Académique Documents
Professionnel Documents
Culture Documents
® ®
© 2010 Caterpillar
All Rights Reserved
KEBU7543-04
September 2009
Operation and
Maintenance
Manual
CP74, CP76, CS56 and CS64 Paving
Compactors and CP56, CP64, CS74
and CS76 Soil Compactors
C7F1-Up (Machine)
C8F1-Up (Machine)
P7F1-Up (Machine)
P8F1-Up (Machine)
C7L1-Up (Machine)
C5P1-Up (Machine)
C6P1-Up (Machine)
C8P1-Up (Machine)
FCP1-Up (Machine)
JCP1-Up (Machine)
C5S1-Up (Machine)
C6S1-Up (Machine)
C8S1-Up (Machine)
FCS1-Up (Machine)
JCS1-Up (Machine)
CYX1-Up (Machine)
SAFETY.CAT.COM
KEBU7543-04 33
Operation Section
Before Operation
Daily Inspection
Before Operation SMCS Code: 1000; 7000
Do not mount a moving machine. Do not dismount a Grease all of the fittings that need to be serviced on
moving machine. Never jump off the machine. Do a daily basis.
not carry tools or supplies when you try to mount the
machine or when you try to dismount the machine. Daily, perform the procedures that are applicable to
Use a hand line to pull equipment onto the platform. your machine:
Do not use any controls as handholds when you
enter the operator compartment or when you exit the • Backup Alarm - Test
operator compartment.
• Cooling System Coolant Level - Check
Alternate Exit
• Engine Air Filter Service Indicator - Inspect
Machines that are equipped with cabs have alternate
exits. For additional information, see Operation and • Engine Oil Level - Check
Maintenance Manual, “Alternate Exit”.
• Hydraulic System Oil Level - Check
34 KEBU7543-04
Operation Section
Before Operation
• Indicators and Gauges - Test 5. Use the handle on the lock pin in order to align
the upper hole in the lock pin with the hole in the
• Neutral Start Switch - Test lock tube.
• Seat Belt - Inspect 6. Insert the quick-release pin through the lock pin
and both sides of the lock tube. Make sure that
the quick-release pin extends fully through the
i02520901
lock tube.
Steering Frame Lock
Disengage the Steering Frame
SMCS Code: 7506
Lock
1. Remove the quick-release pin.
No clearance for person in this area when machine 2. Use the handle on the lock pin in order to align
turns. Severe injury or death from crushing could the lower hole in the lock pin with the hole in the
occur. lock tube.
g01265444
Illustration 29
The steering frame lock is shown in the unlocked position.