Académique Documents
Professionnel Documents
Culture Documents
net/publication/293821887
CITATIONS READS
0 825
1 author:
Sundarakumar Kusuma
Usha Rama College of Engineering & Technology, Andhra Pradesh, India
31 PUBLICATIONS 82 CITATIONS
SEE PROFILE
Some of the authors of this publication are also working on these related projects:
Modeling of Urban Climate of new capital city of Andhra Pradesh View project
All content following this page was uploaded by Sundarakumar Kusuma on 11 February 2016.
Abstract
Introduction
Fresh water being one of the basic necessities for sustenance of life, the human race
through the ages has striven to locate and develop it. Water, a vital source of life in its
natural state is free from pollution but when man tampers the water body it loses its
natural conditions. Ground water has become an essential resource over the past few
decades due to the increase in its usage for drinking, irrigation and industrial uses etc.
In the last few decades, there has been a tremendous increase in the demand for fresh
water due to rapid growth of population and the accelerated pace of industrialization.
Human health is threatened by most of the agricultural development activities
particularly in relation to excessive application of fertilizers and un-sanitary
conditions. Rapid urbanization, especially in developing countries like India, has
affected the availability and quality of groundwater due to its overexploitation and
improper waste disposal, especially in the urban areas. According to WHO
organization, about 80% of all the diseases in human beings are water borne. Further,
the groundwater and the pollutants it may carry move with such a low velocity that it
may take considerable time for the contaminants to move away from the source of
pollution and degradation in the groundwater quality may remain undetected for
years; Once the groundwater is contaminated, its quality cannot be restored by
arresting the pollutants from the source. Polluted waters lead to various
gastrointestinal problems, liver infections, tropical diseases and terminal diseases like
cancer. Children are often the worst affected, dying in large numbers because of
diarrhea. Hence the quality of ground water is equally important as that of quantity.
It therefore becomes imperative to regularly monitor the quality of groundwater
and to device ways and means to protect it. Water quality index is one of the most
effective tools to communicate information on overall quality status of water to the
concerned user community and policy makers [1, 2]. Thus, it becomes an important
parameter for the assessment and management of groundwater.
Remote sensing and GIS are effective tools for water quality mapping and land
cover mapping essential for monitoring, modeling and environmental change
detection. GIS can be a powerful tool for developing solutions for water resources
problems for assessing water quality, determining water availability, preventing
flooding, understanding the natural environment, and managing water resources on a
local or regional scale [3].
The purpose of the study is to understand the groundwater quality in the district
and pictorially represent it using Geographic Information System (GIS). GIS is an
effective tool for storing large quantum of data that can be correlated spatially and
retrieved for the spatial analysis and integration to produce the desirable output. GIS
has been used by scientists of various disciplines for spatial queries, analysis and
integration for the last few decades [4].
Study Area
Srikakulam District is the extreme Northeastern District of Andhra Pradesh situated
within the geographic co-ordinates of 180-20’ and 190-10’ of Northern latitude and
830-50’ and 840-50’ of Eastern longitude. Srikakulam is the second-most backward
district in Andhra Pradesh, India. The district has an industry called Dr. Reddy's
Laboratories, at Pydibhimavaram. The district has lot of scope for development in
Ground Water Quality Assessment of Srikakulam 497
future with the forthcoming establishment of a thermal power plant at Sompeta and a
nuclear power plant at Ranasthalam.
The District is skirted to a distance by Kandivalasagedda, Vamsadhara and
Bahuda at certain stretches of their courses white a line of heights of the great Eastern
Ghats run from North East. Vizianagaram District flanks in the south and west while
Orissa bounds it on the north and Bay of Bengal on the East .The total area of the
District is 5837 Sq. kms. It has a population of 2537593 persons [5]. Nagavali,
Vamsadhara, Mahendratanaya, Champavathi, Bahuda and Kumbikotagedda are the
important rivers. The rivers have origin in the EatsrenGhats of Orissa state and joins
Bay of Bengal within the seacoast of Srikakulam district. The Irrigation Projects at
Narayanapuram on the Nagavali, Gottabarrage on Vamsadhara, and Kalingadala on
Mahendratanaya provide abundant water resources throughout the District.
The District has a seacoast of 193 Kms. Throughout the year, the climate is
characterised by humidity. The South-West-monsoon which follows the summer
season lasts up to September. Northeast monsoon starts from 1st October to the end of
November. The period from December to mid February enjoys generally a fine
weather. The annual rainfall is 937.6 mm during the year 2004-2005 against normal
rainfall is 1162 mm. The district map, location map of the study area and Mandal map
are shown in the Figure.1, 2, 3 respectively.
Figure 1: District map of Srikakulam. Figure 2: Location map of the study area.
Methodology
Database Creation
The study is carried out with the help of four major components: inputs from remote
sensing data, topographic maps, field data and existing data. The IRS-ID satellite data
of 2001 procured from the National Remote Sensing Agency (NRSA) for the study
area is used for the generation of various digitally processed outputs. These outputs
form the spatial database for the present study. The water quality parameters data has
been obtained from the Department of Rural Water Supply and Sanitation of
Srikakulam District. The data comprises water quality of samples collected from
about 7308 sampling stations spread over the 38 mandals of the Srikakulam District,
during the last six months of 2009. The number of sampling locations in each Mandal
was given in the Table.1.The water quality data so obtained form the attribute
database for the present study. Table 2 presents the normal statistics of water quality
parameters of groundwater samples.
Number Number
of of
Name of the Mandal Name of the Mandal
samples samples
Tested Tested
AMUDALAVALASA 75 NARASANNAPETA 326
BHAMINI 129 PALAKONDA 198
BURJA 94 PALASA 112
ETCHERLA 248 PATHAPATNAM 230
G.SIGADAM 78 POLAKI 178
GARA 525 PONDURU 194
HIRAMANDALAM 91 RAJAM 223
ICHCHAPURAM 210 RANASTALAM 203
JALUMURU 234 REGIDI 52
KANCHILI 201 SANTHABOMMALI 219
KAVITI 207 SANTHAKAVITI 166
KOTABOMMALI 152 SARAVAKOTA 300
KOTHURU 160 SARUBUJJILI 98
L.N.PETA 84 SEETHAMPETA 122
LAVERU 270 SOMPETA 203
MANDASA 152 SRIKAKULAM 416
MELIAPUTTI 249 TEKKALI 120
NANDIGAMA 231 VAJRAPUKOTHURU 160
VANGARA 171 VEERAGHATTAM 227
Ground Water Quality Assessment of Srikakulam 499
Table 3: Water quality parameters, their BIS 10500/WHO standards, and assigned
unit weights.
pH 8.5 0.024939
Electrical
Conductivity(EC) 2000.00 0.000106
Total dissolved
Solids(TDS) 500.00 0.000424
Turbidity 5.00 0.042396
Alkalinity 200.00 0.00106
Hardness 300.00 0.000707
Fluoride 1.00 0.211978
Chloride 250.00 0.000848
Calcium 75.00 0.002826
Sulphate 200.00 0.00106
Iron 0.30 0.706592
Magnesium 30.00 0.007066
Water Quality
Conductivity
Magnesium
Alkalinity
Sulphates
Turbidity
Electrical
Dissolved
Hardness
Chloride
Fluoride
Calcium
Solids
Index
Total
Iron
Sl.
pH
No NAME
1 AMUDALAVALASA 6.90 1093.55 1225.33 3.89 270.08 568.11 0.57 424.59 151.41 44.51 0.18 98.42 52.32
2 BHAMINI 6.95 604.75 608.53 3.48 277.27 319.32 0.62 174.05 103.94 32.63 0.15 52.24 46.73
3 BURJA 6.85 949.41 901.08 3.77 211.35 492.71 0.59 351.68 148.95 38.54 0.22 81.97 60.09
4 ETCHERLA 6.97 899.67 999.60 3.36 310.55 451.72 0.61 335.99 128.00 40.69 0.19 78.47 57.27
5 G.SIGADAM 7.00 1260.77 1434.62 2.77 368.97 631.05 0.68 502.97 168.60 55.13 0.18 112.55 53.11
6 GARA 6.99 918.28 1007.43 3.64 273.04 413.47 0.61 373.49 125.36 37.29 0.21 69.71 63.48
7 HIRAMANDALAM 8.15 1270.69 762.10 10.51 267.42 332.42 0.50 289.54 80.91 43.98 0.06 65.58 28.58
8 ICHCHAPURAM 7.73 1291.80 689.68 4.68 129.12 429.34 0.50 289.88 0.06 97.56 0.35 95.68 92.10
9 JALUMURU 8.37 1547.94 827.44 0.80 231.27 462.03 0.40 385.58 148.94 44.46 0.10 97.27 35.32
10 KANCHILI 7.81 1343.08 738.51 18.24 138.36 360.76 0.27 257.97 101.94 56.90 0.46 65.78 106.79
11 KAVITI 7.47 547.04 305.67 2.88 65.98 153.74 0.25 113.52 51.45 55.79 0.22 0.01 53.29
12 KOTABOMMALI 7.72 915.30 658.89 5.79 149.64 324.72 0.53 205.35 86.57 56.90 5.72 0.03 659.68
13 KOTHURU 7.02 792.03 790.63 3.43 298.79 372.25 0.63 308.68 130.68 36.57 0.19 58.63 57.13
14 L.N.PETA 6.90 973.04 1058.33 2.92 342.26 464.54 0.60 301.95 132.38 38.15 0.18 80.03 52.39
15 LAVERU 7.04 1254.22 1308.15 3.46 352.30 584.59 0.69 433.82 168.03 51.75 0.19 100.41 61.10
16 MANDASA 6.79 1214.79 1307.90 13.90 452.68 375.79 0.78 400.00 51.19 82.90 0.16 65.89 54.29
17 MELIAPUTTI 7.80 1401.57 777.07 0.10 114.56 354.68 0.30 264.73 84.85 42.66 0.17 69.71 42.94
18 NANDIGAM 7.32 1116.97 743.26 4.79 163.97 375.77 0.60 317.26 108.53 45.67 0.57 0.04 128.82
19 NARASANNAPETA 7.76 1992.62 1285.73 8.38 318.66 502.78 0.43 474.31 125.06 43.68 0.34 96.57 93.46
20 PALAKONDA 7.23 858.43 941.41 3.28 306.77 428.21 0.63 263.20 113.07 63.71 0.17 76.85 57.18
21 PALASA 7.83 1405.88 971.79 3.97 135.67 473.78 0.65 302.79 85.90 29.45 0.16 84.73 56.24
22 PATHAPATNAM 7.26 1312.41 828.04 3.43 153.34 394.26 0.59 308.68 130.68 36.57 0.19 58.63 60.31
23 POLAKI 7.06 637.25 662.57 3.89 209.29 359.47 0.73 224.61 151.41 44.51 0.18 98.42 59.60
24 PONDURU 6.92 629.47 629.90 3.99 233.21 391.16 0.71 196.64 106.40 30.93 0.17 68.20 52.12
25 RAJAM 6.97 999.02 1032.74 3.83 215.10 593.21 0.63 452.71 146.92 48.07 0.19 108.01 58.59
26 RANASTALAM 6.96 849.34 960.59 3.55 273.29 435.94 0.60 298.42 125.49 37.29 0.20 75.27 58.89
27 REGIDI 6.94 711.27 803.85 2.56 243.23 400.77 0.59 238.19 116.31 36.37 0.15 68.95 46.12
28 SANTHABOMMALI 7.26 1312.41 828.04 6.67 153.34 394.26 0.59 355.51 97.63 35.79 3.68 0.06 487.09
29 SANTHAKAVITI 7.08 856.54 971.69 2.96 282.64 490.77 0.60 326.36 140.65 41.34 0.13 84.91 45.03
30 SARAVAKOTA 8.09 1437.06 837.17 8.19 135.57 409.63 0.37 285.12 85.14 54.80 0.24 62.79 70.66
31 SARUBUJJILI 6.90 1112.24 1036.73 4.71 224.22 473.27 0.57 431.22 121.92 34.10 0.29 85.04 73.49
32 SEETHAMPETA 6.95 300.26 318.85 3.48 190.26 239.00 0.52 92.97 102.13 29.80 0.22 33.75 59.24
33 SOMPETA 7.73 1607.00 897.57 4.90 154.50 390.76 0.48 301.43 91.63 44.79 11.54 0.04 1056.71
34 SRIKAKULAM 6.97 970.14 957.21 3.56 306.07 424.42 0.59 363.49 127.62 36.29 0.19 72.20 56.57
35 TEKKALI 7.10 263.00 300.00 3.00 200.00 180.00 0.80 70.00 84.00 16.80 0.10 23.40 39.90
36 VAJRAPUKOTHURU 7.55 1151.00 749.49 3.79 74.38 347.01 0.35 202.05 110.32 54.78 0.47 67.90 106.03
37 VANGARA 7.06 637.25 662.57 3.08 209.29 359.47 0.73 224.61 106.98 32.80 0.19 61.79 60.42
38 VEERAGHATTAM 7.06 641.16 719.82 3.27 275.26 376.36 0.58 225.67 117.44 36.59 0.17 62.32 55.26
Ground Water Quality Assessment of Srikakulam 501
Conclusion
In this study the water quality parameters of all the 38 mandals of Srikakulam district
were analysed and water quality index has been calculated and the results were
interpreted in terms of maps. The analysis of the results drawn at various stages of the
work revealed that integration of Remote Sensing and GIS are effective tools for the
preparation of various digital thematic layers and maps showing spatial distribution of
various water quality parameters. The final output has been given in the pictorial
representation of ground water quality suitable or unsuitable for drinking purposes in
the area under study. As it is an underdeveloped area and because of poor ground
water management practices the water quality in the area is more or less poor. The
analysis reveals that the ground water of the area needs some degree of treatment
before consumption. The outcome of this research work can be effectively utilized by
the Rural Water Supply and Sanitation Engineering Department, for better
management of groundwater as well as supplying protected water to the affected
areas.
Acknowledgments
The author wish to acknowledge K.Vamsikrishna Reddy, S. Kesav,Final year
B.Tech(Civil) students, GMRIT, S. Sivayya, Environmental Engineering lab
technician, GMRIT, for their contribution in this paper work, Department of
RWS&SE of Srikakulam, A.P, for their support, Department of Civil Engineering,
GMRIT, for providing Soft ware and computer lab facilities.
References
[1] Subba Rao N.,1997, Studies on the water quality index in hard rock terrain of
Guntur district, Andhra Pradesh, India. National Seminar on Hydrology of
Precambrian Terrains and hard rock areas, pp 129-134.
[2] Tiwari TN, Mishra MA., 1985, A preliminary assignment of water quality
index of major Indian rivers. Indian J Environ Proc, 5:276-279.
[3] Ferry Ledi Tjandra; Akihiko Kondhoh; Mohammed Aslam M.A. A
Conceptual Database Design For Hydrology Using GIS. Proceedings of Asia
Pacific Association of Hydrology and Water Resources. March 2003, 13-15,
Kyoto, Japan.
[4] Burrough PA, McDonnell., 1998, Principles of Geographical
InformationSystems. Oxford University Press, Oxford, 333 pp.
[5] Census of India., 2001, Director of Census Operations. District Census
Handling of Andhrapradesh.
[6] Abassi, S. A.: Water Quality Indices, State-of-the art.J.IPHE. 1999, No.1.
[7] Pradhan SK, Dipika Patnaik, Rout SP., 2001, Water quality index for the
groundwater in and around a phosphatic fertilizer plant. Indian Journal of
Environmental Protection, 21,355-358.
[8] Mahuya Das Gupta Adak, Purohit KM, Jayita Datta., 2001, Assessment of
drinking water quality of river Brahmani, Indian Journal of Environmental
Protection, 8(3) 285-291.
[9] Tiwari, T. N.; Mishra, M.: Indian Journal of Environmental Protection, 1985,
Vol-5, No. 4, 276-279.
[10] BIS (Bureau of Indian Standards) 10500, Indian standard for drinking water
specification,1991, First revision, p 1-8.
[11] WHO (World Health Organization) Guidelines for drinking water
quality.,1983, 2nd edition, vol 1, p-188.
[12] Sawyer G.N. McCarthy DL., 1967, Chemistry of Sanitary Engineers, 2nd edn,
McGraw Hill, New York, p-518.
[13] APHA, AWWA, WPCF. Standard Methods for theExamination of Water and
Wastewater. 20th edition,American Public Health Association,
Washington,DC, New York, USA, 1998.