Académique Documents
Professionnel Documents
Culture Documents
0.27 0.15
63.50<t≦101.60
~
0.29 1.20
t>101.60
max
Remarks:1.When copper steel is specified, minimum Cu shall be 0.20%.
2.For plates wider than 24 in.(600mm), the elongation requirement is reduced two percentage points.
3.For nominal thickness under 5/16 in.(8mm), the deduction from the specified percentage of elongation in 8
in.(200mm) shall be made for decreases of the nominal thickness below 5/16 in.(8mm). See elongation
requirement adjustments under the Tension Tests section of Specificatuon A6 for deduction values.
4.For each reduction of 0.01% below the specified carbon maximum, an increase of 0.06% manganese above
the specified maximum will be permitted up to the maximum of 1.35%.