Académique Documents
Professionnel Documents
Culture Documents
1st Addition
SERVICE MANUAL
No.SZ12M1132LE350M
MODEL : LC-32LE350M
In the interests of user-safety (Required by safety regulations in some countries) the set should be restored to its orig-
inal condition and only parts identical to those specified should be used.
CONTENTS
SAFETY PRECAUTION
IMPORTANT SERVICE SAFETY CHAPTER 6. ADJUSTMENT
PRECAUTION................................................i [1] ADJUSTMENT....................................6-1
PRECAUTION FOR USING LEAD-FREE
SOLDER.........................................................ii CHAPTER 7. TROUBLESHOOTING TABLE
[1] TROUBLESHOOTING TABLE .........................7-1
CHAPTER 1. OUTLINE CHAPTER 8. OVERALL WIRING/BLOCK DIAGRAM
[1] OUTLINE...........................................1-1 [1] SYSTEM BLOCK DIAGRAM............................8-1
Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the
safety and performance of the set.
SAFETY PRECAUTION
SAFETY PRECAUTIONSAFETY PRECAUTIONSAFETY PRECAUTIONSAFETY PRECAUTION
LC32LE240M
5GTXKEG/CPWCN
WARNING All checks must be repeated with the AC cord plug connection
reversed. (If necessary, a nonpolarized adaptor plug must be used
1. For continued safety, no modification of any circuit should be only for the purpose of completing these checks.)
attempted.
Any reading of 0.74 Vrms (this corresponds to 0.5 mA rms AC.) or
2. Disconnect AC power before servicing. more is excessive and indicates a potential shock hazard which
must be corrected before returning the monitor to the owner.
BEFORE RETURNING THE RECEIVER (Fire &
Shock Hazard)
Before returning the receiver to the user, perform the following
safety checks: DVM
3. Inspect all lead dress to make certain that leads are not pinched, AC SCALE
and check that hardware is not lodged between the chassis and
other metal parts in the receiver. 1.5k ohm
4. Inspect all protective devices such as non-metallic control knobs, 10W
insulation materials, cabinet backs, adjustment and compartment
covers or shields, isolation resistor-capacitor networks, mechanical
insulators, etc.
5. To be sure that no shock hazard exists, check for leakage current in
0.15 µF
the following manner.
TEST PROBE
• Plug the AC cord directly into a 110-240 volt AC outlet.
• Using two clip leads, connect a 1.5k ohm, 10 watt resistor paral-
leled by a 0.15 F capacitor in series with all exposed metal cabinet
parts and a known earth ground, such as electrical conduit or elec-
trical ground connected to an earth ground. TO EXPOSED CONNECT TO
• Use an AC voltmeter having with 5000 ohm per volt, or higher, sen- METAL PARTS KNOWN EARTH
GROUND
sitivity or measure the AC voltage drop across the resistor.
• Connect the resistor connection to all exposed metal parts having a
return to the chassis (antenna, metal cabinet, screw heads, knobs
and control shafts, escutcheon, etc.) and measure the AC voltage
drop across the resistor.
///////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////
SAFETY NOTICE
Many electrical and mechanical parts in LCD colour television have For continued protection, replacement parts must be identical to those
special safety-related characteristics. used in the original circuit.
These characteristics are often not evident from visual inspection, nor The use of a substitute replacement parts which do not have the same
can protection afforded by them be necessarily increased by using safety characteristics as the factory recommended replacement parts
replacement components rated for higher voltage, wattage, etc. shown in this service manual, may create shock, fire or other hazards.
Replacement parts which have these special safety characteristics are
identified in this manual; electrical components having such features
are identified by " " and shaded areas in the Replacement Parts List
and Schematic Diagrams.
///////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////
i
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
Indicates lead-free solder of tin, silver and copper. Indicates lead-free solder of tin, silver and copper.
Soldering
• As the melting point of lead-free solder (Sn-Ag-Cu) is about 220 C which is higher than the conventional lead solder by 40 C, and as it has poor
solder wettability, you may be apt to keep the soldering bit in contact with the PWB for extended period of time. However, Since the land may be
peeled off or the maximum heat-resistance temperature of parts may be exceeded, remove the bit from the PWB as soon as you confirm the
steady soldering condition.
Lead-free solder contains more tin, and the end of the soldering bit may be easily corroded. Make sure to turn on and off the power of the bit as
required.
If a different type of solder stays on the tip of the soldering bit, it is alloyed with lead-free solder. Clean the bit after every use of it.
When the tip of the soldering bit is blackened during use, file it with steel wool or fine sandpaper.
• Be careful when replacing parts with polarity indication on the PWB silk.
Lead-free wire solder for servicing
PRICE PART
PARTS CODE DESCRIPTION
RANK DELIVERY
ZHNDAi123250E BL J 0.3mm 250g (1roll)
ZHNDAi126500E BK J 0.6mm 500g (1roll)
ZHNDAi12801KE BM J 1.0mm 1kg (1roll)
ii
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
CHAPTER 1. OUTLINE
[1] OUTLINE
PWB UNIT
OTHER UNIT
1–1
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
CHAPTER 2. SPECIFICATIONS
[1] SPECIFICATIONS
Specifications
Item Model LC-32LE350M
Screen size 80 cm
Resolution 1,049,088 pixels (1366 g 768)
Video Colour System PAL/SECAM/NTSC 3.58/NTSC 4.43/PAL 60
TV TV-Standard PAL: B/G, D/K, I SECAM: B/G, D/K, K/K1 NTSC: M
Function
Receiving VHF/UHF 48.00—863.25 MHz
Channel
CATV S1—S41ch (including Hyperband)
TV-Tuning System Auto Preset 99 ch
STEREO/BILINGUAL NICAM: B/G, I, D/K A2 stereo: B/G
Viewing angles H : 176º V : 176º
Audio amplifier/Speakers 10 W g 2 / 4 g 10 cm 2pcs
Terminals Antenna input UHF/VHF 75 q DIN type
INPUT 1 HDMI (HDMI input), AUDIO in ( 3.5 mm jack)
INPUT 2 VIDEO in, AUDIO in
INPUT 3 VIDEO in, AUDIO in, COMPONENT in
INPUT 4 (PC input) 15 pin mini D-sub, AUDIO in (common use with INPUT 1) ( 3.5 mm jack)
AUDIO OUT AUDIO out
USB USB
Headphone 3.5 mm stereo
OSD language English/Simplified Chinese/Arabic/French/Portuguese/Russian/Persian/Thai/
Vietnamese/Indonesian
Power Requirement AC 110—240 V, 50/60 Hz
Power Consumption 53 W (0.8 W Stand by)
without stand 735 (W) g 471 (H) g 113 (D) mm
Dimensions
with stand 735 (W) g 463 (H) g 167 (D) mm
Weight 7.9 kg (without stand) / 8.4 kg (with stand)
Operating Temperature 0°C — 40°C
s As a part of policy of continuous improvement, SHARP reserves the right to make design and specification changes for
product improvement without prior notice. The performance specification figures indicated are nominal values of production
units. There may be some deviations from these values in individual units.
2–1
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
Part names
TV (Front)
POWER indicator
Light off Power off.
Lighted (Red) The TV is in stand by mode.
Lighted (Green) The TV is on.
TV (Rear)
1 POWER (On/Off) button
2 MENU button
12
3 INPUT button
4 Channel up (r)/down (s) buttons
5 Volume up (e)/down (f) buttons
INPUT 1
13 6 INPUT 1 (HDMI) terminal*
AUDIO
IN
(R/L) ANT
ANALOGUE RGB
7 INPUT 4 terminal*
(PC)
INPUT 4
COMPONENT/AV
R-AUDIO-L VIDEO/Y INPUT
R-AUDIO-L
R-AUDIO-L
AUDIO OUT VIDEO
8 INPUT 3 terminals
9 AUDIO OUT terminals
10 INPUT 2 terminals
11 Antenna input terminal
11 1
6 12 USB terminal
2 13 Headphone jack ( 3.5 mm)
s The speakers do not output volume
3 when headphones are plugged in.
7
4
8
5
9
10
9 10
* The INPUT 1 and INPUT 4 terminals can both use the same audio input terminal. However, the proper item must be
selected in the “PC audio select” menu.
s The illustrations in this operation manual are for explanation purposes and may vary slightly from the actual operations.
3–1
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
3–2
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
COMPONENT/AV INPUT
R-AUDIO-L VIDEO/Y
the stand.
R-AUDIO-L R-AUDIO-L VIDEO
AUDIO OUT
3–3
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
CHAPTER 4. DIMENSIONS
[1] DIMENSIONS
Unit MM
4–1
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
6
6
44
3 3
5–1
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
3. Remove 1 screw from front angle L/R & remove front angle 3
5
4
LED WAYER
3 1 3
5–2
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
1 Hook
1
Hook
1 Hook
1 Hook
1 Hook 1 Hook
2
Figure 1
KS-Bezel
Cab-A
Lock
Note:
Make sure perfectly detech lock
5–3
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
CHAPTER 6. ADJUSTMENT
[1] ADJUSTMENT
2. Remote controller key operation and description of display in adjustment process mode.
1. key operation
* Input mode is switched automatically when relevant adjustment is started so far as the necessary input signal is available.
3. Software upgrading.
1) Plug off the LCD TV.
2) Insert the USB device to the USB terminal at the LCD TV.
(Make sure that the latest software is installed in the USB device).
3) Hold the LCD TV power key and plug on the LCD TV.
4) LCD TV is on and detecting the USB device.
6–1
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
Verifying
Verified
7) Software is successfully installed when the following appears at the end of the process.
B. ANALOG PC EDID
1 EDID INPUT Inspection mode 1. EDID data is input to IC508 (PC INPUT) at checker line.
(ANLOG PC) Ć2
2. EDID data is input before Analogue PC operation
Confirm the file checking.
name/version.
32LE350M ORCD_MM_Asia_Pack15_vXXX.bin
6–2
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
2. SIGNAL ADJUSTMENT
A. PICTURE ADJUSTMENT
Confirmation of signal from generator (setting to spec level)
PAL Composite signal ˖0.7Vp-p ± 0.02Vp-p (pedestal to white level)
15K Component signal (50Hz) ˖Y level ˖0.7Vp-p ± 0.02Vp-p (pedestal to white level)
Pb, Pr level ˖0.7Vp-p ˖0.7Vp-p ± 0.02Vp-p
33K Component signal ˖Y level ˖0.7Vp-p ± 0.02Vp-p (pedestal to white level)
Pb, Pr level ˖0.7Vp-p ˖0.7Vp-p ± 0.02Vp-Com
a) Adjustment Mode
1 Adjustment Mode Press the test key at the test remote control
1 Setting [Signal] ίFeed the COMPONENT 15K 50Hz (576i) 100% Full-field
COMP 15K 50Hz Colour Bar signal(100% colour saturation) to
(576i) COMPONENT INPUT 3
100% Full-field
Colour Bar
[Terminal]
COMPONENT 100% Whiteė ĕBlack
INPUT 3
2 Auto Adjustment Test Mode page 4 At the related page, move cursor to [COMP SD ADJ], press
(COMP SD) ENTER.
1 Setting [Signal] ίFeed the COMPONENT 33K 60Hz (1080i) 100% Full-field
COMP 33K 60Hz Colour Bar signal(100% colour saturation) to
(1080i) COMPONENT INPUT 3
100% Full-field
Colour Bar
[Terminal]
COMPONENT 100% Whiteė ĕBlack
INPUT 3
2 Auto Adjustment Test Mode page 5 At the related page, move cursor to [COMP HD ADJ], press
(COMP HD) ENTER.
1 Setting [Signal] ίFeed the XGA 60Hz 100% Checkered pattern signal
XGA 60Hz (100% colour saturation) to PC INPUT
100% Checkered 䯲Please make sure SYNC is OFF.
Pattern
[Terminal]
PC INPUT 4
2 Auto Adjustment Test Mode page 6 At the related page, move cursor to [RGB ADJ], press
(PC-RGB) ENTER.
6–3
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
1 Setting Backlight : MAX For the details of white balance adjustment procedure, please refer to
AV Mode : DYNAMIC white balance adjustment spec for Kameyama model.
Active Backlight : OFF
Set the luminance 1. Confirm the set condition.
meter on the centre
of the screen 2. Connect the white balance jig.
Write
10. Adjusted value is writing at [command] MSET0003.
MSET0003
11. Set the G of point Max. to the default value (4080 x G value of point 2 /
R2). Set the R,B Max. value [Gmax – G value of point 2 + (R,B value of
point 2)]
Set Max.Level
12. Calculate the slope R2slope, G2slope, B2slope between MAX and Point2.
MGMG**** R2slope = (Rmax - Rhigh )/(4080-3664)
MGMR****
MGMB**** 13.Calculate the correction value پRhigh, پGhigh, پBhigh.
پRhigh = R2slope X (3840-3664)
15. Calculate the slope R1slope, G1slope, B1slope between Point2 and Point1.
R1slope = (Rhigh - Rlow )/(3664-640)
6–4
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
[Adjustment value]
侀Teaching set send by engineering dept is set as reference.
3. FACTORY SETTING
AC power is plug off after shipment setting is done.
Caution: Do not plug on again after shipment setting is done. If do, please re-do the shipment setting. Do not
off with remote control.
Factory setting AC power off to exit 1. Setting is done with test remote control.
the factory setting. 2. Press the ‘Factory Setting’ key on the remote control continuously.
3. When Green background appears on screen and ‘K’ mark
disappears, setting is completed.
Model Name Factory Setting Remote Control S-System Setting OSD Language
Key Name Code Setting
6–5
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
1. Description
The Smart Loader is a function implemented in the service software to easily replicate the user settings of one TV into another.
These settings include (but not restricted to): picture and audio, turning set-up, language and country selection, PIN, child locked programs etc.
Factory adjustments are not copied as they are different for every TV.
The Smart Loader makes possible the user data to be stored in a memory device connected to the USB terminal of the TV that is used as reference
and later load those data into other TVs by using their respective USB terminal.
2. How it works
---
i) SMLD Store
To copy all related data from TV -> USB and put under a fixed filename “SHP_SMLD.bin” (8kB).
6–6
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
1) Press the “INPUT” and “VOL (+)” keys on the set at once and turn on the power.
2) Get the password input screen displayed.
Procedure
The input starts with the leftmost digit.
Use the numeric keys [1] thru [9] and [10/0] keys on the remote controller.
The other keys are not acceptable.
With a numeric-key input, “–” will change to “ “. The input position will move one digit to the right.
With all the 3 digits entered, the password will be verified.
In the adjustment process mode, turn on “PUBLIC MODE”. Also press the “CH ( )” and “VOL (+)” keys on the set at once and turn on the power.
Turn off “PUBLIC MODE” in the adjustment process mode. ( ) m This way alone is not for quitting the setup screen, but for quitting the mode by
itself.
Turn off the power with the “POWER” key. ( )
Select “EXECUTE”.( )
6–7
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
To move the cursor up and down, use the “cursor UP/DOWN” key (remote controller) and “CH ( )/( )” key (remote controller and set).
To change the settings, use the “cursor RIGHT/LEFT” key (remote controller) and “VOL (+)/(–)” key (remote controller and set).
To save new settings, keep the cursor at “Execute” and use the “cursor RIGHT/LEFT” key (remote controller) and “VOL (+)/(–)” key (remote con-
troller and set).
PUBLIC MODE
<Example of image>
5. On Setting Items
1. POWER ON FIXED
Selection Variable/Fixed
Default Variable
Explanation When set to “Fixed”, the power cannot be turned off with the power key on the remote control or main unit, and the image
reception state is kept (it does not enter the standby state).
The power can be turned off by shutting off power supply from AC.
Limit in setting Power key on the main unit/remote control power supply key
OFF timer/ON timer
Exception None
Remarks Selection of “FIXED” assumes use of STB, etc.
When set to “Variable”, if the main power switch is set to off, the power is turned off after a wait of 1 second.
(Push-push switch only)
Display ON/OFF in the hotel menu is controlled by the adjustment process “HOTEL POWERFIX”.
When the power button is operated, a caution is displayed (it times out in 5 seconds).
(For the caution, refer to the power on fixed message sheet.)
* The caution is not displayed when in the adjustment process, hotel menu, default setting, MCL operation and auto preset
(Ch search operation).
The OSD display including the menu and this caution have priority over all others.
When “OSD display” (described below) is set to “Variable”, this caution is displayed as a special case.
2. MAXIMUM VOLUME
6–8
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
8. ON SCREEN DISPLAY
9. BLUE SCREEN
12.232C POWON
6–9
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
8. ON SCREEN DISPLAY
9. BLUE SCREEN
12.232C POWON
6 – 10
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
6 – 11
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
CHAPTER 7. TROUBLESHOOTING
TABLE
[1] TROUBLESHOOTING TABLE
Are the wire harnesses and other cables properly connected in NO Reconnect the wire harnesses and other cables properly in the
the set? set.
YES
Is there the AC_CTRL and PNL_POWER signal input at pins NO Check the AC_CTRL signal line PNL_POWER signal line.
(126) and (127) of IC3301?
YES
Are the DC/DC converter outputs and the output voltages along NO Check the DC/DC converters and the control lines. Replace
the control lines as specified? defective parts as required.
7–1
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
Is there IF output from the tuner pin(10) of TU1101 as specified? NO Check TU1101 and its peripheral circuits.
YES
Is there VIF input at pin 74 & 75 of IC3301? NO Check the circuit between TU1101 & IC3301.
YES
Are there the signal outputs (pin 100-107, 109,110) of IC3301? NO Check IC3301 and its peripheral circuit.
YES
Check LVDS cable, LCD controller (incl. panel) and their periph-
eral circuits.
Is INPUT 2 selected on the input select menu screen? NO Select INPUT 2 on the input select menu screen to pick up the
right input signal.
YES
Is there the video signal input at pin (43) of IC3301? NO Check the line between pin (9) of J502 and pin (43) of IC3301.
YES
Are there the signal outputs (pin 100-107, 109,110) of IC3301? NO Check IC3301 and its peripheral circuits.
YES
Check LVDS cable, LCD controller (incl. panel) and their periph-
eral circuits.
7–2
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
Is INPUT 3 selected on the input select menu screen? NO Select INPUT 3 on the input select menu screen to pick up the
right input signal.
YES
Are there the Y, Pb and Pr signal inputs at pins (36), (34) and NO Check the line between pins (15)/(17)/(19 )of J502 and pins (36)/
(38) of IC3301 respectively? (34)/(38) of IC3301.
YES
Are there the signal outputs (pin 100-107, 109,110) of IC3301? NO Check IC3301 and its peripheral circuits.
YES
Check LVDS cable, LCD controller (incl. panel) and their periph-
eral circuits.
Is INPUT 1 selected on the menu screen? NO Select INPUT 1 on the input select menu screen to pick up the
right signal input.
YES
Are there signal outputs from SC1501 to IC3301? NO Check peripheral circuits between SC1501 and IC3301.
YES
Are there the signal outputs (pin 100-107, 109,110) of IC3301? NO Check IC3301 and its peripheral circuits.
YES
Check LVDS cable, LCD controller (incl. panel) and their periph-
eral circuits.
7–3
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
Is the IF output from the tuner pin (10) of TU1101 as specified? NO Check TU1101 and its peripheral circuits.
YES
Is there the SIF signal input at pins (77), (78) of IC3301? NO Check IC3301 and its peripheral circuits.
YES
Is there audio signal intput at pin(6) of IC1701? NO Check connection between IC3301 and IC1701 and its
peripheral circuits.
YES
Is the L-ch audio signal output at pin (26),(27) ,(30),(31) NO Check IC1701 and its peripheral circuits.
of IC1701 normal?
YES
Are the audio signal L-ch and R-ch output at (3)/(4) and (1)/(2) of NO Check circuit between IC1701 & P1701.
P1701 normal?
YES
Check speakers and their peripheral circuits.
7–4
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
YES
Is there the I2S signal output at pin (80), (81) of IC3301? NO Check IC3301 and its peripheral circuits.
YES
Is there audio signal input at pin(6) of IC1701? NO Check connection between IC3301 and IC1701 and its periph-
eral circuits.
YES
Is the L-ch audio signal output at pin(26), (27) ,(30),(31) of NO Check IC1701 and its peripheral circuits.
IC1701 normal ?
YES
Are the audio signal L-ch and R-ch output at (3)/(4) and (1)/(2) of NO Check circuit between IC1701 & P1701.
P1701 normal?
YES
Check speakers and their peripheral circuits.
7–5
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
Does the HDMI image appear onscreen? NO Refer to “<INPUT 1> in No external input video onscreen
(HDMI)”.
YES
No audio output from <INPUT 1> NO Check it if EDID is written or not.
YES
Are waveforms input in to the pin(3-6), (8), (9), (11), (12) NO Check peripheral circuits IC3301.
of IC3301 normally?
YES
Is there audio signal input at pin(6) of IC1701? NO Check connection between IC3301 and IC1701 and its periph-
eral circuits.
YES
Is the L-ch audio signal output at pin(26), (27) ,(30), (31) NO Check IC1701 and its peripheral circuits.
of IC1701 normal?
Is the R-ch audio signal output at pin(10),(11),(14),(15)
of IC1701 normal?
YES
Are the audio signal L-ch and R-ch output at (3)/(4) and (1)/(2) of NO Check circuit between IC1701 & P1701.
P1701 normal?
YES
Check speakers and their peripheral circuits.
7–6
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
YES
Is there the L-ch audio signal input from pin (2) of external input
terminal J506 (HDMI AUDIO IN) to pin (55) of IC3301?
Is there the R-ch audio signal input from pin (3) of external input
terminal J506 (HDMI AUDIO IN) to pin (56) of IC3301?
YES
Are I2S signal output from the pins (80), (81) of IC3301 normally? NO Check peripheral circuits of IC3301.
YES
Is there audio signal input at pin(6) of IC1701? NO Check connection between IC3301 and IC1701 and its periph-
eral circuits.
YES
Is the L-ch audio signal output at pin(26),(27),(30),(31) NO Check IC1701 and its peripheral circuits.
of IC1701 normal?
YES
Are the audio signal L-ch and R-ch output at (3)/(4) and (1)/(2) of NO Check circuit between IC1701 & P1701.
P1701 normal?
YES
Check speakers and their peripheral circuits.
7–7
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M SYSTEM BLOCK
㪠㪝㪂
㪠㪝㪄
㪟㪛㪤㪠㩷㪈㩷㪪㪚㪈㪌㪇㪈
㪠㪉㪚
㪨㪪㪦㪚㪱㪘㪈㪎㪌㪮㪡
㪺㫃㫂㩿㪉㪀
㪻㪸㫋㪸㩿㪋㪀
㪜㪛㪠㪛 㪫㪜㪤㪧㩷㪪㪜㪥㪪㪦㪩 㵘㵘㵘㵘
㪠㪉㪚㩿㪟㪛㪤㪠
㪠㪚㪈㪌㪇㪈 㪫㪟㪊㪊㪇㪈
㪤㪈㪈㪇㪊㪡㪈㪌
㪟㪧㪛㪇㪶㪠㪥㪆㪛㪌㪭
㪢㪜㪰㪈㪆㪉㪆㪧㪦㪮㪜㪩㩷㪪㪮
㪫㪜㪩㪤㪠㪥㪘㪣 㪟㪛㪤㪠㩷㪠㪥㪈 㪚㪜㪚㩷㪠㪥 㪪㪘㪩㩿㪇㪀㩷
㪟㪛㪤㪠㩷 㫧㪠㪝㩷㪠㪥 㪪㪘㪩㩿㪉㪀 㪪㪘㪩㩿㪈㪀
㪮㪧㪶㪚㪫㪩㪣
㪛㪛㪚㪈 㪞㪧㪠㪦㪈㪇
㪜㪜㪧㪩㪦㪤㩷㪠㪚㪌㪇㪏 㩷 㪩㪚㪆㪣㪜㪛
㪠㪩㪜㪤
㪭㪟㪠㪙㪩㪉㪋㪫㪇㪉㪡 㪠㪩㩷㪠㪥
㪠㪩㩷㪩㪼㪺㫀㪼㫍㪼㫉
P101 P151 㪩㪤㪚㪈㪇㪈
㪧㪚㩷㩷㪛㪪㪬㪙㩷㪈㪌㫇㫀㫅 㪧㪚㩿㪩㪞㪙㪀 㪣㪜㪛㪶㪞 5PIN 5PIN
㪞㪧㪠㪦㪍
BLOCK DIAGRAM
㪪㪚㪌㪇㪉 㪟㪛 S S 㪣㪜㪛
㪨㪪㪦㪚㪥㪘㪏㪇㪐㪮㪡㪨㪱 㪭㪛 㪞㪧㪠㪦㪊㪎 㪛㪈㪌㪊㪆㪛㪈㪌㪉
㪧㪚㩷㪛㪛㪚
㪣㪜㪛㪶㪩
㪧㪚㩷㪘㫌㪻㫀㫆㩷㪡㪌㪇㪍 㪣㪆㪩
㪨㪡㪘㪢㪡㪘㪇㪉㪋㪮㪡
㪚㪭㪙㪪㪆㪚㪦㪤㪧㩷㪠㪥㩷㪡㪌㪇㪉 㪰㪆㪧㪹㪆㪧㫉
㪨㪡㪘㪢㪣㪘㪇㪊㪎㪮㪡㪨㪱 㪚㪭㪙㪪㩷㪸㫅㪻㩷㪘㫌㪻㫀㫆㩷㪣㪆㪩 㪚㪭㪙㪪
㪚㪦㪤㪧
㪚㫆㫄㫇㩷㪘㫌㪻㫀㫆㩷㪠㪥㩷㪡㪌㪇㪊 㪘㪬㪛㪠㪦
㪨㪡㪘㪢㪝㪘㪇㪍㪏㪮㪡㪨㪱 㪣㪆㪩
CHAPTER 8. OVERALL
㪨㪡㪘㪢㪱㪘㪉㪏㪋㪮㪡㪨㪱
㪤㫆㫅㩷㪣㪆㪩㩷㪦㪬㪫㩷㪡㪌㪇㪌 㪤㫆㫅㫀㫋㫆㫉㩷㪘㫌㪻㫀㫆㩷
㪤㫆㫅㩷㪘㫄㫇㩷㪺㫀㫉㪺㫌㫀㫋
㪨㪡㪘㪢㪝㪘㪇㪍㪏㪮㪡㪨㪱 POWER UNIT
㪟㪧㩷㪡㪌㪇㪋 㪟㪧㩷㪘㫄㫇㩷㪺㫀㫉㪺㫌㫀㫋㩷
㪟㪧㩷㪘㫌㪻㫀㫆㩷㫆㫌㫋
㪨㪡㪘㪢㪡㪇㪈㪇㪈㪪㪜 㪧㪛 㪧㪛
㪟㪧㩷㪛㪼㫋
㪬㪩㪂㪈㪉㪅㪉㪭 㪬㪩㪂㪈㪉㪅㪉㪭
㪞㪥㪛 㪞㪥㪛
WIRING
㵘
㪤㪪㪫㪍㪈㪇㪇㪭㪪 㪧㪪㪶㪦㪥 FFC 㪧㪪㪶㪦㪥
㪜㪩㪩㪦㪩 㪜㪩㪩㪦㪩 㪜㪩㪩㪦㪩
㪩㪼㪽㩷㪥㫆㪅㪠㪚㪊㪊㪇㪈 㪦㪝㪣 㪦㪝㪣
㪦㪝㪣
㪪㪫㪙 㪪㪫㪙 CN1
㪩㪟㪄㪠㪯㪛㪇㪊㪌㪊㪮㪡㪱㪱㪨 㪧㪥㪣㩷㪪㪫㪙
2pin
/
LED1_A
LED1_K
8–1
LED BAR
CN1 (2pin)
䊌䊈䊦㔚Ḯ
LED1_A
㪉㪐㪑㩷㪈㪉㪭
㪻㪸㫋㪸㩷㪘㩿㪏㪀 㪻㪸㫋㪸㩷㪘㩿㪏㪀 LED1 K
㪣㪭㪛㪪㩿㪏㪹㫀㫋㪀 㪺㫃㫂㩷㪘㩿㪉㪀 㪧㪉㪍㪇㪈 㪺㫃㫂㩷㪘㩿㪉㪀
㪊㪇㩷㫇㫀㫅
䊝䉳䊠䊷䊦
㪊㪉㩷㪑㩷㪮㪯㪞㪘
㪯㪫㪘㪣㩿㪉㪋㪅㪇㪤㪟㫑㪀
㪯㪠㪥㪆㪯㪦㪬㪫 㪯㪊㪊㪇㪈
㪩㪚㪩㪪㪚㪘㪉㪊㪐㪮㪡㪨㪱㪰
㪠㪉㪚㩷
㪜㪜㪧㪩㪦㪤㩿㪟㪛㪚㪧㪀
㪠㪉㪚 㪠㪚㪏㪋㪇㪊
㪩㪟㪄
㪠㪯㪛㪈㪈㪇㪮㪡㪱㪱㪨
㪠㪉㪚㩷
㪜㪜㪧㪩㪦㪤㩿㪛㪘㪫㪘㪀
㪠㪉㪚 㪠㪚㪏㪋㪇㪉
㪛㪩㪘㪤㩷㪠㪝 㪘㪬㪛㪠㪦㪶㪦㪬㪫 㪪㪧㪠㩷㪠㪆㪝
㪭㪟㪠㪩㪉㪋㪈㪉㪏㪘㪪㪄㪈㪰
㩷
㪪㪧㪠
㪟㪆㪮㩷㪩㪜㪪㪜㪫
㪠㪉㪪
㪠㪉㪪
㪪㪧㩷㪤㪬㪫㪜
㪘㪬㪛㪠㪦㩷㪘㪤㪧
㪠㪚㪉㪎㪇㪋
㪤㪘㪠㪥 㪭㪟㪠㪰㪛㪘㪈㪍㪋㪛㪱㪄㪈㪰
㪪㪧㪶㪣
㪪㪧㪶㪩
㪪㪧㪧㪉㪎㪇㪈
㪨㪧㪣㪞㪥㪙㪇㪐㪉㪮㪡㪱㪱㪰
㪪㪧㪶㪩
㪪㪧㪶㪣
㵘㵘㵘㵘㵘㵘㵘
㪪㪧 㪣 㪪㪧 㪩
㪋㪆㪏㱅㪈㪇㪮 㪋㪆㪏㱅㪈㪇㪮
LC-32LE350M
LC-32LE350M
H Main ( A-Chip )
1 2 3 4 5 6 7 8 9 10
9–1
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
Main ( B-Symbol )
H
1 2 3 4 5 6 7 8 9 10
9–2
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
[2] LED_IR Unit
H
LED A -Chip LED A -Symbol
1 2 3 4 5 6 7 8 9 10
9–3
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
H
LED B -Chip LED B -Symbol
1 2 3 4 5 6 7 8 9 10
9–4
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
CAUTION:
This circuit diagram is original one, therefore there may be a slight
difference from yours.
SAFETY NOTES:
1) DISCONNECT THE AC PLUG FROM THE AC OUTLET
BEFORE REPLACING PARTS.
2) SEMICONDUCTOR HEAT SINKS SHOULD BE REGARDED AS
POTENTIAL SHOCK HAZARDS WHEN THE CHASSIS IS
OPERATING.
10 – 1
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
(MASTER)
H
LC-32LE350M MAIN1 (TUNER)
TL1112
TU1101
NQA073WJQZ
TL1101
TL1102
TL1103
TL1104
TL1105
TL1106
TL1107
TL1108
TL1109
TL1110
TL1111
C1103 4.7K 4.7K
0.1u *R1109 *R1110
25V (PWB) (PWB)
(PWB)
CIL
FB1101 *L1101
0253TA CCZ C
10uH *C1101 *
(PWB)
(PWB) (PWB) (PWB) (PWB)
C1108 C1104 *C1105 *C1106 47P 4
ASY *R1114 R1107 R1108
F 1000P
50V
*C1107
10u
16V
10u
16V
10u
16V
3.3K 100 100
330u
16V
TUNER_RESET
R1116
I2C_DAT
I2C_CLK
10K
IF_IN+
IF_IN-
C1116
0.1u
(PWB) (PWB)
*R1111 *R1112
100 0
(PWB)
C1118 *C1117
0.01u
0.022u
E
*R1113
47K
(PWB)
IF_IN-
IF_IN+
I2C_DAT
I2C_CLK
TAGC
DUNTKG165WE
1 2 3 4 5 6 7 8 9 10
10 – 2
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
LE350_PP(2012.10.16)
TL1112
TO MAIN10(POWER)
D+3.3V
D+3.3V
4.7K 4.7K
1109 *R1110
PWB) (PWB)
CCZ CCZ
*C1101 *C1102
(PWB) (PWB)
47P 47P
TO MAIN5(CPU)
TUNER_RESET
C1109 CZ
0.1u R1101 R1104 C1111
33 0.1u
IF_IN- 180
VIFM
CIL
C1115 L1102
CZ
180P 100nH C1112
R1102 R1103
33 0.1u
IF_IN+ 180
VIFP
C1110
0.1u C1113 C1114
22P 22P
I2C_DAT
I2C_DAT
I2C_CLK
I2C_CLK
TAGC
TAGC
10 11 12 13 14 15 16 17 18 19
10 – 3
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
(MASTER)
H
LC-32LE350M MAIN2 (HDMI-TERM)
INPUT1 SC1501
ZA347WJQZ
D1510 D1516 *D1501
E DB2S310L DB2S310L DB2S310L
24 25 *TL1510 Q1501
20 *R1507
2 4 6 8
21 R1511 LTC044EEB 47K
10 12 14 16 18 47K CZ CZ
1 3 5 7 11 13 15 17 19
9
22
23
R1505
*R1502
1K
4.7K 1 3
(PWB) (P
*TL1507
4
*TL1501
D
(PWB) (PWB) 1 3
HDMI0_CLKN
*D1505 *D1508
1SS226 1SS226
HDMI0_CLKP 3 3 R1504
R1503 10
HDMI0_D0N
4
47K
CZ
HDMI0_D0P
1 2 1 2
HDMI0_D1N
*TL1502
*TL1503
*TL1505
HDMI0_D1P
8 7 6 5
HDMI0_D2N C1501
*SG1513 *SG1519 10u VCC VCLK SCL SDA
*SG1507
C VXA187WJQZ
(PWB)
VXA187WJQZ
(PWB)
VXA187WJQZ
(PWB)
HDMI0_D2P 16V
KZA837WJQZ IC1501
BR24T02J
*SG1522 C1502 EEPROM
*SG1501 0.01u
VXA187WJQZ A0 A1 A2 GND
VXA187WJQZ 25V
(PWB)
(PWB) CZB
1 2 3 4
A DUNTKG165WE
1 2 3 4 5 6 7 8 9 10
10 – 4
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
M) LE350_PP(2011.11.12)
TO MAIN10(POWER)
D+5V
D+5V
BU+3.3V
BU+3.3V
R1510
10K
;E M M 3N G !&M W !J ;E 8~ $1$O I > 2A %\ !<%I D L $j !K Q1503 CZ
*TL1506
*D1501
DB2S310L LTC044EEB
*R1507
47K Q1502
CZ
LTC044EEB TO MAIN5(CPU)
(PWB)
HPD_+5V_IN
*R1509
0
(PWB) (PWB) HPD_CTRL
*R1506 *R1508
WP_CTRL
0 CZ 0 CZ
HDMI_DAT
HDMI_CLK
1 3
R1504
10 HDMI0_CLKN
2
HDMI0_CLKP
HDMI0_D0N
*TL1502
*TL1503
*TL1505
HDMI0_D0P
7 6 5
HDMI0_D1N
2 3 4
*D1502
1SS420
*R1546
27K
F CZ
R1547
200
HDMI_CEC
HDMI_ARC
10 11 12 13 14 15 16 17 18 19
10 – 5
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
H (MASTER) MAIN3(TERMINAL)
LC-32LE350M
CO
10 9 20
G
*TL540 *TL545
*TL529
*TL566
*TL542
*TL565
VXA005WJ
VXA005WJ
VXA005WJ
VXA005WJ
*VA533
(PWB)
*VA519
*VA532
*VA518
(PWB)
(PWB)
(PWB)
*C530
56P
F R533 R549
R548
75
75 75 R534 TQ
TQ TQ 10K
(PWB)
*C531
1000P
USB:500mA max
J501
ZA284WJQZ R532
12K
USB Atype Right Angle
*TL514
GND
4
*TL515 USB_D0P
CVBS_AUD_L
USB_DP
3
COMP1_Pb
COMP1_Pr
*TL516 USB_D0N
CVBS1
USB_DN
2
*TL517
*VA505 *VA506
+5V
1
VXA074WJ VXA074WJ
E
39V 39V
1.1pF 1.1pF
*TL584
5 4
*TL579
Vout Vin
C503 C581
10u 10u *TL580
16V IC510 16V
KZA837WJQZ 3479A50P KZA837WJQZ
ON GND N.C.
*TL558
1 2 3
PC_R
C582 *TL556
(PWB)
0.1u
(PWB) *C549
*TL553 R582
75 5P
*VA528 TQ CH
VXA005WJ
*TL501 SC502
NB037WJQZ
PC_G
*C550
(PWB) R583
75 5P
17
16
10
6
7
8
9
*VA529 TQ CH
*TL550
VXA005WJ
11
12
13
14
15
PC_B
(PWB)
*C551
*TL544
*TL546
*TL555
*TL552
(PWB) R584
75 5P
*VA530 TQ CH
VXA005WJ
R577
*TL547 10K J
2 PC_AUD_L
3 *TL548
C PC AUDIO R578
10K J R613
PC_AUD_R R614
100
100
C543 R581 C548
(PWB) 56P 1000P *C560
12K R610 *C561
*VA524 R611
2.2K 47P 47P
VXA005WJ 2.2K
(PWB) (PWB)
1 2 3 4 5 6 7 8 9 10
10 – 6
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
LE350_PP(2012.10.16)
J502 LA047WJQZ
HP SIDE
J504
J0101SE
10 9 20 19 8 7 18 17 6 5 16 15 4 3 14 13 2 1 12 11 7 6 2 3 4 5 1
*TL510
*TL509
*TL508
*TL511
*TL545 *TL568 *TL538 *TL562 *TL559 *TL537 *TL534 *TL528 *TL530
*TL529
*TL524 C501
0.01u
VXA005WJ
VXA005WJ
*TL565 *TL535
*VA508
*VA507
(PWB)
(PWB)
*VA511
(PWB)
*TL543 *TL564 *TL536 *TL527
VXA005WJ
R506 R510
VXA005WJ
VXA005WJ
VXA005WJ
VXA005WJ
VXA005WJ
VXA005WJ
R503
100K 100K
*VA509
*VA531
*VA520
(PWB)
*VA532
*VA510
(PWB)
(PWB)
(PWB)
*VA515
(PWB)
(PWB)
1K
(PWB)
*VA516
VXA005WJ
*R504
0 *C502 *C504
*C527
10P 10P
1000P
*C526
1000P
TO MAIN5(CPU)
*C532 *C517 *C514
56P 56P 56P COMP1_Y
R528 R526
100 COMP1_Pb
R548 100
75 1/4W R516 1/4W R513
TQ R536 R547
75 10K 10K COMP1_Pr
10K
TQ
*C509 CVBS1
(PWB) *C508 (PWB)
(PWB) 0.01u
*C518 *C515
*C533 0.01u
1000P 1000P
1000P
R527
R525
100K 100K
COMP_AUD_L
R515 R511
R535
12K 12K
12K COMP_AUD_R
MON_R_OUT
MON_L_OUT
HP_R_OUT
HP_L_OUT
COMP1_Pb
HP_PLUG
COMP1_Y
WP_CTRL
R/C
IR_PASS
UART_DEBUG_RX
PC_R
UART_DEBUG_TX
PC_G
PC_B
PC_HSYNC_IN
PC_R (PWB) (PWB)
(PWB) *R633 *R634 PC_VSYNC_IN
D510 10K 10K
*C549
BAV70
5P PC_AUD_L
CH *TL567
1 PC_AUD_R
3
PC_G 2 R625
R608 R607 J
(PWB) 47K 47K
47K UART_232C_TX
*C550 R616 *TL502
100
5P UART_232C_RX
CH *TL503
UART_DEBUG_RX
R615 *TL578
100 UART_DEBUG_TX
PC_B
(PWB) USB_D0P
*C551
8 7 6 5
5P USB_D0N
CH C565 VCC VCLK SCL SDA
10u HP_PLUG
16V
KZA837WJQZ
IC508
C566 BR24T02J
0.01u EEPROM
25V A1 A2 GND
A0
1 2 3 4
TO MAIN9(AUDIO_AMP)
WP_CTRL HP_R_OUT
HP_L_OUT
MON_R_OUT
MON_L_OUT
*C561
47P
(PWB)
PC_HSYNC_IN
PC_VSYNC_IN
B) (PWB)
03 *VA504
005WJ VXA005WJ
TO MAIN10(POWER)
D+5V
M+5.6V
BU+3.3V
(PWB)
*P501
NB047WJ
TL504
3.3V 1
TL505 UART_232C_TX
UART TX 2
TL506 UART_232C_RX
UART RX 3
TL507
GND 4
R/C 5
IR PASS 6
5V 7
10 11 12 13 14 15 16 17 18 19
10 – 7
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
(MASTER)
LC-32LE350M MAIN5 (CPU)
H
TO MAIN10(POWER)
D+2.5V
D+3.3V
D+1.8V
G PANEL_POW
D+5V
AC_CTRL
TO MAIN6(DDR)
POW_CHK
PWM0_OFL
IR_PASS
A_DDR_D9
A_DDR_D6
A_DDR_D1
A_DDR_D3
A_DDR_D4
A_DDR_A1
A_DDR_A3
A_DDR_A5
A_DDR_A7
A_DDR_A9
A_DDR_DQM0
A_DDR_DQM1
A_DDR_D14
A_DDR_D12
A_DDR_D11
A_DDR_A10
A_DDR_A12
A_DDR_DQS0N
A_DDR_DQS0P
A_DDR_CLKEN
DDR_VREF
A_DDR_WE#_HSS
A_DDR_BA1_HSS
A_DDR_BA0_HSS
A_DDR_BA2_HSS
DDR_VREF FB3302 FB3303 FB3304
A192WJ A192WJ A192WJ
A_DDR_DQM0
A_DDR_DQM0
A_DDR_DQM1
TO MAIN1(TUNER) A_DDR_DQM1
C3302 C3318
C3304 C3306
VIFP A_DDR_DQS0N 10u 10u
A_DDR_DQS0N 16V 0.1u 0.1u
16V
KZA837WJQZ
VIFM A_DDR_DQS0P KZA837WJQZ
A_DDR_DQS0P
TP3308
A_DDR_DQS1N
A_DDR_DQS1N
A_DDR_DQS1P
A_DDR_DQS1P
A_DDR_D0
I2C_CLK A_DDR_D0
A_DDR_D1
I2C_DAT A_DDR_D1
A_DDR_D2
A_DDR_D2
TUNER_RESET
(PWB)
*R3302 A_DDR_D3
A_DDR_D3
5.6K
(PWB) T_AGC A_DDR_D4 C3320 C3331
C3322 C3324 C3326 C3327
TAGC A_DDR_D4 0.1u 0.1u
F
*R3349 0.1u 0.1u 0.1u 0.1u
0 A_DDR_D5
(PWB) (PWB) A_DDR_D5 C3321
*C3361 2.2u
*C3362
A_DDR_D6
0.022u 0.1u A_DDR_D6 162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131
A_DDR_D7
A_DDR_D7
PWM1
PWM0
VDDC
WEZ
DQSL
DQMU
DQML
MCLKE
DQSLZ
DVDD_DDR
AVDD_DDR
AVDD_DDR
AVDD_DDR
AVDD_DDR
A_DDR_D8 C3311
MADR[1]
MADR[3]
MADR[5]
MADR[7]
MADR[9]
MADR[12]
BADR[1]
BADR[0]
BADR[2]
MDATA[9]
MDATA[6]
MDATA[1]
MDATA[3]
MDATA[4]
MADR[10]
A_DDR_D8
MDATA[14]
MDATA[12]
MDATA[11]
0.1u AVDD_
USB_PLUG A_DDR_D9 163 MEMPLL
TP3307
A_DDR_D9
A_DDR_DQS1P
R3316 C3350 A_DDR_D10 164 DQSU
33 0.047u RCA_CVBS2_IN A_DDR_D10
A_DDR_DQS1N
TO MAIN3(TERMINAL) A_DDR_D11 165 QDSUZ
A_DDR_D11
A_DDR_D15
CVBS input A_DDR_D12 166 MDATA[15]
A_DDR_D12
R3304 C3308 A_DDR_D8
33 0.047u RCA_CVBS1_IN A_DDR_D13 167 MDATA[8]
CVBS1 A_DDR_D13
E
COMP1_Pr
R3371 A_DDR_A1 0.1u
C3374 A_DDR_A1
68 0.047u COMP1_YINM 175 AVDD_DDR
C3313
A_DDR_A2 A_DDR_D5
A_DDR_A2 0.1u
176 MDATA[5]
A_DDR_A3 A_DDR_CLKP_400MHz
PC input A_DDR_A3
177 MCLK
*C3305
R3359 A_DDR_A4
C3368 A_DDR_A4 12P
33 0.047u PC_GINP 178 AVDD_DDR
PC_G (PWB)
C3377 A_DDR_A5
A_DDR_A5 A_DDR_CLKN_400MHz
1000P PC_SOGIN 179 MCLKZ
R3360 A_DDR_A6 A_DDR_ODT_HSS
C3369 A_DDR_A6
33 0.047u PC_BINP 180 ODT
PC_B
R3358 A_DDR_A7
C3367 A_DDR_A7 A_DDR_RAS#_HSS
33 0.047u PC_RINP 181 RASZ
PC_R
R3373 A_DDR_A8 A_DDR_CAS#_HSS
C3375 A_DDR_A8
68 0.047u PC_GINM 182 CASZ
A_DDR_A9 A_DDR_A0
A_DDR_A9 183 MADR[0]
PC_HSYNC_IN
PC_HSYNC_IN A_DDR_A10
A_DDR_A10 A_DDR_A2
184
*IC3301
MADR[2]
C3314
A_DDR_A11 RH-IXD454WJQZQ
PC_VSYNC_IN A_DDR_A11 0.1u
PC_VSYNC_IN 185 AVDD_DDR
A_DDR_A12 A_DDR_A4
A_DDR_A12 186 MADR[4]
AUDIO input
A_DDR_ODT_HSS A_DDR_A6
CVBS_AUD_L
C3360 10V
AUD_L0
A_DDR_ODT_HSS 187 MADR[6] MST6100VS
2.2u KZA115WJ A_DDR_RAS#_HSS
CVBS_AUD_L A_DDR_RAS#_HSS A_DDR_A8
C3363 10V 188 MADR[8]
CVBS_AUD_R 2.2u KZA115WJ AUD_R0 A_DDR_CAS#_HSS
CVBS_AUD_R A_DDR_CAS#_HSS A_DDR_A11
189 MADR[11]
C3315 10V A_DDR_CLKEN
COMP_AUD_L 2.2u KZA115WJ AUD_L1 A_DDR_CLKEN
D
COMP_AUD_L 190 MADR[13]
C3316 10V A_DDR_WE#_HSS
COMP_AUD_R 2.2u KZA115WJ AUD_R1 A_DDR_WE#_HSS
COMP_AUD_R 191 VDDC
C3309
A_DDR_CLKP_400MHz I2C_DAT
C3372 10V A_DDR_CLKP_400MHz 0.1u
PC_AUD_L AUD_L2 192 DDCR_DA
2.2u KZA115WJ
PC_AUD_L
A_DDR_CLKN_400MHz
C3373 10V A_DDR_CLKN_400MHz
PC_AUD_R AUD_R2 193 VDDP
2.2u KZA115WJ C3310
PC_AUD_R
I2C_CLK 0.1u
194 DDCR_CK
195 GND
USB_D0P
196 USB0_DM
USB_D0N
197 USB0_DP
C3317
WP_CTRL 0.1u
FB3301 198 AVDD_ALIVE
A192WJ
(PWB) *Q3304 VS
R/C (PWB)
RT1N141C *R3369 199 BYPASS
IR_PASS 10K C3319
1u 200 GND
UART_DEBUG_TX (PWB) SPI_CLK
*C3379 201 SCK
0.1u
UART_DEBUG_RX SPI_DI_DAT
10V 202 SDI
POW_CHK SPI_DO_DAT
1 VCC 8 203 SDO
UART_232C_TX
SPI_CS0N
204 SCZ
UART_232C_RX
2 7 R3343
KEY1
2.7K 205 SAR0
C
HP_PLUG KEY2
206 SAR1
3 6
TEMP
207 SAR2
C3344 PSW_IN
4 GND 5 0.01u 208 GPIO10
TO MAIN9(AUDIO_AMP)
TH3301 DDCA_CLK
M1103J15 209 DDCA_CK
R3352
*IC3303 0 DDCA_DAT
210 DDCA_DA
HC2G66DP (PWB)
HP_L_MUTE LED_G
211 GPIO6
HP_OUT_0L USB_PLUG
HP_L 212 GPIO7
R3319
1K EEP_WP
AD_SEL 213 GPIO8
HP_OUT_0R
HP_R HPD_+5V_IN
R3320 214 GPIO9
1K
R3301 C3301 R3313 C3303 R/C
215 IRIN
220K 220P 220K 220P
HDMI_CEC
216 CEC
Pure NC Pins
DDCDA_DA
DDCDA_CK
HOTPLUGA
AVDD_126
HWRESET
AVDD_33
RXACKN
RXACKP
HSYNC0
VSYNC0
SOGIN0
RXA0N
RXA2N
RXA0P
RXA1N
RXA1P
RXA2P
GIN0M
TO MAIN2(HDMI-TERM)
GIN0P
RIN0P
BIN0P
VDDC
GND
ARC
NC
NC
NC
NC
NC
NC
NC
NC
NC
HDMI0_CLKN R3324 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
R3323 Q3302 22K
4.7K
TL3301
LTC014EEB
HDMI0_CLKP TL3302
VS C3325
R3335
R3331
R3334
R3330
R3332
R3327
R3328
R3333
HW_RESET
0
0
0
0
0
0.047u
GND
HDMI0_D0N
OUT
1
R3325
B
HDMI0_D0P 1K
VDD
CD
HDMI0_D1N
C3330 0.1u 0.1u 0.1u
0.01u
HDMI0_D1P
IC3302 CZB
56
R3306
HDMI0_D2N PST8429U
HDMI0_D2P
RESET IC
A192WJ
FB3305
C3329
0.1u
GND
NC
3
10V
HDMI_DAT
VDD
2
HDMI_CLK
OUT
1
5
CT
HPD_CTRL
HPD_+5V_IN
*IC3306
WP_CTRL
BU4229G (PWB)
HDMI_CEC
HDMI_ARC
A
PC_HSYNC_IN
PC_VSYNC_IN
HDMI0_CLKN
HDMI0_CLKP
HDMI0_D0N
HDMI0_D1N
HDMI0_D2N
HDMI0_D0P
HDMI0_D1P
HDMI0_D2P
HPD_CTRL
HDMI_ARC
PC_SOGIN
HDMI_DAT
HDMI_CLK
PC_GINM
PC_GINP
PC_RINP
PC_BINP
1 2 3 4 5 6 7 8 9 10
10 – 8
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
LE350_PP(2012.11.05)
R3337
33K
4
R3321 (PWB) (PWB)
2.7K *R3318 *R3375
4.7K 4.7K
3
TO MAIN11(KEY)
R/C
LED_G
FB3308
INV_POW
AC_CTRL
PWM0_OFL
LAMP_ERR
IR_PASS
A_DDR_A1
A_DDR_A3
A_DDR_A5
A_DDR_A7
A_DDR_A9
A192WJ
A_DDR_A10
A_DDR_A12
FB3313 LED_R
A_DDR_BA2_HSS
A192WJ
FB3307
R3353
R3336
A192WJ
10K
10K
C3341
10u
16V
KZA837WJQZ R3338
1K
KEY1
4 3 KEY_1
TP3308
KEY2
2 1 KEY_2
RXE_D0N
RXE_D0P
TP3305
PSW_IN
PSWIN
TO MAIN8(PANEL)
R3345
(PWB) 1K
RXE_D0N *C3349
0.1u
10V
RXE_D0P
C3351 C3352 C3353
C3336
0.1u
C3335 CCZ
C3327 C3331 C3333 CCZ CCZ
0.1u 0.1u 0.1u RXE_D1P
0.1u
C3337
RXE_D2N
141 140 139 138 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 RXE_D2P
C3340
0.1u
PWM1
PWM0
RXE_CLKN
VDDC
VDDC
VDDP
LVB0M
LVB1M
LVB2M
LVB3M
LVB4M
R3430
LVB0P
LVB1P
LVB2P
LVB3P
LVB4P
LVA0M
LVBCKM
LVA0P
AVDD_MOD
LVBCKP
GPIO77
GPIO76
GPIO75
GPIO74
MADR[1]
MADR[3]
MADR[5]
MADR[7]
MADR[9]
MADR[12]
AVDD_LPLL
BADR[2]
10K
MADR[10]
RXE_CLKP TO MAIN7(FLASH)
_
RXE_D3P
LVA3P 100
LVA4M 99
LVA4P 98
Pure NC Pin NC 97
TO MAIN9(AMP)
PWM2 AD_SEL
96 L_MUTE
L_MUTE
USB1_DP USB_D0P
95
LINE_OUT_L
USB_D0N MONITOR_L
USB1_DM 94 R3361
1K
TUNER_RESET
GPIO38 93 LINE_OUT_R
MONITOR_R
LED_R R3362
GPIO37 92 1K (PWB) (PWB)
*C3378 R3364 *C3380 R3368
GPIO36 SPI_WP 220P 220P 220K
91 220K
I2S_OUT_BCK I2S_OUT_SCLK
90
I2S_OUT_MCK I2S_OUT_MCLK
89
I2S_OUT_LRCLK *E3301
I2S_OUT_WS 80 RA912WJFW
TAGC T_AGC
79
C3381
SIFM 78 0.1u
10K
10K
C3382
*R3317
TO MAIN10(POWER)
R3346
SIFP 77 0.1u
FB3312 C3348
A192WJ 0.1u FB3314 LAMP_ERR
AVDD_PGA 76 LAMP_ERR
A192WJ
VIFP *Q3303
VIFP 75
LTC014EEB
VIFM VIFM VS
74
INV_POW
C3346 INV_POW
PGA_COM 73
0.1u
FB3315 PWM0_OFL
A192WJ PWM0_OFL
AVDD_REF 72
AVDD_DMPLL 71
C3347 FB3316
0.1u A192WJ
XOUT 70
R3347
C3358
XIN 69 470
10P
3 4
(PWB)
NC 68 *R3348
1M
2 1
Pure NC Pins NC 67
X3301
NC 66
24MHz
HP_OUT_0R C3357 I2C_CLK
AUOUTR0 65 SCA239WJQZ 10P 3 4
HP_OUT_0L I2C_DAT
AUOUTL0 64 1 2
LINE_OUT_R
AUOUTR1 63 R3350
4.7K
LINE_OUT_L
AUOUTL1 62
FB3317
A192WJ
AVDD_AU33 61
AUR4 60
C3345
0.1u
AUL4 59 UART_232C_RX
3 4 3 4
*R3370
AUR3 58 UART_232C_TX 0
1 2 1 2
AUL3 57
UART_DEBUG_RX R3351
AUD_R2 4.7K
AUR2 56
UART_DEBUG_TX
AUD_L2
AUL2 55
AVDD_AU25
CVBSOUT0
DDCA_CLK
AVDD_126
AVDD_25
AVDD_33
3 4
HSYNC0
VSYNC0
IC CONFIGURATION
SOGIN0
SOGIN1
AUVAG
AUVRP
R3329
CVBS4
CVBS2
CVBS3
CVBS1
CVBS0
GIN0M
GIN1M
GIN0P
VCOM
RIN0P
BIN0P
VDDC
GIN1P
RIN1P
BIN1P
AUR0
AUR1
AUL1
AUL0
GND
DDCA_DAT 10
NC
NC
I2S_OUT_SCLK (PWB) 1 2
*R3307
22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 4.7K
R3308
C3365 4.7K
10u C3364 (PWB)
10u I2S_OUT_MCLK *R3309
TP3304 16V
4.7K
C3371 C3370
0.1u 0.1u R3310
4.7K
IR_PASS (PWB)
*R3311
C3328 C3332 C3334 C3338 C3339 4.7K
A192WJ
FB3310
A192WJ
FB3305
FB3306
A192WJ
EEP_WP
WP_CTRL
6 5 4
Q3301
UPUMD2
1 2 3
RCA_CVBS1_IN
RCA_CVBS2_IN
COMP1_SOGIN
PC_HSYNC_IN
COMP1_PbINP
PC_VSYNC_IN
COMP1_PrINP
COMP1_YINM
COMP1_YINP
PC_SOGIN
PC_GINM
PC_GINP
PC_RINP
PC_BINP
AUD_R0
AUD_R1
AUD_L0
AUD_L1
VCOM0
10 11 12 13 14 15 16 17 18 19
10 – 9
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
(MASTER)
H LC-32LE350M MAIN6(DDR
TO MAIN10(POWER) FL3501
NA119WJ
010
D+1.8V
G
R3526 R3525
1K 1K
F
TO MAIN5(CPU) F
*R3529 0 VREF_DDR_0.9V
DDR_VREF
A_DDR_DQM0
A_DDR_DQM1
F A_DDR_DQS1P A_DDR_D2
5 6
DDRA_D2 A_DDR_D9
5 6
DDRA_D9
3 4 3 4
A_DDR_D0 A_DDR_D5 DDRA_D5 A_DDR_D14 DDRA_D14
1 2 1 2
A_DDR_D1
R3504 R3515
A_DDR_D2 56
56
A_DDR_DQS0N DDRA_DQS0N
A_DDR_D4 DDRA_D4
A_DDR_D3 7 8
R3505 A_DDR_D3 DDRA_D3
A_DDR_D4 5 6
56
A_DDR_DQS0P DDRA_DQS0P
A_DDR_D1 DDRA_D1
A_DDR_D5 3 4
R3506 A_DDR_D6 DDRA_D6
A_DDR_D6 1 2
56
A_DDR_DQM0 DDRA_DQM0
A_DDR_D7
R3516
E A_DDR_D8
R3507
56
56
A_DDR_D14
A_DDR_D15
A_DDR_BA0_HSS R3502
56 R3519
A_DDR_BA1_HSS 56
A_DDR_WE#_HSS DDRA_WE#_HSS A_DDR_CLKP_400MHz DDRA_CLKP_400MHz
1 2
A_DDR_BA2_HSS A_DDR_CLKEN DDRA_CLKEN R3520
3 4
56
A_DDR_CLKN_400MHz DDRA_CLKN_400MHz
A_DDR_A0 A_DDR_BA1_HSS DDRA_BA1_HSS
5 6
A_DDR_A1 A_DDR_BA0_HSS DDRA_BA0_HSS
7 8 R3517
56
A_DDR_A2
(PWB) A_DDR_A0 DDRA_A0
*R3510 1 2
A_DDR_A3
56
C A_DDR_A4
A_DDR_BA2_HSS DDRA_BA2_HSS A_DDR_CAS#_HSS
3 4
DDRA_CAS#_HSS
B
3 4
R3521
A_DDR_A9 DDRA_A9 56
5 6 A_DDR_A11 DDRA_A11
A_DDR_ODT_HSS
A_DDR_A12 DDRA_A12
7 8
A_DDR_RAS#_HSS
A_DDR_CAS#_HSS
A_DDR_CLKEN
A_DDR_WE#_HSS
A_DDR_CLKP_400MHz
A_DDR_CLKN_400MHz
1 2 3 4 5 6 7 8 9 10
10 – 10
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
MAIN6(DDR) LE350_PP(2012.09.27)
C3508
10u C3505
16V 0.1u K
KZA837WJQZ 10V
1 2 3 7 8 9
DDRA_DQS1N
C3502 C3507
DDRA_D11 0.1u K 0.1u K
10V A1 A2 A3 A7 A8 A9
A 10V
DDRA_D12
DDRA_DQM1 VDD NC VSS VSSQ /UDQS VDDQ
DDRA_DQS1P
DDRA_D9 DDRA_D14 DDRA_D15
DDRA_D14
B1 B2 B3 B B7 B8 B9
C3510
DDRA_D4 0.1u
C1 C2 C3 C C7 C8 C9 K
10V
DDRA_D3 DDRA_D11 VDDQ DQ9 VDDQ VDDQ DQ8 VDDQ
DDRA_D10
DDRA_D12 DDRA_D13
DDRA_D1
DDRA_D6 D1 D2 D3 D D7 D8 D9
DQ12 VSSQ DQ11 DQ10 VSSQ DQ13
DDRA_DQS0N
C3511
0.1u K
DDRA_D15 E1 E2 E3 E E7 E8 E9 10V
DDRA_DQM0 VDD NC VSS VSSQ /LDQS VDDQ
DDRA_DQS0P
DDRA_D8
DDRA_D6 DDRA_D7
DDRA_D10
F1 F2 F3 F F7 F8 F9
DDRA_D13
DDRA_D1 DQ6 VSSQ LDM LDQS VSSQ DQ7
DDRA_D0
C3503 C3512
0.1u K G1 G2 G3 G7 G8 G9 0.1u K
G
10V 10V
VDDQ DQ1 VDDQ VDDQ DQ0 VDDQ
IC3501
DQ4 VSSQ DQ3 IXD391WJQZ DQ2 VSSQ DQ5
H1 H2 H3 H H7 H8 H9
DDRA_D4 DDRA_D5
DDRA_D3 DDRA_D2
VDDL VREF VSS VSSDL CK VDD
C3506
0.1u J1 J2 J3 J J7 J8 J9
K
10V (PWB)
C3509
0.1u *C3501 R3527
K 100
DDRA_CLKP_400MHz 10V DDRA_CLKP_400MHz
0.01u
25V
CKE /WE /RAS /CK ODT
DDRA_CLKN_400MHz K2 K3 K7 K8 K9
K
DDRA_ODT_HSS
DDRA_CLKEN R3528
100 DDRA_CLKN_400MHz
DDRA_WE#_HSS
DDRA_RAS#_HSS
NC(BA2) BA0 BA1 /CAS /CS
DDRA_A0 L1 L2 L3 L L7 L8
2 DDRA_BA2_HSS
DDRA_CAS#_HSS DDRA_BA0_HSS
4 DDRA_CAS#_HSS
DDRA_BA1_HSS
DDRA_RAS#_HSS A10 A1 A2 A0 VDD C3517
6
M2 M3 M7 M8 M9 0.1u
M 10V
DDRA_ODT_HSS
8 DDRA_A10
DDRA_A0
DDRA_A1 DDRA_A2
VSS A3 A5 A6 A4
N1 N2 N3 N N7 N8
DDRA_A8
2 DDRA_A4
DDRA_A3
DDRA_A6 DDRA_A5 DDRA_A6
4
A7 A9 A11 A8 VSS
DDRA_A4
6 P2 P3 P P7 P8 P9
DDRA_A2 DDRA_A7
8 DDRA_A8
DDRA_A9 DDRA_A11
VDD A12 NC NC NC
C3504
0.1u R1 R2 R3 R R7 R8
K
DDRA_A11 10V
DDRA_A12
10 11 12 13 14 15 16 17 18 19
10 – 11
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
(MASTER)
H
LC-32LE350M MAIN7 (FLASH)
F
SPI_WP
SPI_CZ
SPI_DO_DAT
R3101
4.7K
E
SPI_WP
*TL3101
*TL3106
*TL3107
*TL3103
4 3 2 1
GND WP SO/SIO1 CS
IC3101
*TL3110
*TL3111
RH-IXD464WJQZQ
D SCLK
SI/SIO0 HOLD VCC
*TL3108
*TL3109
3.3 0 3.3 3.3
C3102
5 6 7 8 0.1u 8 7 6 5
10V
C3101
0.1u
*TL3102
*TL3104
10V
CZB IC3102
BR24T28F
*TL3105
SPI_DI_DAT
A0 A1 A2
C
SPI_CLK
1 2 3 4
0 0 0 0
For DATA
I2C Address at A4
1 2 3 4 5 6 7 8 9 10
10 – 12
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
(FLASH) LE350_PP(2012.10.16)
TO MAIN10(POWER)
BU+3.3V
TO MAIN5(CPU)
SPI_WP
SPI_CLK
SPI_CZ
SPI_DI_DAT
SPI_DO_DAT
I2C_CLK
R3103
I2C_DAT
4.7K
*TL3114
*TL3115
*TL3112
*TL3113
IC3103
IXD110WJQZ
A0 A1 A2 GND
4 1 2 3 4
0 0 0 0 0
10 11 12 13 14 15 16 17 18 19
10 – 13
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
(MASTER)
H
LC-32LE350M MAIN8 (PANEL)
G TO MAIN10(POWER)
PNL+12V
D+3.3V
TO MAIN5(CPU)
RXE_D0N
E RXE_D0P
RXE_D1N
RXE_D1P
RXE_D2N
D RXE_D2P
RXE_CLKN
RXE_CLKP
RXE_D3N
RXE_D3P
C
I2C_CLK
I2C_DAT
TCON_WP
1 2 3 4 5 6 7 8 9 10
10 – 14
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
NEL) LE350_PP(2012.08.27)
*TL3802
SC3801
NB080WJQZ
TL3806
1 VCC
C3801 VCC
0.1u
2
CZB
3 vCC
*TL3803 4 VCC
5 GND
6 GND
7 GND
TL3804 8 GND
(PWB) *R3801 0
TL3812 9 SELLVDS
(PWB) *R3802 0
TL3805 10 ODSEL
11 GND
12 RX0-
TL3807 13 RX0+
14 GND
15 RX1-
TL3808 16 RX1+
17 GND
18 RX2-
TL3809 19 RX2+
20 GND
21 RXCLK-
TL3810 22 RXCLK+
23 GND
24 RX3-
TL3811 25 RX3+
TL3813 26 GND
1 VCC 8
TL3814
27 NC/SDA
(PWB)
*R3803
0
TL3815
28 NC/SCL
(PWB) *R3805 0
2 7
29 NC/GND
3 6 *TL3801 30 GND
(PWB)
*R3804
0
4 GND 5
(PWB)
*IC3801
HC2G66DP
10 11 12 13 14 15 16 17 18 19
10 – 15
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
MAIN9(AUDIO_AMP)
H
TO MAIN10(POWER)
UR+12.2V
D+3.3V
D+5V
13V_DET
BU+5V
C1905
1u 10V
5 4 3 2 1
F 6 7 8 9 10
14.66V
C1902
EXA643WJQZ
16V 10u
*D1901
(PWB)
*C1906
4.7u
R1908
CKZ TL1904
(PWB) 10K
VS
Q1901
LTC044EEB
C1903 R1906 4 3
1u CYB 1K
OUT CD
E
TO MAIN5(CPU)
L_MUTE
MONITOR_R
R1915 R1916
6.8K 2.2K
MONITOR_L
HP_L_MUTE
HP_L
HP_R
AC_CTRL
S_STBY
C1702
D 10u
25V
KZA838WJQZ
C
C1701 1
10u 2
I2S_MCLK
25V K
KZA838WJQZ
I2S_DAT
I2S_SCLK
(PWB)
I2S_LRCLK *C1703
33u
25V
APF
C
(PWB)
*R1902
J 10K
TL1901
(PWB)
*R1703
4 3 10K
OUT CD (PWB)
*R1704
IC1901 C1901
1000P 10K
B
50V
PST8429U CZB
R1903 R1904
3.3K 8.2K
1 2 3 4 5 6 7 8 9 10
10 – 16
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
O_AMP) LE350_PP(2012.10.16)
TO MAIN3(TERMINAL)
MON_L_OUT
MON_R_OUT
HP_L_OUT
(PWB) HP_R_OUT
CZ
*R1909
CZ
R1910 *TL1902
0
100K
TL1909
VS (PWB)
Q1902 C1916 *C1918
LTC044EEB C1915 1u
0.1u
10u 10V
CZF
16V
13
14
15
16
4 3
EN
C1920
GND
C1911
AVDD
SGND
OUT CD OUTL
HPVDD
IC1905 C1922
12
1
INL-
CPP
11
2
IC1903
INL+
PGND
10
3
INR+
1u 10V
C1919
C1914
4
9
CPN
INR-
1u 10V 1u
HPVSS
OUTR
G0
10V
G1
8
7
5
R1917 R1918
6.8K 2.2K
(PWB)
(PWB) *R1913
*R1911 0
CZ
0 C1917
CZ 2.2u
10V
CZ
R1912 R1914
10K 10K
CZ
*TL1903
C1702
10u C1716
25V 0.22u
C1710 C1715
KZA838WJQZ 25V CKZ
0.1u 0.1u 25V
25V CYB
CYB
C1704 L1701 L1703
10u 15uH 15uH
C1701
25V PB337WJQZ PB337WJQZ
10u
25V KZA838WJQZ C1708 C1712
1u 25V 1u 25V
KZA838WJQZ (PWB) (PWB)
KZA621WJQZ KZA621WJQZ
*D1701 *D1703
14.66V 14.66V
EXA643WJQZ EXA643WJQZ
(PWB)
*C1703 (PWB) (PWB)
33u *C1723 *C1727
25
26
27
28
29
30
31
32
GND
C1731
OUTML
PVDDML
OUTPL
PVSSL
PVDDML
PVSSL
OUTPL
*C1721 NA961WJ
100P 100P
*TL1701
(CH) (CH)
AVSS MONO 4 Lch+
23
2
*TL1702
TP1702 3 Lch-
*TL1703
TEST
IC1701 CKMOD
2
22
3
R1720
0
R1713
68K F
MCK PLIMIT2 (PWB)
20
5
R1714
10K F *C1724
R1709 (CH)
68K F 100P
SDATA PLIMIT1 C1732
19
6
R1710 1000P
4.7K TP1703 R1716
CYB
F 47K
(PWB) (PWB)
SCLK PROTN
18
7
*C1720 *C1722
(PWB)
R1717 100P 100P *C1730
*R1703 0.1u
10K (CH) (CH)
10K LRCLK SLEEPN
17
8
(PWB)
R1711
PVDDMR
PVDDPR
*R1704 C1718
OUTMR
OUTMR
OUTPR
OUTPR
PVSSR
220K
PVSSR
10K 1000P
*C1726 (PWB)
0.1u *C1728
16
15
14
13
12
11
10
100P
9
(PWB)
(PWB) (CH)
*R1701 *R1702
10K 10K
C1709 C1713
25V 1u 25V
1u
KZA621WJQZ KZA621WJQZ
L1702
L1704
15uH C1711 C1714
15uH
0.1u 0.1u
PB337WJQZ PB337WJQZ
25V 25V
CYB CYB
C1717
0.22u
25V CKZ
(PWB) (PWB)
*D1702 *D1704
EXA643WJQZ EXA643WJQZ
14.66V 14.66V
10 11 12 13 14 15 16 17 18 19
10 – 17
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
(MASTER)
LC-32LE350M MAIN10 (POWER)
H
SC9601
NB098WJ
VS (PWB)
TL9601 *Q9604
RT1N141C
UR12.2V 1
C9601
TL9613
G UR12.2V 2 10u
25V
UR12.2V 3 R9641
TL9602 10K
GND 4
(PWB)
GND 5 *R9604 *R9625
100 4.7K
GND 6 TL9603
PS_ON 7 TL9604
*R9636
8
F
LAMP_ERR 12K
TL9611
CZ
C9611
R9613
R9616
VHD
PWM(OFL) 9
8.2K
TL9612 0.033u
10K
D9606
R9606 R9607 16V DA101
STB 10 *R9637
47K 22K
2200P
C9616
3.3K
CZ R9620 R9624
F
3.9K
F
47K
*IC9606
IC9603
F S170B50U
8 7 6 5
(PWB)
AP3503MP
EN
SS
*C9620
FB
C9636
COMP
10u EN V
51P
1
*D9601 16V
50V
DA1010 KZA837WJQZ GND
2
(PWB)
GND
NC
SW
Vin
3
BS
1 2 3 4
R9609
L9603 C9623
27 10uH
PB014WJQZ
10u
16V
M+5.6V
2.45A 48m &8KZA837WJQZ TL9605
(PWB)
C9610 *C9618
0.1u C9624
2200P K
C9614 50V 10u
25V
10u 16V
C9638 CZB (PWB) KZA837WJQZ
25V
0.1u
KZA838WJQZ *R9617
25V 2.2
CYB CY
TO MAIN5(CPU)
25V
C9639
10
INV_POW
C9612
C9617
F
2200P
PWM0_OFL
R9615
0.033u
16V R
10K
R9619 R9623
LAMP_ERR 680 F 3.3K F
4.3K
R9614
1/
8 7 6 5 IC9605 (PWB)
*C9619
PANEL_POW
D AP3502MP 1000P K
EN
SS
FB
50V
COMP
R9601
10K C962
4.7u
KZA761
GND
SW
Vin
BS
1 2 3 4
R9610 L9602
33 10uH
PB014WJQZ
TL9606
2.45A 48m &8
(PWB)
*C9637
2200P
50V C9621 C9622
C9613 10u 10u
K
0.01u 16V 16V
(PWB)
K 25V KZA837WJQZ KZA837WJQZ
*R9638
2.2
6 5 4
C9615
10u
25V
C
KZA838WJQZ
1 2 3
(PWB)
*C9625
1u 10V
KZA531WJQZ
(PWB)
*C9602
1u 25V
KZA621WJQZ
VS
R9605
(PWB)
100K Q9607
*Q9602
KTA1535T
B TPC6110
R9608
1K
3
4
(PWB)
*C9635
10u
25V
2
5
KZA838WJQZ
6
Q9601
RT1N141U
DUNTKG165WE
1 2 3 4 5 6 7 8 9 10
10 – 18
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
10 (POWER) LE350_PP(2012.10.16)
(PWB)
*R9626
4.7K
(PWB)
VS (PWB) VS *Q9605
*Q9604 RT1N141C
RT1N141C
TO MAIN9(AUDIO_AMP)
*R9640
R9632 100
R9641 4.7K 13V_DET
10K
(PWB)
UR+12.2V
*R9625
4.7K
D+3.3V
(PWB) *Q9606 (PWB)
*R9639
100 2SC3928AR D+5V
5
1
1
1
KZA520WJQZ
Z GND GND GND
2
2
2
M+5.6V
NC VIN On NC On NC
4
4
4
3
3
3
BU+3.3V
V
R9622
8.2K
(PWB) D9605
*R9628 CRS02
12K
2200P
C9632
VHD
TO MAIN1(TUNER)
0.033u
C9626
8 7 6 5 IC9604
D+3.3V
AP3502MP
EN
SS
FB
R9634 R9633
COMP
3.9K 22K
R9635
10K
GND
SW
Vin
BS
TO MAIN7(FLASH)
1 2 3 4
CIL PB014WJQZ
L9604 TL9614 BU+3.3V
10uH D+3.3V 600mA
25V
25V
C9640
C9639
C9642
10u
10u
27 C9641
0.1u 10u 10u
R9621 TL9609
C9630 16V 16V
25V KZA510WJPZ KZA510WJPZ TO MAIN2(HDMI-TERM)
R9630 R9631
1 1 IC9609 IC9611 KZA520WJQZ
C9634 D+5V
1/2W
C9643 3416C25N 1u 10V
1/2W
TWF TWF 0.1u BU+3.3V
3479A18P
Vin CS Vin Vout
5
3
1
4
4.7u 10V
C9627 GND GND
2
KZA761WJQZ
Vout ON On NC
4
1
3
5
C9628
4.7u 10V
KZA761WJQZ
TL9608
1.8V 280mA
D+1.26V 600mA
(PWB)
*D9602
DA1010
TO MAIN6(DDR)
(PWB) D+1.8V
*D9603
DA1010
6 5 4 (PWB)
(PWB)
*D9604
*Q9603 DA1010 TO MAIN5(CPU)
RN4982 D+5V
D+3.3V
1 2 3
D+1.8V
(PWB)
(PWB)
*R9629
*C9625 D+2.5V
4.7K
1u 10V
KZA531WJQZ D+1.26V
BU+3.3V
AC_CTRL
POW_CHK
07
535T
TO MAIN8(PANEL)
PNL+12V
(PWB)
*C9635 D+3.3V
10u
25V
KZA838WJQZ
TO MAIN11(KEY)
BU+3.3V
10 11 12 13 14 15 16 17 18 19
10 – 19
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
MAIN11(
H
1
3
3
4
4
2
2
(PWB)
*D101
EXA721WJQZ
16V
R101 R103
8.2K 12K
1/16W 1/16W
TO MAIN5(CPU)
E
TL101
KEY_1
TL102
KEY_2
TL103
PSWIN
TO MAIN10(POWER)
D
BU+3.3V
TO MAIN5(CPU)
TL104
R/C
TL105
LED_G
C TL106
LED_R
P101
NB150WJ
RA TO LED
BU+3.3V 1
B GND 2
R/C 3
LED_G 4
LED_R 5
DUNTKG165WE
A
1 2 3 4 5 6 7 8 9 10
10 – 20
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
AIN11(KEY/RC) LE350_PP(2012.08.30)
1
3
1
3
3
4
4
2
4
2
2
(PWB)
*D104
EXA721WJQZ
16V
R113 R117
8.2K 12K
1/16W 1/16W
POW
S105
KA037WJ
1
3
4
(PWB)
*D105
EXA721WJQZ
16V
10 11 12 13 14 15 16 17 18 19
10 – 21
Downloaded from www.Manualslib.com manuals search engine
PartsGuide
1st Addition
PARTS GUIDE
No. SZ12M1132LE350M
MODEL LC-32LE350M
CONTENTS
Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these
parts with specified ones for maintaining the safety and performance of the set.
2
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
NO. PARTS CODE PRICE NEW PART DESCRIPTION
RANK MARK RANK
3
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
NO. PARTS CODE PRICE NEW PART DESCRIPTION
RANK MARK RANK
4
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
NO. PARTS CODE PRICE NEW PART DESCRIPTION
RANK MARK RANK
5
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
NO. PARTS CODE PRICE NEW PART DESCRIPTION
RANK MARK RANK
6
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
NO. PARTS CODE PRICE NEW PART DESCRIPTION
RANK MARK RANK
7
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
NO. PARTS CODE PRICE NEW PART DESCRIPTION
RANK MARK RANK
Stand unit
8
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
[6] SUPPLIED ACCESSORIES
X6 QCNCWA969WJZZ AF ANTENNA ADAPTOR (FOR PHILIPPINES)
X7 TGAN-B249WJZZ AC WARRANTY CARD (FOR PHILIPPINES)
X7 TGAN-B383WJN1 AD WARRANTY CARD (FOR VIETNAM)
X7 TGAN-B636WJZZ AD WARRANTY CARD (FOR ASIA/MALAYSIA)
X7 TGAN-B728WJZZ AG WARRANTY CARD (FOR INDONESIA)
9
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
10
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
11
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
12
Downloaded from www.Manualslib.com manuals search engine
LC-32LE350M
13
Downloaded from www.Manualslib.com manuals search engine
EndPage
COPYRIGHT © 2012
COPYRIGHT XXXXBY SHARP CORPORATION
BYSHARP CORPORATION
ALL RIGHTS RESERVED.
RQ200
DEC2012 Printed in Malaysia SHARP MANUFACTURING
Design and Production Information CORPORATION (M) SDN. BHD
Design :SEM PQA DEPARTMENT
Production :SMM Batu Pahat, Johor,
SELVA SMM Malaysia
–1
Downloaded from www.Manualslib.com manuals search engine