Fax No. 0963-512344 Assistant Engineer SS&TL TESCO Sub Division Tank
No. 1058-59 /TNK-17 Dated: 21.02.2018.
The Executive Engineer,
SS & TL TESCO Division Peshawar
Subject: - ATTEND THE P/FAULT ON 132KV WANA-GOMAL ZAM DAM SECTION
REF; This Office Letter No. on dated; 15-11-2018 RE Gomal Zam Dam provided only GZD Datson & POL filled by own responsibility of lender. On dated;15-11-2018 The GZD Vehicle No. was received from CRBC D.i.khan along with Driver Shah Nawaz. After receiving the Vehicle the line staff thoroughly patrolled the above subjected T/L from Gomal Zam Power House to Sikander Check Post and went back to the headquarter Tank. On dated; 16-11-2018 the Line Staff went to Gomal Zam Dam power house and open the transmission the line jumpers and then started the remaining the patrolling from Sikander Check post to Wana GSS,during patrolling found Nos.32 Disc Insulators flashed over on tower location No.55,59,132 and 135,on yellow and blue phases. Vide PTW No.786514 replaced Nos.16 flashed over disc insulators by new ones on tower location No. 55, 59 and due to shortage of time other tower location No. 132,135 were not attended on the same date and went back to the Wana G.S.S. On dated; 17-11-2018, Remaining 16Nos flashed over disc insulators on tower location No.132,135 were replaced by new one. After completion the work, PTW cancelled and T/L energized through RCC Islamabad at 17-40Hrs and load was 12 Ampere ,which held ok. So far, 80Nos. Disc insulators have been replaced up till now out of 100Nos. On dated; 18-11-2018, Undersigned along with Line staff went back to headquarter Tank and GZD Vehicle No. was returned to RE Gomal Zam Dam,CRBC Dikhan.