Académique Documents
Professionnel Documents
Culture Documents
.jÍÖ¬ËÖaj
8ÁjjÄÄË-ÖÍjÁ
Getting Started
1 2
The NETGEAR CD provides a graphical step-by-
step wizard that will assist you with setting up
your router.
Troubleshooting Tips 4. Click the Wireless Settings link and verify that Go to http://kbserver.netgear.com for product
the settings in the router match the settings in the updates and web support.
wireless computer exactly.
Attention: When you
Here are some tips for correcting simple
problems you may have.
Make sure the network settings of the
computer are correct.
0560 configure the wireless
settings of this device
Once the router is connected, always Both Ethernet cable and wirelessly connected
please make sure to select the correct country settings.
restart your network in this sequence: Due to EU law, the country settings must be identical
computers must be configured to obtain IP and DNS
to the country where the device is operating.
1. Turn off the modem and unplug its power cord. addresses automatically via DHCP. For help with this,
Important, due to non-harmonized frequencies in the
Turn off the router. Turn off the computer. please see the tutorials on the CD.
EU, observe these 802.11b restrictions: European
2. Plug in the power cord to the modem and turn it Check the router status lights to verify standards dictate maximum radiated transmit power
on. Wait about two minutes. correct router operation. of 100 mW EIRP and frequency range of 2.412 ~
3. Turn on the router and wait about 1 minute. 2.472 GHz. In France, the equipment must be
• The Power light should turn solid green. If after 2
4. Turn on the computer. minutes it is not, reset the router as described in restricted to 2.457 ~ 2.472 GHz frequency range and
the Setup Manual on the CD. must be restricted to indoor use.
Make sure the cables are plugged in.
• If after completing the setup, the Wireless light
• The router Internet status light will be lit if the does not come on, log in to the router and verify
Ethernet cable from the router to the modem is that the wireless feature is turned on.
plugged in securely and both the modem and
router are turned on. I don’t have a working CD drive.
• For each powered on computer connected to the Go to http://www.NETGEAR.com and download the
router with an Ethernet cable, the corresponding manual for your product from the support area of the
LAN status light will be lit. The label on the Web site. Follow the setup instructions in the manual.
bottom of the router identifies the number of each
LAN port. Technical Support
Log in to the router to make sure the
wireless settings in the router match Thank you for selecting NETGEAR products.
exactly those in the computer.
After completing the Smart Wizard configuration
The Wireless Network Name (SSID) and security assistant, locate the serial number on the bottom label
settings of the router and wireless computer must of your product and use it to register your product at
match exactly. For example, entering nETgear for the http://www.NETGEAR.com/register.
SSID is not the same as entering NETGEAR.
Registration on the web site or over the phone is ©2004 by NETGEAR, Inc. All rights reserved.
1. Use a computer connected to the router by an required before you can use our telephone support NETGEAR is a registered trademark of NETGEAR, Inc. in the
Ethernet cable. service. The phone numbers for worldwide regional United States and/or other countries.
2. Open a browser. Other brand and product names are trademarks or registered
customer support centers are on the Warranty and trademarks of their respective holders. Information is subject to
3. Log in to the router at Support Information card that came with your change without notice.
http://192.168.1.1 with the user name of admin product.
and the password of password, both in lower
case letters. August 2004