Académique Documents
Professionnel Documents
Culture Documents
NOTE: Top wing does not need a carbon rod. MOTOR MOUNT PARTS
Carbon rod glued into slot (bottom wing only) CG 7cm from TOP
wing leading edge.
3
3mm PLYWOOD
2
Glue Plywood onto Depron
WIRE
11
Cut here
10 7
Motor
Battery position
1
SIDES (MAKE 2)
ESC
Receiver
Control point
Plywood motor mount glued to Depron.
WIRE
Plywood landing gear mount glued to Depron.
11 11
3mm PLYWOOD
9
5 5
Control point
Access to Battery and Electronics Access to Electronics TOP (Must be curved to fit)
8
TOP
MIDDLE 2
BOTTOM
4 BOTTOM
4 VENT
SETUP :-
Weight (painted) = 410g
Weight (painted with 1350 battery) = 554g NOTES:-
Static thrust = 670g
ULTIMATE NAC - EASYBUILD - V1.0 Prop = 10x5
Assemble plane parts in numbered order.
Bevel or curve all leading edges.
Designed by Nick Cara (NAC) Motor = 1050kv Trim and sand corners to a curve.
nicknac6@gmail.com ESC = 25A minimum
CM Use Hot Glue for all parts except carbon rods.
0 1 2 3 4 5 6 7 8 9 10 Battery = 1350 or 2100 3s1p 25C Li-Po Mount eletronics and battery using Velcro.
Depron = 6mm Radio = 4CH
Control points Balance the plane at COG mark by moving the battery possition.
INCH (Make 4 from old plastic credit card)
Control points
(Make 4 from old plastic credit card)
Wing span = 84cm (~33”) Aileron throw = +/- 20 degrees
0 1 2 3 4 Length = 81cm (~31.8”) Elevator throw = +/- 35 degrees
Rudder throw = +/- 35 degrees
Expo = 50%
COG = 7cm from upper wing leading edge.