Académique Documents
Professionnel Documents
Culture Documents
Figure 2 Tema 5
Tema # 6
Complete the design of the beam shown in Figure 3 to carry a large hydraulic motor. The
beam is attached to the two side rails of the frame of a truck. Because of the vertical
accelerations experienced by the truck, the load on the beam varies from 1200 lb upward to
5000 lb downward. One-half of the load is applied to the beam by each foot of the motor.
Figure 3 Tema 6
Tema 7
Figure 4 shows a yoke suspended beneath a crane beam by two rods. Design the yoke if the
loads are applied and released many times. Later, design the two vertical rods if the loads are
applied and released many times. Finally, design the connections between the rods and the
yoke and the crane beam.
Figure 4 Tema 7