meaning of the given
word and mark it in the answer sheet.
11. Four alternatives are given for the Idiom/phrase
underlined in the sentence. Choose the alternative 16. Diligent
which best expresses the meaning.
a) Intelligent
His blood ran cold when he heard his uncle was
murdered. b) Energetic
b) The destiny could not be changed if masters 18. a) If I leave now, / b) I will not be able to / c) return
cannot be changed. back before 9 p.m. / d) No error.
c) The destiny cannot change if masters cannot be 19. a) The old lady / b) prayed that he / c) may live
changed. long. / d) No error
d) The destiny cannot be changed if masters cannot 20. a) In any case no disciplinary action / b) are required
be changed. / c) to be taken / d) No error.
13. Choose the correct spelt word out of the given (Direction Q.21 to 25) Fill in the blanks with suitable
alternatives. words.
Direction (Q.14 to 15) In given below question, choose the b) Was drizzling
most suitable “One Word” for the given expression.
c) Is drizzling
14. A Part-song for several voices without instrumental
accompaniment is a : d) Has been drizzling
a) Ballad b) Madrigal
c) Panegyric d) Limerick
JOT/C/5
6001/02
22. The education Minister………………….visit our 27. A person deposited Rs.700 for 4 years and Rs.800 for
school next week. 3 years at the same rate of simple interest in a bank.
Altogether he received Rs.208 as interest. The rate of
a) May simple interest per annum was:
b) Might a) 4%
c) Should b) 3%
d) Had to c) 6%
d) Comes c) 600
d) After a) 30 m
SECTION – 3 b) 81 : 91
QUANTITATIVE APTITUDE/ELEMENTARY MATH
c) 9 : 10
26. By selling a fan for Rs.540, a man losses 10%. To make
a gain of 20%, the selling price of the fan should be: d) 10 : 9
c) 720 a) 10 days
d) 1000 b) 12 days
c) 15 days
d) 20 days
JOT/C/6
6001/02
32. The perimeter of the shaded region is: 36. The mean height of 10 students is 151.8cm. Two
more students of height 157.6cm and 154.4cm join
the group. What is the new mean height?
a) 155.0cm
b) 153.5cm
c) 152.5cm
a) 44 cm. d) 251.5cm
c) 66 cm. a) √26
a) Rs.17,400 b) 16
b) Rs.16,400 c) 64
c) Rs.16,800 d) 256.25
d) Rs.17,800
JOT/C/7
6001/02
SECTION – 4 46. Which one of the following state has the longest
GENERAL KNOWLEDGE coastline?
41. Which one of the following is not an All India Service? a) Maharashtra
44. Which one of the following river of India does not c) Rauf d) Suisini
make a delta?
50. Which among the following movements was not led
a) Ganges by Mahatma Gandhi?
c) Mahanandi
b) Non-Cooperation Movement
d) Tapti
c) Civil Disobedience Movement
45. Which of the following atmospheric gases constitute
greenhouse gases?
d) Quit India Movement
1) Carbon dioxide
2) Nitrogen
3) Nitrous oxide SECTION -5
4) Water Vapour DOMAIN KNOWLEDGE
Select the correct answer using the codes given below: 51. The function of the starter for DC motor is:
a) 1 and 4 a) To limit the starting current
b) 1 and 3 b) To limit the starting torque
c) 1, 2 and 4 c) To increase field resistance
d) 1, 3 and 4 d) To reduce armature resistance
JOT/C/8
6001/02
52. Kirchhoff’s second law is based on law of conservation 58. The most reliable distribution system is:
of:
a) Interconnected system
a) Charge
b) Radial system
b) Energy
c) Ring main system
c) Momentum
d) None of above
d) Mass
59. Speed of a DC motor is:
53. Conductance is expressed in terms of:
a) Always Constant
a) ohm/m b) m/ohm
b) Directly proportional to back emf
c) mho/m d) mho
c) Directly proportional to flux
54. A triac is a
d) Inversely proportional to the product of back
a) 2 terminal switch emf and flux
a) D
a) Silicon controlled rectifier
b) C
b) Field effect transistor
c) B
c) Photo emissive Diode
d) A
d) Tunnel Diode
61. The current drawn by a 120V DC motor of armature
56. In a transistor α is related to β by the relation: resistance 0.4 Ω and back e.m.f 112 V is:
a) β = (α+1) / α a) 10 A
b) β = (α-1) / α b) 20 A
57. Inverter Convert: 62. Change in speed of motor under Ward Leonard
method occurs due to change in:
a) DC to AC
a) Armature Voltage of DC motor
b) AC to AC
b) Armature current of DC motor
c) DC to DC
c) Field excitation of DC motor
d) All of the above
d) Supply Voltage
JOT/C/9
6001/02
63. The condition for maximum efficiency in case of DC 69. Iron loss in a transformer occurs in :
generator is:
a) Winding
a) Variable loss = (1 / Constant Loss)
b) Insulating coil
b) Variable loss = Constant Loss
c) Core
c) Variable loss = 2 x Constant Loss
d) Main body
d) Variable loss = (1 / 2 ) x Constant Loss
70. Damping torque is provided in indicating instrument
64. The semi conductor have ……………… temperature by:
coefficient of resistance :
a) Air friction
a) Zero b) Negative
b) Fluid friction
c) Positive d) Variable
c) Eddy current
65. Which of the following diode is designed to operate in
the breakdown region? d) All of these
a) Signal Diode 71. The secondary line voltage will be least for which of
the following connections?
b) Power Diode
a) Delta-delta
c) Zener Diode
b) Star- delta
d) None of the above
c) Delta-star
66. Figure represents a:
d) Star-star
b) Zener Diode
JOT/C/10
6001/02
74. An auto- transformer supplies a load of 5 kW at 125 V 79. Common impurity in battery electrolyte is:
and at unity power factor. If the primary voltage is 250
V, the transformed power will be: a) Sodium chloride
b) 1000 W c) Iron
c) 2500 W d) Dust
78. A fuel cell converts ………………energy into a) Fleming’s Right hand rule
electrical energy :
b) Lenz’s law
a) Mechanical
c) Right hand thumb rule
b) Solar
d) Both a and b
c) Magnetic
d) Chemical
JOT/C/11
6001/02
84. MMF in magnetic circuit is analogous to: 89. A 100 W , 220 V lamp takes a current of:
d) Voltage d) 5/22 A
85. The co-efficient of coupling of two coils is 90. An electric lamp is marked 100 W, 220 V. The
proportional to: resistance of filament will be:
a) L1L2 a) 22 W
b) √(𝐿1 𝐿2 ) b) 2200 W
d) 4840W
d) 1/L1L2
91. An ammeter is ………………….. instrument.
86. Applied voltage in the circuit is:
a) An indicating
b) An integrating
c) A recording
c) Service main
JOT/C/12
6001/02
95. In DC Generator, the brushes are always placed along: 100. A 4 pole, lap wound machine has 124 coils each
having 2 turns. The flux per pole is 0.015 wb. If the
a) Geometrical Neutral Axis (GNA) speed is 1500 rpm, the Induced emf is:
a) Series Generator
b) Shunt Generator
c) Compound Generator
a) Material
b) Length
c) Cross section
d) None of these
a) Series Generator
b) Shunt Generator
JOT/C/13