Académique Documents
Professionnel Documents
Culture Documents
Date Checked
Subject STATUS Comments
Checked by
20. Bolt 10-5-2019 Corelia & Bari
Available in different
shape
25. Washer 10-5-2019 Corelia & Bari X Not Available
30. Clamp 10-5-2019 Corelia & Bari X Not Available
35. Bushing 10-5-2019 Corelia & Bari X Not Available
65. Inlet temperature & pressure sensor 10-5-2019 Corelia & Bari
Available in different
shape
75. Insulator 10-5-2019 Corelia & Bari X Not Accessable
80. Bolt 10-5-2019 Corelia & Bari
85. Washer 10-5-2019 Corelia & Bari
105. Bolt 10-5-2019 Corelia & Bari
110. Support 10-5-2019 Corelia & Bari
115. Nut 10-5-2019 Corelia & Bari
Verified/Approved by :
( )
ID : Page 1
POLBAN Quality System Garrett TPE331
[LOGO] INPECTION CHECKLIST Garrett AiResearch
Fuel Pump Assembly
135. Rivet 10-5-2019 Corelia & Bari
Not Available/Not
165. Packing 10-5-2019 Corelia & Bari X
Accessable
*Note : Bolt (85 & 105) and Nut (150) are attached in the triangle plate, but our group did not take
the picture, because they were passed.
Verified/Approved by :
( )
ID : Page 2
POLBAN Quality System Garrett TPE331
[LOGO] INPECTION CHECKLIST Garrett AiResearch
Fuel Pump Assembly
Date
Subject Checked by STATUS Comments
Checked
A. Inspect fuel pump assembly:
1. Perform visual inspection of
bolt external and internal
splines for wear as follows:
a. Perform visual inspection
using strong light and 10x 14-5-2019 Corelia & Bari Done
magnification
b. Minor burnish maks and
discoloration are 14-5-2019 Corelia & Bari X (External splines)
acceptable
c. Spline teeth showing no
visible wear step when
viewed from end of spline 14-5-2019 Corelia & Bari Done
and parallel to spline teeth
are acceptable
d. All internal spline showing
wear pattern types C, D
and E, shall require further
14-5-2019 Corelia & Bari X
inspection using look/see
kit or equivalent
boroscope type instrument
e. Spline teeth wear in access
of 0.005 inch is caused for 14-5-2019 Corelia & Bari (Internal splines)
replacement Acceptable
2. Perform dimensional
inspection of both internal and
external splines for wear as
follow:
a. Splnes with border line
wear conditions detected
during visual inspection
shall be replaced or (External splines)
dimentionally inspected
using a tool maker
14-5-2019 Corelia & Bari X
microscope or equivalent.
An impression mold
maybe required in
conjunction with the tool
maker microscope for
internal splines.
b. Defective internal splines
will require replacement of
the affected assembly coil
14-5-2019 Corelia & Bari
pump assembly or fuel
pump assembly. If either
assembly is replaced, a (Internal splines)
Verified/Approved by :
( )
ID : Page 3
POLBAN Quality System Garrett TPE331
[LOGO] INPECTION CHECKLIST Garrett AiResearch
Fuel Pump Assembly
Verified/Approved by :
( )
ID : Page 4