Académique Documents
Professionnel Documents
Culture Documents
by monusuthar2016
Please Vote Me for Contest In this project I am going to show you how to make a
gadget that sends the location of the site of incident,
Please vote me for contest In the project GPS module is used to detect the exact
location of vehicle. At the time of accident
Nowadays many people are died on the road due to accelerometer detects the heavy shock and Arduino
accident, the main cause is "delay in rescue". This sends the location of the vehicle to the relative or
problem is very big in devloping countries, so I friend, we can send the alert to multiple mobile
designed this project for saving the human lives. numbers.
3
7
4 6
8
9
5
https://youtu.be/MVXvnunQTUY
1. Arduino Nano: Arduino Nano is used as microcontroller unit. I used Arduino nano because it is
very small in size and doesn't need any external programmer
2. SIM 800L GSM Module: SIM 800l is GSM module, it is very small in size and we can directly mount
on PCB. Operating voltage of SIM800L is 3.7 to 4.2 voltage, so a voltage regulator LM317 is used
to give power to GSM module.
3. NEO 6m GPS Module: GPS module is used to read the values geographical location, accuracy of
this sensor is quite good.
4. Accelerometer: Accelerometer is used to detect the shock, it can seprately detect the shock in X,
Y and Z directions. We can use "vibration sensor" instant of accelerometer, but accuracy of
vibration sensor is not too good. Accelerometer can detect the vibration in X, Y, Z direction, so it is
also an positive point.
5. LCD: LCD shows the Latitude and Longitude, at the time of accident it shows notifications.
6. Power Adapter: 12 Volt 2A adapter is used to give power to system.
7. LM 317
8. Resistance: 1.1 K 1 PC
9. Resistance: 330 ohm 2 PCs
10. Resistance: 470 ohm 1 PC
11. Preset: 10k 2 PCs
12. Momentary Switch 2 PCs
In the project Printed Circuit Board is used, and PCB is designed on Eagle CAD, which is shown on Fig1, Fig2
and Fig3 and Schematic is shown in the Fig4.
Step 4: Working
Arduino Nano is used as controlling unit, it reads the values from accelerometer, when arduino observe any
abnormal values, it reads the current location from GPS module, and send it to given mobile no over SMS by using
GSM module.
Before sending the SMS arduino activate the buzzer, after 30 seconds of beeping SMS will be sent, but if
someone press the "I AM OKAY" button, message will not sent, which helps to prevent unnecessary SMS.
Download (https://cdn.instructables.com/ORIG/FX8/NWWY/JAWU3T6S/FX8NWWYJAWU3T6S.ino)
http://www.instructables.com/ORIG/FX8/NWWY/JAWU3T6S/FX8NWWYJAWU3T6S.ino
…
(https://cdn.instructables.com/ORIG/FX8/NWWY/JAWU3T6S/FX8NWWYJAWU3T6S.ino)
Is a cellular connection needed for this? How is the data sent? Nice project!
Good, keep it up
He is awesome
Very cool system. You should enter this into the Arduino contest that is currently running.