Académique Documents
Professionnel Documents
Culture Documents
A side B terminal
Tx send - Rx receive
Rx receive - Tx send
=================================
selection!
plate
Although the cat has its own power supply, do not connect the VCC
small feet, but small VCC and cat, VCC. If the cat is 3.3V, small jump
to 5V, although you can see on the board of the RX lights flashing,
soon as you restart the jumper, select the 3.3V voltage (I turn off the
HG527-C, unplug the USB connector from the computer, and then jump the
line to select the voltage, and then plug in the USB port, and then open
=================================
First install the driver (Note: don't install driver, plug plate)
Etc.. The serial port, with the corresponding software to routers, set-
upgrade or update,
=================================
ADSL type wireless home gateway ADSL network protocol ADSL Annex A
54Mbps, 48, the highest rate of uplink 1024Kbps maximum downlink rate
still the preferred access mode for home users, so the use of integrated
products, not only can save resources, but also save space, to achieve
two birds.
It's not just a wireless routing cat, it also has a lot of people
White shell design, the overall feeling is very mellow, the front
panel is the main indicator lamp, because the function is more, so the
lights are various, through which they can quickly diagnose the network.
The interface is also very rich, starting from the left, which are
WPS one key encryption, Reset button, power socket, power control
The back of the product is also like the top of the distribution of
heat holes, as well as wall hanging holes, convenient for their own
difference, or CPU, wireless module, switch chip, SDRAM, FLASH and other
parts, the only difference is that HUAWEI uses CONEXANT chip solutions.
This is the internal circuit board of the product, and all the chips
SDRAM uses modern particles, and two chips are 16MB. FLASH capacity
16MB.
the pop-up
login box, enter the super user name bjcnchgw and password 123456
microsoft-com:office:office""
2. click on the network in the main directory, and then click on the
drop-down menu on the right to see whether there is the same value as
that delete your local VPI/VCI that connection, after using the computer
dial is not dial up. Delete this connection to lay the foundation for
the routing below. Other areas delete the local options. If the 7 option
3. now we'll build the routing mode and click the new connection.
The bearer service should be INTERNET. To enable the right small square,
Then fill in your local VPI and VCI values below. For example,
The four small squares on the right of the NAT should be hooked.
password. The account number and password are provided by your network