Académique Documents
Professionnel Documents
Culture Documents
1. Which of the following plumbing code in USA does the National Plumbing Code of the Philippines
was being patterned for?
A.Standard Plumbing Code
B.ASPE Code
C.Uniform Plumbing Code
D.International Plumbing Code
2. The appropriate sealant that will be used to cover void spaces between pipes and sleeves
through concrete floors in the ground
A.bitumen
B.epoxy
C.grease
D.putty
3. What is the shape for the signage for women's comfort room in order to aid visually impaired
women readilty determine whether a washroom is for men or women?
A.CIRCLE
B.RECTANGLE
C.TRIANGLE
D.SQUARE
4. What is the maximum height should a water closet have if it is intended for a disabled person.
A.0.40m
B.0.50m *
C.0.45m
D.0.35m
5. When shall the installation of plumbing equipment to supply building or structures from existing
water supply system only be allowed to?
A.If the water demand is inadequate
B.Whenever the water supply is scantity availbale
C.When there is always water in the main
D.When water is not available in the vicinity
6. What is the minimum dimension for a turning space in a water closet stall intended for disabled
persons?
A.2.00 m
B.1.20 m
C.1.00 m
D. 1.50 m
7. What is the minimum pipe size of the standpipe if the highest outlet is located 23 meters or less
above the Fire Service connection?
A.3 inches
B.6 inches
C.5 inches
D.4 inches
8. When permitted by DENR, which of the following below is NOT used as a basis in determining the
type of the private sewage disposal system to be used?
A.SOIL POROSITY
B.GROUND WATER LEVEL
C.NUMBER OF OCCUPANTS
D.LOCATION
9. Where should the overflow pipe lead for overhead tank installed on buildings?
A.Soil stack
B.Scuppers
C.Storm drain
D.Gutter
10. What is the minimum horizontal clear dsitance from the septic tank to the property line of the
adjoining private property?
A.1.0 m
B.1.2 m
C.1.5 m
D.1.8 m
11. What installation standard is followed in joining plastic pipe and fittings by solvent cement?
A.ISO
B.ANSI
C.IAPMO
D.ASHRAE
12. Whenever the piping is pressurized by a pump or ejector, what kind of pipe should not be used
in the excreta drainage system?
A.vitrified clay pipe
B.hubless cast iron
C.galvanized wrought iron
D.none of these
13. What shall be issued by the Administrative Authority for the construction of a part of a large
and/or complicated plumbing system before the entire plans and specifications for the whole
system have been submitted or approved?
A.restraining order
B.partial permit
C.summon
D.evaluation sheet
14. What is the minimum diameter of vent pipe is allowed in the revised Code?
A.1 inch
B.1 1/4 inch
C.2 inch
D.1 1/2 inch
15. A kind of cleanout plugs that will be installed in case where raised heads may cause hazards to
passing personnel or vehicles.
A.depressed
B.countersunk
C.embedded
D.recessed
16. Who has the power to remove any member of the Board of Master Plumbers for neglect of duty,
incompetence, malpratice and unprofessional or dishonorable conduct?
A.President of the Philippines
B.Civil Service Commisioner
C.Chairman of PRC Commisioners
D.Commision on Appointments
17. Unless prohibited by structural conditions, what is the reference of each vertical vent pipes
before offsetting horizontally to join the stack vent or vent stack?
A.invert of trap
B.air gap of fixture
C.water level inside the trap
D.highest flood level rim of fixture
18. What is the minimum age requirement for an appointee to become a member of the Board of
Master Plumbers?
A.Thirty years old
B.Twenty eight years old
C.Thirty two years old
D.Thirty five years old
19. What is the minimum pipe size of the standpipe if the highest outlet is located more than 23
meters above the Fire Service connection?
A.3 inches
B.6 inches
C.5 inches
D.4 inches
20. What shape of signage is shown for mens showroom?
A.SQUARE
B.CIRCLE
C.TRIANGLE
D.RECTANGLE
21. What Congress of the Republic of the Philippines approved after the third reading Rep. Act 1378
otherwise known as the Plumbing Law of the Philippines?
A.Third Congress
B.Sixth Congress
C.Second Congress
D.Fifth Congress
22. What type of PVC female screws for water piping is prohibited under the code?
A.Tapped
B.Job fabricated
C.Seamless
D.Schedule 20 screws
23. According to the Fire Code of the Philippines what is the required slope of all horizontal runs of
dry standpipes system for purpose of drawing?
A.10%
B.20%
C.5%
D.2%
24. Under the Accessibilty Law, what is the minimum area of water closet stalls?
A.1.7 x 1.8 meters
B.2.0 x 2.0 meters
C.1.5 x 1.8 meters
D.1.2 x 2.0 meters
25. What is the maximum water pressure must standpipe fittings and connections must withstand to
when ready for service?
A.21 kg/cm²
B.34 kg/cm²
C.15 kg/cm²
D.8 kg/cm²
26. The following are the data required whenever a Registered Master Plumber sign the blueprint of
the building plan EXCEPT
A.Date of PRC registration
B.PTR date
C.Registration expiry date
D.none of these
27. What portion of the trap should the vent pipe opening will not go below from a soil or waste pipe?
A.slip joint
B.weir
C.sleeve
D.seal
28. Accordingto Batas Pambansa Blg. 344, what type of urinal should be provided for disabled
persons?
A.WALL-HUNG TYPE
B.PEDESTAL TYPE
C.TROUGH TYPE
D.NONE OF THESE
29. What is the type of Siamese connection that all 125-millimeter dry standpipes shall be equipped
with?
A.three-way
B.two-way
C.four-way
D.one-way
30. The minimum requirement for the slope of horizontal drainage pipes between manholes is
A.2%
B.2 1/2%
C.3%
D.4%
31. In sizing the grease interceptors, four elements are being used. Two of these elements are
number of meals per peak hour and the waste flow rate. Whta are the other two elemets?