Académique Documents
Professionnel Documents
Culture Documents
Where
A general expression of capillary pressure as a function of interfacial tension and curvature of the interface can be generated by
substitution of H in eq.(2-80) into the Young-Laplace eq. (2-79):
Where R1 and R2 are the principle radii of the curvature of the interface that are measured in perpendicular planes and is the
interfacial tension between the fluids. In the case of a curved interface between immiscible fluids the plus sign is used. In the case
of pendular rings (Figure 2-46) the minus sign is used.
Comparing eq.(2-81) with eq.(2-78) in capillary tube, it is found that the mean radius Rm is defined by
It is impossible to measure the values of R1 and R2 , so they are generally referred to by mean radius of the curvature and
empirically determined from other measurements on a porous medium.For a fluid-fluid interface in a capillary tube:
Where ‘r’ is the radius of the capillary and θ is the contact angle.
Wettability determines the fluid distribution in a porous medium. Wetting phase has tendency to occupy the smaller pores. In a
packing bed porous medium 2 different types of wetting phase distribution can be found, depend on the saturation of the wetting
phase. These two types are funicular distribution and pendular-ring distribution (Figure 2-47). By decreasing the wetting phase
saturation distribution type changes from funicular to pendular. In funicular distribution the wetting phase completely covers the solid
surface and is continues through the system. But by decreasing the saturation this continuity is failed and non-wetting phase is
contact with some of the solid surface and wetting phase occupies the smaller spaces (pendular distribution).
By decreaFigure 2-47: Wetting and non-Wetting Fluid Distribution About Inter Grain Contact of Sphere
sing the saturation R1 and R2 both tend to decrease in size. According to the eq.(2-68) capillary pressure increases by decreasing
the principle radii. So, capillary pressure can be expressed as a function of rock saturation when the rock is saturated by two
immiscible fluids. Also for this specific medium it is possible to find the pore distribution because capillary pressure would be
Figure 2-47: Wetting and non-Wetting Fluid Distribution About Inter Grain Contact of Sphere