Académique Documents
Professionnel Documents
Culture Documents
OF
BACHELOR OF TECHNOLOGY
IN
INSTRUMENTATION AND CONTROL ENGINEERING
By
Ansh Vyas 16bic003
Jignasha Dobariya 16bic012
Under the Guidance of
Prof. Vishal Vaidya
SCHOOL OF TECHNOLOGY
NIRMA UNIVERSITY
Ahmedabad 382 481
May 2019
1
CERTIFICATE
This is to certify that the project report entitle “Rope Type Elevator
Using Arduino” submitted by Mr. ANSH VYAS (16BIC003) & Ms.
JIGNASHA DOBARIYA (16BIC12) towards the partial fulfillment of the
requirements for the award of the degree in Bachelor of Technology
(INSTRUMENTATION & CONTROL ENGINEERING) of School of
Technology is the record of work carried out by him/her/them under
my/our supervision and guidance. The work submitted has in our
opinion reached a level required for being accepted for examination.
The results embodied in this project work to the best of my/our
knowledge have not been submitted to any other University or
Institution for award of any degree or diploma.
DATE: 04/05/2019
2
ACKNOWLEDGEMENT
3
ABSTRACT
4
COMPONENTS
1. IR Sensors
2. Arduino UNO
3. Motor
4. Motor Driver
6. Push Buttons
5
CODE / LOGIC
6
CONCLUSION
From our mini project we have learnt about different sensors and
Arduino platform. We have done cost effectiveness analysis of our model.
In first review we represent over idea about this project. In second review
we represent module of lift and working in one direction. In final review
we represent working of lift in both directions. Pair of IR Sensor used to
sense the floor and push button or IR Sensor detect the destination and
desired floor.
REFERENCE
1. Arduino.cc