Académique Documents
Professionnel Documents
Culture Documents
Desert
For high load, high speed applications in high temperature environments NLGI Grade 2
Corrosion Protection—Resists oxidation and protects metal against rust. Will not
corrode or damage steel, copper bearing alloys or conventional seal materials.
Cat® Extreme Application Grease – Desert
Grease Selection Guide
Cat Extreme Application Grease 1 Cat Extreme Application Grease - Desert Cat Prime Application Grease Cat Ball Bearing Grease
NLGI 1 NLGI 2 NLGI 2 NLGI 2
(-20 to 140ºC / -4 to 284ºF) (-10º to 140ºC / +14º to 284ºF) (-20 to 140ºC / -4 to 284ºF) (-20º to 160ºC / -4º to 320ºF)
With 5% Moly With 5% Moly With 3% Moly Without Moly
Cat Extreme Application Grease 2 Cat Extreme Application Grease - Arctic Cat Utility Grease
NLGI 2 NLGI 0.5 NLGI 2
(-15 to 140ºC / +5 to 284ºF) (-50º to 130ºC / -58º to 266ºF) (-20 to 140ºC / -4 to 284ºF)
With 5% Moly With 5% Moly Without Moly
Working High Load & Med Load & Low Load & Low Load &
High Temp Low Temp
Environment High Speed Med Speed Low Speed High Speed
Typical Properties
NLGI 2 Recommended Use
Color Gray Black Cat Extreme Application Grease – Desert
Molybdenum Disulfide, % 5 is recommended for grease fittings and
lubrication points in very severe load
Operating Temperature Range, °C -10 to +140
conditions and all-speed applications
Operating Temperature Range, °F +14 to +284 at operating temperatures ranging from
Base Oil Type Mineral -10°C to +140°C (-14°F to +284°F).
ASTM D445 Base Oil Viscosity 40°C, mm²/s 460
Thickener Type Calcium Sulfonate
Health and Safety
ASTM D2265 Dropping point, °C > 280 For information on proper use for health,
safety and environment, please refer to
ASTM D2266 4 Ball wear, scar diameter, mm 0.57
the Material Safety Data Sheet (MSDS).
ASTM D2596 4 Ball weld load, kg 500 Read and understand the MSDS before
ASTM D1743 Rust Prevention Pass using this product. Always observe good
ASTM D4048 Copper corrosion 1A hygiene measures. For a copy of the
The values shown are typical values and should not be used as quality control parameters to either accept or reject product. MSDS, contact us or visit the web at
Specifications are subject to change without notice. www.catmsds.com.
PEHJ0406
www.cat.com