Académique Documents
Professionnel Documents
Culture Documents
JOB TITLE / AIM: Jsa for cutting, grinding and welding at Check post 1 barrier
JSA DATE: 18/01/07 JSA NO./ REVISION: 00
SUPERVISOR/ JSA LEADER: Muhammad Ramzan SCRIBE: Abdullah Khan
PARTICIPANTS: Tufail
LIST ASSOCIATED PROCEDURES/WORK INSTRUCTIONS OR TEMPORARY WIs:
Attach copies of any relevant documentation/ drawings.
Part 2: Job Safety Analysis
Job Steps:
1. Mobilization of Equipment
2. Cutting, grinding and welding job
3. Demobilization
Now undertake the JSA and record in the table below. Use prompts on JSA Prompt Sheet and Hazard Checklist PA-HSEC-02-040-002-F03.
Part 3: Contingency Plans. Standard PPE,S : First aid kit must be present at the area and the Hse personnel is the first response in case of
emergency
Part 4: Review. After the job has been completed, JSA leader should note: any hazards, which were identified in the original JSA? Any practices
that need to be captured in the OMS? List action items, changes, and transfer any changes to the Change Management system.
File: 10.30
JSA No: JOB TITLE:
Step Describe Job Step Potential Hazards Hazard Controls
No (Copy from part 2 of form) (Use Hazard Checklist)
1 Mobilization of equipment Unauthorised equipment/tools brought out to Before mobilizing any equipment/tools make sure
site that the E &P Personnel got inspected the
equipment. Checklist are in equipment
Unskilled and uninducted personnel starting Ensure that all personnel prior to start the have
the job been inducted and oriented about the hazard in the
job site.
Workers starting the job unfit to work All personnel not fit to work shall not be allowed
to work at the project site.
Workers starting the job without Permit All the work to be done under BHPB OPS Hot
work permit.
Hand Injury Ensure proper hauling of materials/get help if
required/Wear hand gloves. Ensure trolley are
secured with stable support
2 Welding, grinding and cutting Cutting/Grinding /Welding slugs All the work to be done as per BHPB doc .PA-
HSEC-02-010-003-WI
Fire blanket shall be used.
DCP fire extinguisher shall be placed where
welding activity is performed.
A firewatcher shall be deputed.
Accidental activation of grinder injuring the Grinders shall be placed disc down on
grinder operator ground when not in use.
Ensure that grinder is disconnected from power
source prior to changing /adjusting discs