Académique Documents
Professionnel Documents
Culture Documents
www.tyco-fire.com
Contacts
GRINNELL G-FIRE
Figure 40-5 Strap (Pipe Outlet)
Americas Only
General Technical
Description Data
The GRINNELL G-FIRE Figure 40-5 Approvals
Strap is an economical alternative to UL and ULC Listed
welded pipe outlets on steel pipe. The FM Approved
Figure 40-5 Strap can be used with full Sizes
lengths of pipe and eliminates welding, Pipe Run: 1-1/4 to 2-1/2 inch (DN32 to
decreasing waste and installation time. DN65)
The Figure 40-5 Strap can be used in Outlet Thread: 1/2 to 1 Inch NPT
wet, dry pipe, and deluge systems and
is rated to a maximum pressure of 175 Housing
psi (12 bar). Ductile iron conforming to ASTM A536,
Grade 65-45-12
NOTICE Protective Coatings
The Figure 40-5 Strap described herein Clear rust inhibitive coating
must be installed and maintained in Bolts/Nuts
compliance with this document, and • ANSI
with the applicable standards of the The U-bolt is made from carbon steel
NATIONAL FIRE PROTECTION ASSO- conforming to ASTM A307 Grade A and
CIATION (NFPA), in addition to the zinc-electroplated conforming to ASTM
standards of any authorities having B633. For fire protection pressure rating,
jurisdiction. Failure to do so may impair • The flange nuts are made from carbon
listing and approval information, contact
your TYCO representative.
the performance of this device. steel conforming to ASTM A563 Grade
Owners are responsible for maintaining A, and zinc electroplated per ASTM
their fire protection system and devices B633. Fitting Size Equivalent Ft. Length
in proper operating condition. Contact • Stainless Steel U-Bolts and Nuts are ANSI Inches (1 inch Sch. 40 pipe)
the installing contractor or product available upon request.
manufacturer with any questions. 1-1/4 x 1 8
Gasket
Refer to data sheet TFP1895 for additional 1-1/2 x 1
6
gasket information. 2x1
Care and
2-1/2 x 1 4
Pressure Rating
Nominal Pipe Sizes psi (bar)
Pipe Schedulea
ANSI Inches
UL ULC FM
TABLE B
LISTED/APPROVED PRESSURE RATINGS
NATIONAL FIRE PROTECTION ASSOCIATION and NFPA are registered trademarks of National Fire Protection Association