Académique Documents
Professionnel Documents
Culture Documents
1. Remove cup holder to access the GSE connector. Connect GSE cable to GSE connector.
6.
4.
Select File
7b. Click Open
2/4
8. Click "Update". A pop up box will appear. Click "Yes" to confirm update.
The updating process will take approximately 1 minute to complete.
<Caution>: DO NOT unplug the GSE Cable or turn Key OFF during installation or run other applications
in the background. It may damaged the VCM.
9. Updating is successful when a box showing "Firmware update successful" appear. Click "OK".
(Note: Display may show P03, P07, E03 or F73 after updating is completed)
10. Turn key to "OFF". After 5 seconds, turn key to "ON" position.
11. Click on "Firmware Update" to confirm the version is now 0046.
11 Confirm Version
is 0046
9.
0046
12. After updating the new software, error code P03, P07, E03 or F73 will appear.
13. Click on "Fault History" and clear the history by clicking on "Clear".
13a.
13b
3/4
Communication error (P03, E03) appears because VCM and ECM can't communicate during installation
Error E-03
14. To clear code E03, click on "Connection change" and change Target from VCM1-1M to ECM. Click "OK".
14.
15a. 15b.
16.
17
4/4
18. Click on "Connection change" and change Target from ECM to VCM1-1M. Click "OK".
19. Click on "Fault Status" to confirm no current error code.
Note: If error code E03 still appear, turn key to "OFF".
After 5 seconds, turn key to "ON" position and repeat step 14 to 19.
19.
23. Close Uptime and disconnect GSE cable. Operate truck to confirm it is OK.