Académique Documents
Professionnel Documents
Culture Documents
1 Page 1 from 6
Band Contact/ Manager– Tim Husom or local booking agents (see @ hauschka-et.de/contact ).
Please e-mail all venue specs/directions to venue, load in times/doors/show times curfew etc
to Tim.husom@mac.com
If anything on this rider you are unable to accommodate please let us know at least 7 days in
advance of the show and an agreement has to be made by HAUSCHKA Production otherwise
contract will be in breach
Crew Contact:
Michael Buchholz (FOH Engineer) - +49 170 9369464 tech@hauschka-net.de
HAUSCHKA SOLO Technical Rider 2014 Vers.1 Page 2 from 6
production Requirements:
Stage:
We requires a minimum stage size of twenty ft (20´) wide x twelf ft (12´) deep.
( min. 6 x 4 meter )
Stage should be smooth, level, secure, stable, and able to support Artist's equipment and
performance. Provide stairs for personnel, and ramp for equipment. It is essential that any
temporary or portable stage be properly grounded.
Mix Position:
A site for HAUSCHKA sound console oreferable in central position approximately in the centre
of the room and not under a bolcony. A free Line of sight to artist performance is a must.
N.B. If these staging requirements cannot be met The Artist must be advised immediately in
writing.
Power:
One (1) – single phase 10amp power supply (230V GermanPlug) seperate from all other house
supplies for HAUSCHKAs electronic stuff left at the musican position.
Parking:
If HAUSCHKA is travelling by Car a parking space near the Stageentry is needed.
Stage Covering:
Adequate stage covering must be provided at outdoor
shows to prevent Artist equipment from getting wet.
ELECTRICIAN:
A qualified electrician familiar with the building, to connect power supply at load-in, to be
present throughout the show, andto disconnect supply after show.
VENUE SPECS:
SPECS:
Please provide a detailed technical specification of the venue, (including sound level limits )
and a map or diagram showing its location within seven days of receipt of this rider.
HAUSCHKA SOLO Technical Rider 2014 Vers.1 Page 3 from 6
VEHICLE PERMITS:
PERMITS:
Promoter shall provide any local driving or parking permits which may be needed by touring
production vehicles.
SOUNDCHECK:
SOUNDCHECK:
We would like to have line checking for 1 hour and a soundcheck for 1/2 hour. Exact running
order for each day can be finalised between Promoter and our Production Manager /
HAUSCHKA.
PASSES:
PASSES:
The Artist production will issue local working passes as required.
**In the event of “festival conditions apply”, the festival should issue passes that have no
restrictions to the band and crew, this must include access to other stages in case the band
would like to visit other stages**
Merchandising:
A Table for HAUSCHKA merchandise is needet in entrancehall or in smaller venues in Front of
Stage.
COMMUNICATIONS:
It would be fantastic if free but protected broadband Internet connection were available for the
bands dressing room if this is password protected please sign this in the dressing room.
HAUSCHKA SOLO Technical Rider 2014 Vers.1 Page 4 from 6
PA Specification
The following is a Minimum Specification. Hauschka Management must be informed
of any significant changes at least 14 days before the engagement.
Competent in house technican must be provided!
1) Loudspeaker System
Prefered Systems are L-acoustics, JBL AXYS Targetsystem, Meyer Sound or comparable
systems.
The sound system must be in full working order and capable of faithfully reproducing the full
Audio band (40-16000Hz) @ 99dB / Lequ without audible distortion at the FOH mix position.
It is very important to have enought headroom for the uncompressed dynamic in the
performance.
We need bass for the electronical sampels and sound effects.
Please keep in mind that we make sounds like a full drumsset with bassdrum.
It is the PA providers responsibility to have equal caverage from the first row all the way till
the back of the highest balcony.
3) Monitor System
2 high quality and identical floor monitors ( Duran Audio UFM256, MeyerSound, D&B )
2 channel of graphic equalizer
HAUSCHKA SOLO Technical Rider 2014 Vers.1 Page 5 from 6
Hauschka SOLO
Ch. Input / Instrument Mic Insert Notes
1 Piano Left Schoeps Cardioid */ C414 48V Clamp**
2 Piano Right Schoeps Cardioid */ C414 48V Clamp**
3 Piano Discant Neumann KM 85i */ cond mic 48V Clamp**
4 Piano Inside Left Countryman isomax H */ Dpa 4061 48V taped Inside
5 Piano Inside Middle Left Countryman isomax H */ Dpa 4061 48V Taped Inside
6 Piano Inside Middle Right Countryman isomax H */ Dpa 4061 48V Taped Inside
7 Piano Inside Right Countryman isomax H */ Dpa 4061 48V Taped Inside
8 Piano Bottom Bass C-Ducer** 48V Taped
9 Piano Bottom Mid C-Ducer* →with XLR-Splitt 48V Taped
10 Piano PickUp Subbass Helpenstill Humbacker Short**
11 Piano PickUp Helpenstill* →with XLR-Splitt
12 BassDrum Helpenstill Humbacker Short** Feed to Mackie on Stage
13 LoopStation Submix Mackie XLR -Out Comp.
14 LoopStation Submix Mackie XLR-Out Comp.
15 Announce microphone Hauschka SM58 or equal Small Stand
16 BassDrum Loop DI-Box
Bachline Requirements:
GrandPiano (minimum Yamaha C5)
Lighting:
We need a teather like Lighting, No Moves, some Scenes with dark and warm Colors.
Video:
If possible we would like to have a Videoprojection to show the Inside of the Piano.
Please provide camera.
Thank You.
For any technical questions please contact tech@hauschka-net.de