Vous êtes sur la page 1sur 2

M195 NOISE CLAMP

92503010856 REVA
M195 NOISE CLAMP
DESCRIPTION POWER DIRECTIONS SPECIFICATIONS
• Eliminates hiss and excess noise The MXR Noise Clamp can be • Run a cable from your guitar to • The volume threshold is the
from your effects chain powered by one 9 volt battery minimum level required to turn off IMPEDANCE 
your Noise Clamp’s Input jack
(accessed by removing the bottom the noise clamp. Input, Return 1 MΩ
• A single Trigger knob sets the and run another cable from the
plate of the pedal), a Dunlop Output, Send 1 kΩ
volume threshold Noise Clamp’s output jack to • Rotating the Trigger knob
• Capable of reducing noise up ECB003 AC adapter (ECB003E in your amplifier. clockwise raises the Noise Max Level 10 dBV
to 26 dB Europe) or a Dunlop DCB10 DC • Run a cable from the Noise Clamp’s volume threshold for Gate Attenuation -26 dBV
• Maintains riff definition at extreme Brick power supply. Clamp’s Send jack to the input hard clamping, while rotating Signal to Noise 99.5 dBA
gain levels of the first pedal in your effects it counterclockwise lowers its THD* 0.01%
chain. Run another cable from the volume threshold to let through Attack Time 3 ms
Noise Clamp’s Return jack to the quieter notes. Release Time 10 ms
output jack of the last pedal in Bypass Buffered
your effects chain. Current Draw 13 mA
• Turn the effect on by depressing Power Supply DC 9 volts
CONTROLS the footswitch.
TRIGGER knob sets volume 0 dBV = 1 Vrms
threshold for when the Clamp * Measured at 1 kHz, -10 dBV
is active
SEND Front of FX loop
OUTPUT Goes to amp
RETURN End of effects loop
INPUT To guitar
FOOTSWITCH toggles effect
on/bypass
**LOOP BYPASS OPTION
Internal switch toggles between two bypass modes: Loop Bypass or Loop
**LOOP BYPASS OPTION On. When in Loop Bypass mode, the Send/Return effects loop is bypassed
Up - Loop On (factory setting) when the pedal is off. In Loop On mode, the Send/Return effects loop is
Down - Loop Bypass active while the pedal is off. This can be accessed by removing the back
DUNLOP MANUFACTURING, INC.
plate of the pedal. P.O. BOX 846 BENICIA, CA 94510 U.S.A.
TEL: 1-707-745-2722 FAX: 1-707-745-2658

Vous aimerez peut-être aussi