Académique Documents
Professionnel Documents
Culture Documents
APPLICATION RANGE:
Application on damp surfaces of Process vessels, pressure vessels of all kinds
On- and Offshore structures Storage tanks for crude oil, hydrocarbons, chemicals
Pipelines for oil & gas Special tanks for urea (Ad-Blue), bio oils
APPLICATION DATA:
Application methods: Airless spray pump (without filter), Ratio 1:70 or higher. Tip size: 0.021-0.029”; Hose length max.
20m; Spray hose diameter max. ¾”; Material must be taken up directly (without intake hose); avoid
waiting time under pressure (reduction of pot life!)
Mixing ratio: 10:1 by weight [6:1 by volume]
Part A (base) to be mixed thoroughly with part B (hardener)
Potlife (20oC): ~45 minutes (reduced at higher temperatures)
Material spray temp: Minimum 20°C, maximum 25°C recommended
Filters: Check to ensure that filters are clean
Number of coats: On horizontal surfaces unlimited WFT/DFT. Sagging limit at vertical surfaces is 1.000 µm.
TECHNICAL INFORMATION:
Colour: RAL colours
Volume Solids: 100% (+/- 2%)
Solvent resistance: Excellent
Flash point: > 23°C
Chemical resistance: Very good
VOC: 0g
Abrasion resistance: Excellent, 80 mg loss
Flexibility: Excellent
(ASTM D 4060)
Seawater resistance: Excellent, > 6.000 hours seawater Adhesion: Excellent, > 27 N/mm²
immersion test (ISO 4624)
Corrosion resistance: Excellent, > 10.000 hours salt spray Specific Gravity (Mix): 1,57
(ISO 7253)
Application:
Film thickness per coat Theoretical consumption Contact Ceramic Polymer
technical services for
Dry Wet kg/m² m²/kg specific system and
1000 µm 1000 µm 1,57 0,64 application advice.
Product Data Sheet Page 2 of 3
Concrete Substrates
Refer to Ceramic Polymer GmbH for specific recommendations.
Damp Surfaces
The surface should be prepared by abrasive blast cleaning to minimum SA 2,5 (ISO 8501-1:2007) or SSPC-SP10. A sharp,
angular surface profile of 75-100 µm is required. By application in slightly damp surfaces, it is recommended to remove water
drops and moisture by pressure air, before the Ceramic Polymer 232 Spray Version will be applied by Airless-Spray
application. A performance reduction must be expected by applying the coating material on slightly corroded and damp
surfaces. The direct contact with water / moisture can cause a slightly surface irritation, which is a visual effect and will not
cause a surface protection failure. The curing time can extend.
DRYING TIME:
Substrate Recoat
Gel Service Cured
temperature
Minimum Maximum
o
20 C 1,5 h 8h 24 h 8h 30 d
DISCLAIMER:
All technical information in this Product Data Sheet is signified as material description and based on laboratory tests and
practical experiences under normal conditions. During individual use, actual measured data may vary due to circumstances
beyond our control. In particular, the recommendations regarding the application and use require the proper storage and
treatment of our products. Due to differences in materials, substrates and real site conditions Ceramic Polymer GmbH does
not assume any warranty or liability for application results or fitness for a particular purpose, of any legal relationship
whatsoever, neither from this information, nor from any given recommendations, or from any other oral advice. The user of the
product must check the product's suitability for the intended application and purpose. Ceramic Polymer reserves the right to
change the properties of its products. The proprietary rights of third parties must be observed. All orders are accepted subject
to our general terms and conditions of sale and delivery. The most recent issue of the Product Data Sheet has to be
considered, please ask always for the current version.
11/2016