Can voyage planning be executed = yes Is it necessary to construct = a passage plan—under pilot Rigging of the Pilot = a responsible officer SOLAS (The International = all vessels What is the crucial = an effective detailed What is the main purpose of VTS = increase the safety of all ship When a vessel is transiting = all of these answer When handing over the con = a passage plan should When initially setting up = select WGS84 When planning a voyage = the anticipated weather and While navigating using = radar ranges from Who will have the authority = the panama canal You are a Senior Officer = deciding safe Your vessel is to = rudder hard to port If the electronic chart = tidal current Which of the following = all of the above ECDIS unit incroporate = vector and raster Raster scan chart = a digitized Which of the following = all of the above Which of the following =ship hydro dinamic The database resulting = system electronic The level database information = standard display info Ecdis must give = all Ecdis must give = if the ship is going Ecdis must give = when the speciefed Chart information = intrnational hygro.. An ecdis is required = hydrografic data Ecdis must have = 12 hours Which data must ecdis = all of above With respect to failure = all of above Which feuture = selectve available The highest level = DGPS Which type of GPS = continuos Which theoritical = four An ecdis is required = waypoint Which data must ecdis = course made good With respect to failure = a warning of lose With respect to failure = an alarm if a new NOAAVHF = 162.55 162.40 Which from navigatio = electronic
Use of radar and ARPA to maintain safety of navigation N3
1.The main component in the display = cathode ray unit
2. What does the above diagram indicate = Bearing discrimination. 3. The main component of the transmitter is the: = antenna 4. What indicates the true movement of the targ = True vector 5. The purpose of the transmitter unit is to = conduct the radar pulses to 6. Targets echoes appear along a line called the = heading marker 7. What does this control on the radar = Transmitted power monitor. 8. What is the time of closest point of approach of target A ? 9. The function of the waueguide is to = conduct pulses to and from the 10.What is this mark? (see figure) = Racon 11.Who should conn the vessel at the time of a SAR = Master 12.What is the closest point of approach of = Less than 1 mile 13.Target detection ranges are considerably = Shadow sectors 14.What is the closest point of approach of = Between 1 – 2 mile 15.What is no.12 ? (see figure) = CRT 16.Radar does not transmit continuously = make the equipment get 17.When two tracked targets are very close to each other =Target swap 18.Which target will have the closest point of approach ? = Target A 19.What type of spurious echoes are these? (see figure) = Multiple echoes 20.What is this on the PPI? (see figure) = Clearing bearing 21.The unit which radiates the radar pulse is the = scanner 22.What is no.4 ? (see figure) = Modulator 23.Target ranges are obtained from = the range marker 24.The purpose of radar is to enable = The range and bearing of objects 25.The unit which sends returning ragets echoes to the = transmitter unit 26.A reference for target bearings is provid = heading marker 27.The transmitter P.R.F. is determined = magnetron 28.What is the closest point of = Less than 0.9 mile 29.Radar uses pulse transmission = avoid interference 30.In the equation d = (t x s) r2, = The speed of the radar waves