Académique Documents
Professionnel Documents
Culture Documents
WIRING
TABLE OF CONTENTS
page page
cardiagn.com
ANTILOCK BRAKES. . . . . . . . . . . . . . . . . . . 8W-35-1 POWER SEATS . . . . . . . . . . . . . . . . . . . . . . 8W-63-1
VEHICLE THEFT SECURITY SYSTEM . . . . . 8W-39-1 POWER SUNROOF . . . . . . . . . . . . . . . . . . . 8W-64-1
INSTRUMENT CLUSTER . . . . . . . . . . . . . . . 8W-40-1 SPEED PROPORTIONAL STEERING . . . . . . 8W-65-1
HORN/CIGAR LIGHTER/POWER OUTLET . . 8W-41-1 SPLICE INFORMATION . . . . . . . . . . . . . . . . 8W-70-1
AIR CONDITIONING/HEATER . . . . . . . . . . . 8W-42-1 CONNECTOR PIN-OUTS . . . . . . . . . . . . . . . 8W-80-1
OCCUPANT RESTRAINT SYSTEM. . . . . . . . 8W-43-1 CONNECTOR/GROUND/SPLICE LOCATION. 8W-91-1
INTERIOR LIGHTING. . . . . . . . . . . . . . . . . . 8W-44-1 POWER DISTRIBUTION . . . . . . . . . . . . . . . 8W-97-1
cardiagn.com
PM 8W-01 WIRING DIAGRAM INFORMATION 8W - 01 - 1
TABLE OF CONTENTS
page page
cardiagn.com
WARNINGS - GENERAL . . . . . . . . . . . . . . . . . . . . . . 9 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
DIAGNOSIS AND TESTING - WIRING DIODE
HARNESS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
STANDARD PROCEDURE INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
STANDARD PROCEDURE - TERMINAL
ELECTROSTATIC DISCHARGE (ESD) REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
SENSITIVE DEVICES . . . . . . . . . . . . . . . . . . . . . . 11 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
STANDARD PROCEDURE - TESTING OF WIRE
VOLTAGE POTENTIAL . . . . . . . . . . . . . . . . . . . . . 12 STANDARD PROCEDURE - WIRE SPLICING . . . . 21
STANDARD PROCEDURE - TESTING FOR
CONTINUITY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
8W - 01 - 2 8W-01 WIRING DIAGRAM INFORMATION PM
cardiagn.com
and other components are shown as simply as possible, with regard to function only.
PM 8W-01 WIRING DIAGRAM INFORMATION 8W - 01 - 3
cardiagn.com
8W - 01 - 4 8W-01 WIRING DIAGRAM INFORMATION PM
cardiagn.com
PM 8W-01 WIRING DIAGRAM INFORMATION 8W - 01 - 5
SYMBOLS
International symbols are used throughout the wiring diagrams. These symbols are consistent with those being used
around the world.
cardiagn.com
8W - 01 - 6 8W-01 WIRING DIAGRAM INFORMATION PM
cardiagn.com
PM 8W-01 WIRING DIAGRAM INFORMATION 8W - 01 - 7
TERMINOLOGY
This is a list of terms and definitions used in the wiring diagrams.
cardiagn.com
WIRE COLOR CODE CHART
CIRCUIT FUNCTION
A BATTERY FEED
B BRAKE CONTROLS
C CLIMATE CONTROLS
D DIAGNOSTIC CIRCUITS
E DIMMING ILLUMINATION
CIRCUITS
F FUSED CIRCUITS
G MONITORING CIRCUITS
(GAUGES)
H MULTIPLE
I NOT USED
J OPEN
K POWERTRAIN CONTROL
cardiagn.com
MODULE
L EXTERIOR LIGHTING
M INTERIOR LIGHTING
N MULTIPLE
O NOT USED
P POWER OPTION (BATTERY
FEED)
Q POWER OPTIONS (IGNITION
FEED)
R PASSIVE RESTRAINT
S SUSPENSION/STEERING
T TRANSMISSION/TRANSAXLE/
TRANSFER CASE
U OPEN
V SPEED CONTROL, WIPER/
WASHER
W WIPERS
X AUDIO SYSTEMS
Y TEMPORARY
Z GROUNDS
IDENTIFICATION
In-line connectors are identified by a number, as follows:
• In-line connectors located in the engine compartment are C100 series numbers.
• In-line connectors located in the instrument panel area are C200 series numbers.
• In-line connectors located in the body are C300 series numbers.
• Jumper harness connectors are C400 series numbers.
• Grounds and ground connectors are identified with a “G” and follow the same series numbering as the in-line
connectors.
• Splices are identified with an “S” and follow the same series numbering as the in-line connectors. In addition,
S001–S099 numbers are located in the engine compartment.
• Component connectors are identified by the component name instead of a number. Multiple connectors on a
cardiagn.com
component use a C1, C2, etc. identifier.
LOCATIONS
Section 8W-91 contains connector/ground/splice location illustrations. The illustrations contain the connector name
(or number)/ground number/splice number and component identification. Connector/ground/splice location charts in
section 8W-91 reference the figure numbers of the illustrations.
The abbreviation T/O is used in the component location section to indicate a point in which the wiring harness
branches out to a component. The abbreviation N/S means Not Shown in the illustrations
WARNING
WARNINGS - GENERAL
WARNINGS provide information to prevent personal injury and vehicle damage. Below is a list of general warnings
that should be followed any time a vehicle is being serviced.
WARNING: Use safety stands anytime a procedure requires being under a vehicle.
WARNING: Be sure that the ignition switch always is in the off position, unless the procedure requires it to
be on.
WARNING: Set the parking brake when working on any vehicle. An automatic transmission should be in
park. A manual transmission should be in neutral.
WARNING: Keep away from moving parts when the engine is running, especially the fan and belts.
WARNING: To prevent serious burns, avoid contact with hot parts such as the radiator, exhaust manifold(s),
tail pipe, catalytic converter and muffler.
8W - 01 - 10 8W-01 WIRING DIAGRAM INFORMATION PM
WARNING: Do not allow flame or sparks near the battery. Gases are always present in and around the bat-
tery.
WARNING: Always remove rings, watches, loose hanging jewelry and avoid loose clothing.
WARNING: Never use a jumper wire across a load, such as a motor, connected between a battery feed and
ground.
• Voltmeter - Used to check for voltage on a circuit. Always connect the black lead to a known good ground and
the red lead to the positive side of the circuit.
cardiagn.com
CAUTION: Most of the electrical components used in today’s vehicles are Solid State. When checking volt-
ages in these circuits, use a meter with a 10 - megohm or greater impedance rating.
• Ohmmeter - Used to check the resistance between two points of a circuit. Low or no resistance in a circuit
means good continuity.
CAUTION: Most of the electrical components used in today’s vehicles are Solid State. When checking resis-
tance in these circuits use a meter with a 10 - megohm or greater impedance rating. In addition, make sure
the power is disconnected from the circuit. Circuits that are powered up by the vehicle’s electrical system
can cause damage to the equipment and provide false readings.
STANDARD PROCEDURE
STANDARD PROCEDURE - ELECTROSTATIC DISCHARGE (ESD) SENSITIVE
DEVICES
cardiagn.com
All ESD sensitive components are solid state and a
symbol is used to indicate this. When handling any
component with this symbol, comply with the following
procedures to reduce the possibility of electrostatic
charge build up on the body and inadvertent discharge
into the component. If it is not known whether the part
is ESD sensitive, assume that it is.
1. Always touch a known good ground before han-
dling the part. This should be repeated while han-
dling the part and more frequently after sliding
across a seat, sitting down from a standing posi-
tion, or walking a distance.
2. Avoid touching electrical terminals of the part, unless instructed to do so by a written procedure.
3. When using a voltmeter, be sure to connect the ground lead first.
4. Do not remove the part from it’s protective packing until it is time to install the part.
5. Before removing the part from it’s package, ground the package to a known good ground on the vehicle.
8W - 01 - 12 8W-01 WIRING DIAGRAM INFORMATION PM
cardiagn.com
STANDARD PROCEDURE - TESTING FOR CONTINUITY
1. Remove the fuse (1) for the circuit being checked
or, disconnect the battery.
2. Connect one lead of the ohmmeter to one side of
the circuit being tested
3. Connect the other lead to the other end of the cir-
cuit being tested. Low or no resistance means
good continuity.
cardiagn.com
8W - 01 - 14 8W-01 WIRING DIAGRAM INFORMATION PM
SPECIAL TOOLS
WIRING/TERMINAL
cardiagn.com
TERMINAL PICK TOOL SET 6680
CONNECTOR
REMOVAL
1. Disconnect battery.
2. Release Connector Lock (2).
3. Disconnect the connector (3) being repaired from
its mating half/component.
4. Remove the dress cover (if applicable) (1).
cardiagn.com
8W - 01 - 16 8W-01 WIRING DIAGRAM INFORMATION PM
cardiagn.com
5. Release the Secondary Terminal Lock, if required (1).
PM 8W-01 WIRING DIAGRAM INFORMATION 8W - 01 - 17
cardiagn.com
1 - TYPICAL CONNECTOR
2 - PICK FROM SPECIAL TOOL KIT 6680
3 - APEX CONNECTOR
4 - PICK FROM SPECIAL TOOL KIT 6680
5 - AUGAT CONNECTOR
6 - SPECIAL TOOL 6932
7 - MOLEX CONNECTOR
8 - SPECIAL TOOL 6742
9 - THOMAS AND BETTS CONNECTOR
10 - SPECIAL TOOL 6934
11 - TYCO CONNECTOR
12 - SPECIAL TOOL 8638
6. Position the connector locking finger away from the terminal using the proper special tool. Pull on the wire to
remove the terminal from the connector.
8W - 01 - 18 8W-01 WIRING DIAGRAM INFORMATION PM
INSTALLATION
1. Insert the removed terminal in the same cavity on the repair connector.
2. Repeat steps for each terminal in the connector, being sure that all wires are inserted into the proper cavities.
For additional connector pin-out identification, refer to the wiring diagrams.
3. When the connector is re-assembled, the secondary terminal lock must be placed in the locked position to pre-
vent terminal push out.
4. Replace dress cover (if applicable).
5. Connect connector to its mating half/component.
6. Connect battery and test all affected systems.
cardiagn.com
PM 8W-01 WIRING DIAGRAM INFORMATION 8W - 01 - 19
DIODE
REMOVAL
1. Disconnect the battery.
2. Locate the diode in the harness, and remove the
protective covering.
3. Remove the diode from the harness, pay attention
to the current flow direction (1) (2) (3).
INSTALLATION
cardiagn.com
1. Remove the insulation from the wires in the harness. Only remove enough insulation to solder in the new diode.
2. Install the new diode in the harness, making sure current flow is correct. If necessary, refer to the appropriate
wiring diagram for current flow.
3. Solder the connection together using rosin core type solder only. Do not use acid core solder.
4. Tape the diode to the harness using electrical tape. Make sure the diode is completely sealed from the elements.
5. Re-connect the battery and test affected systems.
8W - 01 - 20 8W-01 WIRING DIAGRAM INFORMATION PM
TERMINAL
REMOVAL
1. Follow steps for removing terminals described in the connector removal section.
2. Cut the wire 6 inches from the back of the connector.
INSTALLATION
1. Select a wire from the terminal repair kit that best matches the color and gage of the wire being repaired.
2. Cut the repair wire to the proper length and remove one–half (1/2) inch of insulation.
3. Splice the repair wire to the wire harness (see wire splicing procedure) (Refer to 8 - ELECTRICAL/WIRING DIA-
GRAM INFORMATION/WIRE - STANDARD PROCEDURE).
4. Insert the repaired wire into the connector.
5. Install the connector locking wedge, if required, and reconnect the connector to its mating half/component.
6. Re-tape the wire harness starting at 1–1/2 inches behind the connector and 2 inches past the repair.
7. Connect battery and test all affected systems.
cardiagn.com
PM 8W-01 WIRING DIAGRAM INFORMATION 8W - 01 - 21
WIRE
STANDARD PROCEDURE - WIRE SPLICING
When splicing a wire, it is important that the correct gage be used as shown in the wiring diagrams.
1. Remove one-half (1/2) inch of insulation from each
wire that needs to be spliced.
2. Place a piece of adhesive lined heat shrink tubing
on one side of the wire. Make sure the tubing will
be long enough to cover and seal the entire repair
area.
3. Place the strands of wire overlapping each other
inside of the splice clip (1).
cardiagn.com
5. Solder (3) the connection (2) together using rosin
core type solder (1) only.
6. Center the heat shrink tubing (2) over the joint and
heat using a heat gun. Heat the joint until the tub-
ing is tightly sealed and sealant (1) comes out of
both ends of the tubing.
cardiagn.com
PM 8W-02 COMPONENT INDEX 8W - 02 - 1
cardiagn.com
Capacitor-Ignition . . . . . . . . . . . . . . . . . . . . . 8W-30 Module-Sentry Key Remote Entry . . . . . . . . . 8W-39
Cluster . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-40 Module-Steering Control . 8W-33, 41, 43, 44, 47, 50,
Coil-Ignitions . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30 51, 52, 53, 65
Control-A/C-Heater . . . . . . . . . . . . . . . . . . . . 8W-42 Module-Totally Integrated Power . . . . . . . . . 8W-13
Data Link Connector . . . . . . . . . . . . . . . . . . . 8W-18 Module-Transmission Control . . . . . . . . . . . . 8W-31
Fan Module-Radiator Cooling . . . . . . . . . . . . 8W-30 Modules-Headlamp Leveling . . . . . . . . . . . . . 8W-50
Fuse/Relay Block . . . . . . . . . . . . . . . . . . . . . . 8W-11 Motor-Blower . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-11, 13 Motor-Sunroof . . . . . . . . . . . . . . . . . . . . . . . . 8W-64
Fusible Link . . . . . . . . . . . . . . . . . . . . . . . . . 8W-20 Motors-Windows . . . . . . . . . . . . . . . . . . . . . . 8W-60
Generator . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-20 Motors-Wiper . . . . . . . . . . . . . . . . . . . . . . . . . 8W-53
Glow Plugs . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30 Power Outlets . . . . . . . . . . . . . . . . . . . . . . . . 8W-41
Grounds . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15 Pump-Washer-Windshield . . . . . . . . . . . . . . . 8W-53
Heater-Cabin . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42 Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-47, 55
Heater-PCV . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30 Receiver-Satellite . . . . . . . . . . . . . . . . . . . . . 8W-47
Heaters-Seat . . . . . . . . . . . . . . . . . . . . . . . . . 8W-63 Relay-Cabin Heaters . . . . . . . . . . . . . . . . . . . 8W-42
Horns . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-41 Relay-Main . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-11
Injectors-Fuel . . . . . . . . . . . . . . . . . . . . . . . . 8W-30 Relays-Radiator Fan . . . . . . . . . . . . . . . . . . . 8W-11
Lamp-Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-44 Resistor-Blower Motor . . . . . . . . . . . . . . . . . . 8W-42
Lamp-Cup Holder . . . . . . . . . . . . . . . . . . . . . 8W-44 Seat Belt-Tensioners . . . . . . . . . . . . . . . . . . . 8W-43
Lamp-Dome . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-44 Sensor-Accelerator Pedal Position . . . . . . . . . 8W-30
Lamp-High Mounted Stop . . . . . . . . . . . . . . . 8W-51 Sensor-Ambient Air Temperature . . . . . . . . . 8W-42
Lamp-License . . . . . . . . . . . . . . . . . . . . . . . . 8W-51 Sensor-Brake Fluid Level . . . . . . . . . . . . . . . 8W-30
Lamp-Turn Front . . . . . . . . . . . . . . . . . . . . . 8W-52 Sensor-Crankshaft Position . . . . . . . . . . . . . . 8W-30
Lamp-Vanity-Left . . . . . . . . . . . . . . . . . . . . . 8W-44 Sensor-Dynamics . . . . . . . . . . . . . . . . . . . . . . 8W-35
Lamps-Backup . . . . . . . . . . . . . . . . . . . . . . . 8W-51 Sensor-Engine Coolant Temperatures . . . . . . 8W-30
Lamps-Fog Front . . . . . . . . . . . . . . . . . . . . . . 8W-50 Sensor-Evaporator Temperature . . . . . . . . . . 8W-42
Lamps-Headlamp . . . . . . . . . . . . . . . . . . . . . 8W-50 Sensor-Fuel Temperature . . . . . . . . . . . . . . . 8W-30
Lamps-Park/Turn Front . . . . . . . . . . . . . . 8W-50, 52 Sensor-Intake Air Temperature . . . . . . . . . . . 8W-30
Lamps-Side Repeater . . . . . . . . . . . . . . . . . . 8W-52 Sensor-Intake Air Temperature/Boost
Lamps-Tail Turn . . . . . . . . . . . . . . . . . . . . . . 8W-52 Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Lamps-Tail/Stop . . . . . . . . . . . . . . . . . . . . . . 8W-51 Sensor-Knock . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Lamps-Tail/Stop/Fog . . . . . . . . . . . . . . . . . . . 8W-51 Sensor-MAP . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Latches-Doors . . . . . . . . . . . . . . . . . . . . . . . . 8W-61 Sensor-Mass Air Flow . . . . . . . . . . . . . . . . . . 8W-30
Mirror-Inside Rearview . . . . . . . . . . . . . . 8W-49, 55 Sensor-Oil Temperature . . . . . . . . . . . . . . . . 8W-30
Mirrors-Outside Rearview . . . . . . . . . . . . . . . 8W-62 Sensor-Steering Angle . . . . . . . . . . . . . . . 8W-35, 65
Module-All Wheel Drive Control . . . . . . . . . . 8W-31 Sensor-Transmission Range . . . . . . . . . . . . . . 8W-31
8W - 02 - 2 8W-02 COMPONENT INDEX PM
cardiagn.com
Switch-Backup Lamp . . . . . . . . . . . . . . . . . . 8W-51 Valve-Manifold Flow . . . . . . . . . . . . . . . . . . . 8W-30
Switch-Bank . . . . . . . . . . . . . . 8W-35, 43, 50, 52, 63
PM 8W-11 FUSE/RELAY BLOCK 8W - 11 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-13 TOTALLY INTEGRATED POWER MODULE 8W - 13 - 1
cardiagn.com
Fuse 13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-12 Module-Heated Seats . . . . . . . . . . . . . . . . . . . . . 8W-13-20
Fuse 14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-11 Module-Intrusion Transceiver . . . . . . . . . . . . . . . . 8W-13-11
Fuse 15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-13 Module-Inverter . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-12
Fuse 16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-12 Module-Occupant Classification . . . . . . . . . . . . . . . 8W-13-9
Fuse 17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-9, 10 Module-Occupant Restraint Controller . . . . . . . . . . 8W-13-18
Fuse 18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-14 Module-Powertrain Control . . . . . . . . 8W-13-16, 18, 20, 27, 31
Fuse 19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-9, 10 Module-Sentry Key Remote Entry . . . . . . . . . . . . 8W-13-8, 9
Fuse 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-11 Module-Steering Control . . . . . . . . . . . . . . . . . 8W-13-9, 18
Fuse 21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-11 Module-Totally Integrated Power . . 8W-13-2, 3, 6, 7, 8, 9, 10, 11,
Fuse 22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-17 12, 13, 14, 15, 16, 17, 18, 19, 20,
Fuse 23 . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-14, 15 21, 22, 23, 24, 25, 26, 27, 28, 29, 30, 31, 32
Fuse 24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-17 Module-Transmission Control . . . . . . . . . . . . . . 8W-13-9, 22
Fuse 25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-17 Motor-Blower . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-23
Fuse 26 . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-14, 15, 16 Motor-Sunroof . . . . . . . . . . . . . . . . . . . . . . . 8W-13-12, 17
Fuse 27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-18 Motor-Wiper-Front . . . . . . . . . . . . . . . . . . . . . . . 8W-13-19
Fuse 28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-18 Motor-Wiper-Rear . . . . . . . . . . . . . . . . . . . . . 8W-13-12, 32
Fuse 30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-20 Power Outlet-Ac . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-12
Fuse 31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-20 Power Outlet-Instrument Panel . . . . . . . . . . . . . . . 8W-13-12
Fuse 32 . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-15, 16 Pump-Washer-Windshield . . . . . . . . . . . . . . . . . . 8W-13-32
Fuse 33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-20 Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-11
Fuse 34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-21 Receiver-Satellite . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-9
Fuse 35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-21 Relay-Cabin Heater 1 . . . . . . . . . . . . . . . . . 8W-13-7, 20, 23
Fuse/Relay Block . . . . . . . . . . . . . . . . . . . . 8W-13-7, 13, 19 Relay-Cabin Heater 2 . . . . . . . . . . . . . . . . . 8W-13-7, 20, 23
Fusible Link . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-6, 7 Relay-Main . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-14, 20
G100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-6, 7 Relay-Radiator Fan-Low/High . . . . . . . . . . . 8W-13-13, 19, 20
G101 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-6, 7 Relay-Radiator Fan-Medium/High . . . . . . . . 8W-13-13, 19, 20
G111 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-32 Relay-Radiator Fan-Series/Parallel . . . . . . . . . . 8W-13-19, 20
G112 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-32 Sensor-Ambient Air Temperature . . . . . . . . . . . . . . 8W-13-23
G200 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-8 Sensor-Brake Fluid Level . . . . . . . . . . . . . . . . . . 8W-13-25
G250 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-8 Sensor-Input Speed . . . . . . . . . . . . . . . . . . . . . . 8W-13-22
Generator . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-6, 7 Sensor-Mass Air Flow . . . . . . . . . . . . . . . . . . . . . 8W-13-14
Heater-PCV . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-27 Sensor-Output Speed . . . . . . . . . . . . . . . . . . . . . 8W-13-22
Horn 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-13 Sensor-Steering Angle . . . . . . . . . . . . . . . . . . 8W-13-18, 21
Horn 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-13 Sensor-Transmission Range . . . . . . . . . . . . . . . . . 8W-13-22
Injector-Fuel 1 . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-15 Siren . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-11
Injector-Fuel 2 . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-15 Solenoid-A/C Compressor . . . . . . . . . . . . . . . . . . . 8W-13-15
Injector-Fuel 3 . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-15 Solenoid-Camshaft 1/1 Position . . . . . . . . . . . . . . . 8W-13-15
Injector-Fuel 4 . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-15 Solenoid-Camshaft 1/2 Position . . . . . . . . . . . . . . . 8W-13-15
Lamp-Backup-Left . . . . . . . . . . . . . . . . . . . . . . . 8W-13-30 Speaker-Subwoofer . . . . . . . . . . . . . . . . . . . . . . 8W-13-10
Lamp-Backup-Right . . . . . . . . . . . . . . . . . . . . . . 8W-13-30 Starter . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-6, 7, 31
Lamp-Dome . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-12 Switch-Backup Lamp . . . . . . . . . . . . . . . . . . . . . 8W-13-25
Lamp-Fog-Left Front . . . . . . . . . . . . . . . . . . . . . 8W-13-30 Switch-Bank . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-20
Lamp-Fog-Right Front . . . . . . . . . . . . . . . . . . . . 8W-13-30 Switch-Ignition . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-8
Lamp-Headlamp-Left . . . . . . . . . . . . . . . . . . . 8W-13-29, 31 Switch-Mirror . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-9
Lamp-Headlamp-Right . . . . . . . . . . . . . . . . . . 8W-13-29, 31 Switch-Power Window-Driver . . . . . . . . . . . . . . . . 8W-13-29
Lamp-High Mounted Stop . . . . . . . . . . . . . . . . . . 8W-13-25 Switch-Security Hood . . . . . . . . . . . . . . . . . . . . . 8W-13-32
Lamp-License . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-26 Switch-Stop Lamp . . . . . . . . . . . . . . . . . . . 8W-13-8, 18, 25
Lamp-Park/Turn-Left Front . . . . . . . . . . . . . . . 8W-13-28, 31 Transponder-Tire Pressure-Left Front . . . . . . . . . . . 8W-13-18
Lamp-Park/Turn-Right Front . . . . . . . . . . . . . . 8W-13-28, 30 Transponder-Tire Pressure-Left Rear . . . . . . . . . . . 8W-13-18
Lamp-Side Repeater-Left . . . . . . . . . . . . . . . . . . . 8W-13-29 Transponder-Tire Pressure-Right Rear . . . . . . . . . . 8W-13-18
Lamp-Side Repeater-Right . . . . . . . . . . . . . . . . . . 8W-13-29 Valve-EGR Air Flow Control . . . . . . . . . . . . . . . . . 8W-13-15
Lamp-Tail Turn-Left . . . . . . . . . . . . . . . . . . . . . 8W-13-26
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-15 GROUND DISTRIBUTION 8W - 15 - 1
cardiagn.com
G250 . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-7, 8, 9 Module-Inverter . . . . . . . . . . . . . . . . . . . . . . . 8W-15-6
G300 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-10 Module-Occupant Classification . . . . . . . . . . . 8W-15-10
G301 . . . . . . . . . . . . . . . . . . . . . . 8W-15-10, 11, 12, 13 Module-Occupant Restraint Controller . . . . . . . 8W-15-10
G302 . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-14, 15, 16 Module-Powertrain Control . . . . . . . . . . . . . . . 8W-15-4
G303 . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-17, 18, 19 Module-Sentry Key Remote Entry . . . . . . . . . . 8W-15-9
Heater-Cabin . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-14 Module-Steering Control . . . . . . . . . . . . . . 8W-15-6, 7, 8
Heater-PCV . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-3 Module-Totally Integrated Power . . . . . . . . . 8W-15-4, 5
Heater-Seat Back-Left . . . . . . . . . . . . . . . . . . 8W-15-13 Module-Transmission Control . . . . . . . . . . 8W-15-12, 17
Heater-Seat Back-Right . . . . . . . . . . . . . . . . . 8W-15-18 Motor-Sunroof . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-9
Heater-Seat Cushion-Left . . . . . . . . . . . . . . . . 8W-15-13 Motor-Wiper-Front . . . . . . . . . . . . . . . . . . . . . 8W-15-5
Heater-Seat Cushion-Right . . . . . . . . . . . . . . 8W-15-18 Motor-Wiper-Rear . . . . . . . . . . . . . . . . . . . . . 8W-15-12
Lamp-Backup-Left . . . . . . . . . . . . . . . . . . . . 8W-15-11 Power Outlet-Instrument Panel . . . . . . . . . . . . 8W-15-6
Lamp-Backup-Right . . . . . . . . . . . . . . . . . . . 8W-15-17 Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-8
Lamp-Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-7 Receiver-Satellite . . . . . . . . . . . . . . . . . . . . . 8W-15-16
Lamp-Cup Holder . . . . . . . . . . . . . . . . . . . . . . 8W-15-9 Relay-Radiator Fan-Series/Parallel . . . . . . . . . . 8W-15-4
Lamp-Dome . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-7 Sensor-Brake Fluid Level . . . . . . . . . . . . . . . . 8W-15-3
Lamp-Fog-Left Front . . . . . . . . . . . . . . . . . . . . 8W-15-5 Sensor-Oxygen 1/1 . . . . . . . . . . . . . . . . . . . . . 8W-15-3
Lamp-Fog-Right Front . . . . . . . . . . . . . . . . . 8W-15-3, 5 Sensor-Oxygen 1/2 . . . . . . . . . . . . . . . . . . . . . 8W-15-5
Lamp-Headlamp-Left . . . . . . . . . . . . . . . . . . . 8W-15-5 Sensor-Steering Angle . . . . . . . . . . . . . . . . . . . 8W-15-8
Lamp-Headlamp-Right . . . . . . . . . . . . . . . . . . 8W-15-2 Siren . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-4
Lamp-High Mounted Stop . . . . . . . . . . . . . . . 8W-15-12 Solenoid-A/C Compressor . . . . . . . . . . . . . . . . . 8W-15-3
Lamp-License . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-12 Speaker-Subwoofer . . . . . . . . . . . . . . . . . . . . 8W-15-17
Lamp-Park/Turn-Left Front . . . . . . . . . . . . . . . 8W-15-5 Switch-Backup Lamp . . . . . . . . . . . . . . . . . . . 8W-15-11
Lamp-Park/Turn-Right Front . . . . . . . . . . . . . . 8W-15-2 Switch-Bank . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-6
Lamp-Side Repeater-Left . . . . . . . . . . . . . . . . 8W-15-14 Switch-Clutch Interlock . . . . . . . . . . . . . . . . . 8W-15-14
Lamp-Side Repeater-Right . . . . . . . . . . . . . . . . 8W-15-3 Switch-EVAP System Monitor . . . . . . . . . . . . . 8W-15-16
Lamp-Tail Turn-Left . . . . . . . . . . . . . . . . . . . 8W-15-11 Switch-Ignition . . . . . . . . . . . . . . . . . . . . . . 8W-15-7, 8
Lamp-Tail Turn-Right . . . . . . . . . . . . . . . . . . 8W-15-18 Switch-Mirror . . . . . . . . . . . . . . . . . . . . . 8W-15-10, 13
Lamp-Tail/Stop-Left . . . . . . . . . . . . . . . . . . . 8W-15-11 Switch-Power Window-Driver . . . . . . . . 8W-15-10, 13, 15
Lamp-Tail/Stop-Right . . . . . . . . . . . . . . . . 8W-15-11, 17 Switch-Seat Belt-Driver . . . . . . . . . . . . . . . . . 8W-15-14
Lamp-Tail/Stop/Fog-Left . . . . . . . . . . . . . . . . . 8W-15-11 Switch-Security Hood . . . . . . . . . . . . . . . . . . . 8W-15-3
Lamp-Tail/Stop/Fog-Right . . . . . . . . . . . . . . . 8W-15-17 Switch-Stop Lamp . . . . . . . . . . . . . . . . . . . . . 8W-15-17
Lamp-Turn-Left Front . . . . . . . . . . . . . . . . . . . 8W-15-5 Transponder-Tire Pressure-Left Front . . . . . . . 8W-15-12
Lamp-Turn-Right Front . . . . . . . . . . . . . . . . . . 8W-15-2 Transponder-Tire Pressure-Left Rear . . . . . . . . 8W-15-12
Latch-Door-Driver . . . . . . . . . . . . . . . . . . 8W-15-10, 13 Transponder-Tire Pressure-Right Rear . . . . 8W-15-14, 18
Latch-Door-Left Rear . . . . . . . . . . . . . . . . 8W-15-16, 18 Valve-EGR Air Flow Control . . . . . . . . . . . . . . 8W-15-3
Latch-Door-Liftgate . . . . . . . . . . . . . . . . . . . . 8W-15-12 Valve-Manifold Flow . . . . . . . . . . . . . . . . . . . . 8W-15-3
Latch-Door-Passenger . . . . . . . . . . . . . 8W-15-13, 18, 19
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-18 BUS COMMUNICATIONS 8W - 18 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-20 CHARGING SYSTEM 8W - 20 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-21 STARTING SYSTEM 8W - 21 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-30 FUEL/IGNITION SYSTEM 8W - 30 - 1
cardiagn.com
Fuse 26 . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-2, 18 Sensor-Engine Coolant Temperature 1 . . . . 8W-30-7
Fuse 28 . . . . . . . . . . . . . . . . . . . . . . 8W-30-3, 14, 16 Sensor-Engine Coolant Temperature 2 . . . . 8W-30-8
Fuse 32 . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-2, 16 Sensor-Fuel Temperature . . . . . . . . . . . . . 8W-30-22
Fuse 33 . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-2, 3 Sensor-Intake Air Temperature . . . . . . . . . 8W-30-8
Fuse/Relay Block . . . . . . . . . . . . . . . . . . . 8W-30-19 Sensor-Intake Air Temperature/Boost
Fusible Link . . . . . . . . . . . . . . . . . . . . . . . 8W-30-11 Pressure . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-21
G110 . . . . . . . . . . . . . . . . . . . 8W-30-7, 9, 13, 15, 18 Sensor-Knock . . . . . . . . . . . . . . . . . . . . . . 8W-30-11
G111 . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-3, 15, 16 Sensor-MAP . . . . . . . . . . . . . . . . . . . . . . 8W-30-6, 7
G112 . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-9, 19 Sensor-Mass Air Flow . . . . . . . . . . . . . . . . 8W-30-17
G302 . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-5, 13, 14 Sensor-Oil Temperature . . . . . . . . . . . . . . . 8W-30-8
G303 . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-13, 14 Sensor-Oxygen 1/1 . . . . . . . . . . . . . . . . . . . 8W-30-9
Generator . . . . . . . . . . . . . . . . . . . . . . 8W-30-11, 22 Sensor-Oxygen 1/2 . . . . . . . . . . . . . . . . . . . 8W-30-9
Glow Plug 1 . . . . . . . . . . . . . . . . . . . . . . . 8W-30-19 Sensor-Transmission Range . . . . . . . . . . . . 8W-30-8
Glow Plug 2 . . . . . . . . . . . . . . . . . . . . . . . 8W-30-19 Sensor-Vehicle Speed . . . . . . . . . . . . . . . . 8W-30-10
Glow Plug 3 . . . . . . . . . . . . . . . . . . . . . . . 8W-30-19 Solenoid-A/C Compressor . . . . . . . . . . 8W-30-11, 23
Glow Plug 4 . . . . . . . . . . . . . . . . . . . . . . . 8W-30-19 Solenoid-Camshaft 1/1 Position . . . . . . . . . 8W-30-4
Heater-PCV . . . . . . . . . . . . . . . . . . . . . . . 8W-30-13 Solenoid-Camshaft 1/2 Position . . . . . . . . . 8W-30-4
Injector-Fuel 1 . . . . . . . . . . . . . . . . . . . . . . 8W-30-4 Solenoid-EVAP Purge . . . . . . . . . . . . . . . . 8W-30-11
Injector-Fuel 2 . . . . . . . . . . . . . . . . . . . . . . 8W-30-4 Switch-Clutch Interlock . . . . . . . . . . . . . . 8W-30-14
Injector-Fuel 3 . . . . . . . . . . . . . . . . . . . . . . 8W-30-4 Switch-EVAP System Monitor . . . . . . . . . . 8W-30-5
Injector-Fuel 4 . . . . . . . . . . . . . . . . . . . . . . 8W-30-4 Switch-Engine Oil Pressure . . . . . . . . . . . 8W-30-11
Injector-Fuel-No. 1 . . . . . . . . . . . . . . . . . . 8W-30-24 Switch-Ignition . . . . . . . . . . . . . . . . . . . . . 8W-30-18
Injector-Fuel-No. 2 . . . . . . . . . . . . . . . . . . 8W-30-24 Switch-Oil Pressure . . . . . . . . . . . . . . . . . 8W-30-23
Injector-Fuel-No. 3 . . . . . . . . . . . . . . . . . . 8W-30-24 Switch-Stop Lamp . . . . . . . . . . . . . . . . . . 8W-30-14
Injector-Fuel-No. 4 . . . . . . . . . . . . . . . . . . 8W-30-24 Throttle Body . . . . . . . . . . . . . . . . . . . . . . . 8W-30-6
Module-Engine Control . . . . . . 8W-30-2, 14, 16, 17, Valve-EGR Air Flow Control . . . . . . . . . . . 8W-30-18
18, 19, 20, 21, 22, 23, 24 Valve-Manifold Flow . . . . . . . . . . . . . . . . . . 8W-30-7
Module-Fuel Pump . . . . . . . . . . . . . . . . . . 8W-30-13
Module-Glow Plug . . . . . . . . . . . . . . . . . . 8W-30-19
Module-Powertrain Control . . 8W-30-2, 3, 4, 5, 6, 7,
8, 9, 10, 11, 12, 14
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-31 TRANSMISSION CONTROL SYSTEM 8W - 31 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-33 VEHICLE SPEED CONTROL 8W - 33 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-35 ANTILOCK BRAKES 8W - 35 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-39 VEHICLE THEFT SECURITY SYSTEM 8W - 39 - 1
cardiagn.com
Horn 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-39-15 Module-Headlamp Leveling-Left . . . . . . . . 8W-39-13
Horn 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-39-15 Module-Headlamp Leveling-Right . . . . . . 8W-39-13
Lamp-Backup-Left . . . . . . . . . . . . . . . . . . 8W-39-11 Module-Intrusion Transceiver . . . . . . . 8W-39-16, 17
Lamp-Backup-Right . . . . . . . . . . . . . . . . . 8W-39-11 Module-Sentry Key Remote Entry . . . . . 8W-39-2, 3
Lamp-Dome . . . . . . . . . . . . . . . . . . . . . . . 8W-39-17 Module-Totally Integrated Power . . . 8W-39-2, 3, 10,
Lamp-Headlamp-Left . . . . . . . . . . . . . . . . 8W-39-12 11, 12, 13, 14, 15, 16
Lamp-Headlamp-Right . . . . . . . . . . . . . . . 8W-39-12 Siren . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-39-16
Lamp-License . . . . . . . . . . . . . . . . . . . . . . 8W-39-10 Switch-Ignition . . . . . . . . . . . . . . . . . . . . . . 8W-39-2
Lamp-Park/Turn-Left Front . . . . . . . . 8W-39-12, 13 Switch-Power Window-Driver . . . . . . . . . 8W-39-4, 5
Lamp-Park/Turn-Right Front . . . . . . . 8W-39-11, 13 Switch-Security Hood . . . . . . . . . . . . . . . . 8W-39-15
Lamp-Side Repeater-Left . . . . . . . . . . . . . 8W-39-14 Transponder-Tire Pressure-Left Front . . . . 8W-39-3
Lamp-Side Repeater-Right . . . . . . . . . . . . 8W-39-14 Transponder-Tire Pressure-Left Rear . . . . . 8W-39-3
Lamp-Tail Turn-Left . . . . . . . . . . . . . . . . . 8W-39-10 Transponder-Tire Pressure-Right Rear . . . . 8W-39-3
Lamp-Tail Turn-Right . . . . . . . . . . . . . . . . 8W-39-10
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-40 INSTRUMENT CLUSTER 8W - 40 - 1
cardiagn.com
Lamp-Cup Holder . . . . . . . . . . . . . . . . . . . . 8W-40-4 Switch-Parking Brake . . . . . . . . . . . . . . . . 8W-40-3
Lamp-Dome . . . . . . . . . . . . . . . . . . . . . . . . 8W-40-6 Switch-Power Window-Driver . . . . . . . . . . . 8W-40-6
Lamp-High Mounted Stop . . . . . . . . . . . . 8W-40-10 Switch-Seat Belt-Driver . . . . . . . . . . . . . . . 8W-40-3
Lamp-Vanity-Left . . . . . . . . . . . . . . . . . . . . 8W-40-6 Switch-Stop Lamp . . . . . . . . . . . . . . . . . . 8W-40-10
Latch-Door-Driver . . . . . . . . . . . . . . 8W-40-5, 7, 8, 9 Transponder-Tire Pressure-Left Front . . . 8W-40-11
Latch-Door-Left Rear . . . . . . . . . . . 8W-40-5, 7, 8, 9 Transponder-Tire Pressure-Left Rear . . . . 8W-40-11
Latch-Door-Liftgate . . . . . . . . . . . . . . 8W-40-5, 7, 8 Transponder-Tire Pressure-Right Rear . . . 8W-40-11
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-41 HORN/CIGAR LIGHTER/POWER OUTLET 8W - 41 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-42 AIR CONDITIONING/HEATER 8W - 42 - 1
cardiagn.com
Fuse/Relay Block . . . . . . . . . . . . . . . . . . 8W-42-6, 7 Sensor-Ambient Air Temperature . . . . . . . . 8W-42-4
G110 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42-3 Sensor-Evaporator Temperature . . . . . . . . . 8W-42-5
G111 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42-7 Solenoid-A/C Compressor . . . . . . . . . . . . . . 8W-42-3
G200 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42-2 Transducer-A/C Pressure . . . . . . . . . . . . . . 8W-42-5
G302 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42-6
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-43 OCCUPANT RESTRAINT SYSTEM 8W - 43 - 1
cardiagn.com
G302 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43-3 Sensor-Side Impact-Right 2 . . . . . . . . . . . . 8W-43-5
Module-Occupant Classification . . . . . 8W-43-2, 3, 6 Switch-Bank . . . . . . . . . . . . . . . . . . . . . . . . 8W-43-3
Module-Occupant Restraint Switch-Seat Belt-Driver . . . . . . . . . . . . . . . 8W-43-3
Controller . . . . . . . . . . . . . . . . . . 8W-43-2, 3, 4, 5 Switch-Seat Belt-Passenger . . . . . . . . . . . . 8W-43-3
Module-Steering Control . . . . . . . . . . . . . . 8W-43-4
Module-Totally Integrated Power . . . . . . 8W-43-2, 3
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-44 INTERIOR LIGHTING 8W - 44 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-47 AUDIO SYSTEM 8W - 47 - 1
cardiagn.com
Module-Hands Free . . . . . . . . . . . . . . . 8W-47-4, 11 Switch-Remote Radio-Right . . . . . . . . . . . 8W-47-11
Module-Steering Control . . . . . . . . . . . . . . 8W-47-11
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-48 REAR WINDOW DEFOGGER 8W - 48 - 1
cardiagn.com
cardiagn.com
PM 8W-49 OVERHEAD CONSOLE 8W - 49 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-50 FRONT LIGHTING 8W - 50 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-51 REAR LIGHTING 8W - 51 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-52 TURN SIGNALS 8W - 52 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-53 WIPERS 8W - 53 - 1
8W-53 WIPERS
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-55 NAVIGATION/TELECOMMUNICATIONS 8W - 55 - 1
8W-55 NAVIGATION/TELECOMMUNICATIONS
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-60 POWER WINDOWS 8W - 60 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-61 POWER DOOR LOCKS 8W - 61 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-62 POWER MIRRORS 8W - 62 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-63 POWER SEATS 8W - 63 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-64 POWER SUNROOF 8W - 64 - 1
cardiagn.com
cardiagn.com
PM 8W-65 SPEED PROPORTIONAL STEERING 8W - 65 - 1
cardiagn.com
cardiagn.com
cardiagn.com
cardiagn.com
PM 8W-70 SPLICE INFORMATION 8W - 70 - 1
cardiagn.com
S102 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-6 S323 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42-6
S103 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-15 S326 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-26
S104 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-14 S327 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-20
S105 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-7 S328 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-10
S106 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-7 S331 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-39-9
S107 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-8 S332 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-39-9
S108 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-3 S334 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-22
S109 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-12 S335 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-31-4
S110 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-12 S336 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-10
S111 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-12 S340 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-12
S112 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-12 S345 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-17
S113 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-20-2, 3 S348 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-47-2
S120 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-24 S349 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-19
S121 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-22 S350 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-62-3
S150 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-20-2, 3 S351 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-13
S153 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-24 S352 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-62-5
S200 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-12 S353 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-62-4
S201 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-9 S354 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-62-5
S202 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-11 S355 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-12
S203 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-9 S360 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-44-3
S204 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42-2 S361 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-7
S205 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-18-3 S362 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-9
S206 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-18-4 S368 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-47-9
S207 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-18-7 S370 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-10
S208 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-18 S372 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-47-9
S209 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-17 S373 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-47-9
S214 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-44-4 S374 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-47-9
S216 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-9 S375 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43-6
S217 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-7 S376 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43-6
S220 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-8 S377 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43-6
S225 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-47-11 S378 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43-6
S300 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13-9 S381 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15-13
S301 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-18-3 S390 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-13
S302 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-18-4
cardiagn.com
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 1
cardiagn.com
Assembly-Shift Lever (Autostick) . . . . . . . . 8W-80-8 C303 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-29
Assembly-Transmission Solenoid/Pressure C304 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-29
Switch . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-9 C304 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-30
Assembly-Valve Block (Diesel) . . . . . . . . . . 8W-80-9 C305 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-30
Backlite-Electric Heated (Ground) . . . . . . . 8W-80-9 C305 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-30
Backlite-Electric Heated (Power) . . . . . . . 8W-80-10 C306 (RHD) . . . . . . . . . . . . . ... . . . . . . . 8W-80-31
Battery-Negative (Diesel) . . . . . . . . . . . . . 8W-80-10 C306 (RHD) . . . . . . . . . . . . . ... . . . . . . . 8W-80-31
Battery-Negative (Gas) . . . . . . . . . . . . . . . 8W-80-10 C308 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-32
Battery-Positive (Diesel) . . . . . . . . . . . . . . 8W-80-10 C308 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-32
Battery-Positive (Gas) . . . . . . . . . . . . . . . 8W-80-10 C309 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-33
Battery-Positive (Gas) . . . . . . . . . . . . . . . . 8W-80-11 C309 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-33
Battery-Positive (Diesel) . . . . . . . . . . . . . . 8W-80-11 C310 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-34
C100 (Diesel) . . . . . . . . . . . . . . . . . . . . . . 8W-80-11 C310 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-34
C100 (Diesel) . . . . . . . . . . . . . . . . . . . . . . 8W-80-12 C311 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-34
C100 (Gas) . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-12 C311 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-34
C100 (Gas) . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-12 C312 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-35
C101 (Diesel) . . . . . . . . . . . . . . . . . . . . . . 8W-80-13 C312 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-35
C101 (Diesel) . . . . . . . . . . . . . . . . . . . . . . 8W-80-13 C313 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-35
C102 (Diesel) . . . . . . . . . . . . . . . . . . . . . . 8W-80-13 C313 . . . . . . . . . . . . . . . . . . . ... . . . . . . . 8W-80-35
C102 (Diesel) . . . . . . . . . . . . . . . . . . . . . . 8W-80-14 Capacitor-Ignition (Gas) . . . . ... . . . . . . . 8W-80-36
C103 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-14 Cluster C1 . . . . . . . . . . . . . . ... . . . . . . . 8W-80-36
C103 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-15 Cluster C2 . . . . . . . . . . . . . . ... . . . . . . . 8W-80-36
C104 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-16 Cluster C3 . . . . . . . . . . . . . . ... . . . . . . . 8W-80-37
C104 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-16 Cluster C4 . . . . . . . . . . . . . . ... . . . . . . . 8W-80-37
C105 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-17 Coil-Ignition 1 (Gas) . . . . . . . ... . . . . . . . 8W-80-38
C105 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-17 Coil-Ignition 2 (Gas) . . . . . . . ... . . . . . . . 8W-80-38
C106 (CVT) . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-17 Coil-Ignition 3 (Gas) . . . . . . . ... . . . . . . . 8W-80-38
C106 (CVT) . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-17 Coil-Ignition 4 (Gas) . . . . . . . ... . . . . . . . 8W-80-38
C200 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-18 Control-A/C-Heater C1 . . . . . ... . . . . . . . 8W-80-38
C200 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-19 Control-A/C-Heater C2 . . . . . ... . . . . . . . 8W-80-39
C201 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-20 Data Link Connector . . . . . . ... . . . . . . . 8W-80-39
C201 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-21 Fan Module-Radiator Cooling C1 . . . . . . . 8W-80-39
C202 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-22 Fan Module-Radiator Cooling C2 . . . . . . . 8W-80-39
C202 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-22 Generator (Gas) . . . . . . . . . . ... . . . . . . . 8W-80-40
C203 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-23 Generator (Diesel) . . . . . . . . ... . . . . . . . 8W-80-40
C203 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-23 Generator-Eyelet . . . . . . . . . ... . . . . . . . 8W-80-40
8W - 80 - 2 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
Horn 2 (Export) . . . . . . . . . . . . . . . . . . . . 8W-80-44 Mirror-Outside Rearview-Driver . . . . . . . . 8W-80-56
Injector-Fuel 1 (Gas) . . . . . . . . . . . . . . . . . 8W-80-44 Mirror-Outside Rearview-Passenger . . . . . 8W-80-57
Injector-Fuel 1 (Diesel) . . . . . . . . . . . . . . . 8W-80-44 Module-All Wheel Drive Control (AWD) . . 8W-80-57
Injector-Fuel 2 (Diesel) . . . . . . . . . . . . . . . 8W-80-44 Module-Anti-Lock Brakes . . . . . . . . . . . . . 8W-80-58
Injector-Fuel 2 (Gas) . . . . . . . . . . . . . . . . . 8W-80-45 Module-Compass . . . . . . . . . . . . . . . . . . . 8W-80-59
Injector-Fuel 3 (Gas) . . . . . . . . . . . . . . . . . 8W-80-45 Module-Electronic Overhead C1 . . . . . . . . 8W-80-59
Injector-Fuel 3 (Diesel) . . . . . . . . . . . . . . . 8W-80-45 Module-Electronic Overhead C2 . . . . . . . . 8W-80-59
Injector-Fuel 4 (Diesel) . . . . . . . . . . . . . . . 8W-80-45 Module-Engine Control C1 (Diesel) . . . . . 8W-80-60
Injector-Fuel 4 (Gas) . . . . . . . . . . . . . . . . . 8W-80-46 Module-Engine Control C2 (Diesel) . . . . . 8W-80-62
Lamp-Backup-Left . . . . . . . . . . . . . . . . . . 8W-80-46 Module-Fuel Pump (FWD) . . . . . . . . . . . . 8W-80-63
Lamp-Backup-Right . . . . . . . . . . . . . . . . . 8W-80-46 Module-Fuel Pump C1 (AWD) . . . . . . . . . 8W-80-63
Lamp-Cargo . . . . . . . . . . . . . . . . . . . . . . . 8W-80-46 Module-Fuel Pump C2 (AWD) . . . . . . . . . 8W-80-63
Lamp-Cup Holder . . . . . . . . . . . . . . . . . . . 8W-80-47 Module-Glow Plug . . . . . . . . . . . . . . . . . . 8W-80-63
Lamp-Dome . . . . . . . . . . . . . . . . . . . . . . . 8W-80-47 Module-Hands Free . . . . . . . . . . . . . . . . . 8W-80-64
Lamp-Dome (Rechargeable) . . . . . . . . . . . 8W-80-47 Module-Headlamp Leveling-Left (Export) . 8W-80-64
Lamp-Fog-Left Front . . . . . . . . . . . . . . . . 8W-80-47 Module-Headlamp Leveling-Right
Lamp-Fog-Right Front . . . . . . . . . . . . . . . 8W-80-47 (Export) . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-64
Lamp-Headlamp-Left . . . . . . . . . . . . . . . . 8W-80-48 Module-Heated Seats . . . . . . . . . . . . . . . . 8W-80-65
Lamp-Headlamp-Right . . . . . . . . . . . . . . . 8W-80-48 Module-Intrusion Transceiver C1 . . . . . . . 8W-80-65
Lamp-High Mounted Stop . . . . . . . . . . . . 8W-80-48 Module-Intrusion Transceiver C2 . . . . . . . 8W-80-65
Lamp-License . . . . . . . . . . . . . . . . . . . . . . 8W-80-48 Module-Inverter C1 (Except Export) . . . . . 8W-80-65
Lamp-Park/Turn-Left Front (Except Module-Inverter C2 (Except Export) . . . . . 8W-80-66
Export) . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-49 Module-Occupant Classification C1 (Except
Lamp-Park/Turn-Right Front (Except Export) . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-66
Export) . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-49 Module-Occupant Classification C2 (Except
Lamp-Side Repeater-Left (Export) . . . . . . 8W-80-49 Export) . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-66
Lamp-Side Repeater-Right (Export) . . . . . 8W-80-49 Module-Occupant Restraint Controller C1
Lamp-Tail Turn-Left . . . . . . . . . . . . . . . . . 8W-80-50 (ORC) . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-67
Lamp-Tail Turn-Right . . . . . . . . . . . . . . . . 8W-80-50 Module-Occupant Restraint Controller C2
Lamp-Tail/Stop-Left (Except Export) . . . . 8W-80-50 (ORC) . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-68
Lamp-Tail/Stop-Right (Except Export) . . . 8W-80-51 Module-Powertrain Control C1 (Gas) . . . . 8W-80-69
Lamp-Tail/Stop/Fog-Left (Export) . . . . . . . 8W-80-51 Module-Powertrain Control C2 (Gas) . . . . 8W-80-70
Lamp-Tail/Stop/Fog-Right (Export) . . . . . . 8W-80-51 Module-Sentry Key Remote Entry . . . . . . 8W-80-72
Lamp-Turn-Left Front (Export) . . . . . . . . 8W-80-51 Module-Steering Control C1 . . . . . . . . . . . 8W-80-72
Lamp-Turn-Right Front (Export) . . . . . . . 8W-80-52 Module-Steering Control C2 . . . . . . . . . . . 8W-80-72
Lamp-Vanity-Left . . . . . . . . . . . . . . . . . . . 8W-80-52 Module-Steering Control C4 . . . . . . . . . . . 8W-80-72
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 3
cardiagn.com
Motor-Window-Right Front . . . . . . . . . . . . 8W-80-80 Sensor-Side Impact-Right 1 . . . . . . . . . . . 8W-80-93
Motor-Window-Right Rear . . . . . . . . . . . . 8W-80-80 Sensor-Side Impact-Right 2 . . . . . . . . . . . 8W-80-93
Motor-Wiper-Front . . . . . . . . . . . . . . . . . . 8W-80-80 Sensor-Steering Angle . . . . . . . . . . . . . . . 8W-80-93
Motor-Wiper-Rear . . . . . . . . . . . . . . . . . . . 8W-80-80 Sensor-Transmission Range . . . . . . . . . . . 8W-80-93
Power Outlet-AC (Except Export) . . . . . . . 8W-80-81 Sensor-Vehicle Speed (Gas MTX) . . . . . . . 8W-80-94
Power Outlet-Instrument Panel . . . . . . . . 8W-80-81 Sensor-Wheel Speed-ABS-Left Front . . . . 8W-80-94
Pump-Washer-Windshield . . . . . . . . . . . . . 8W-80-81 Sensor-Wheel Speed-ABS-Left Rear . . . . . 8W-80-94
Radio C1 . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-82 Sensor-Wheel Speed-ABS-Right Front . . . 8W-80-94
Radio C2 (Satellite Radio) . . . . . . . . . . . . 8W-80-82 Sensor-Wheel Speed-ABS-Right Rear . . . . 8W-80-95
Receiver-Satellite C1 . . . . . . . . . . . . . . . . 8W-80-83 Siren (Export) . . . . . . . . . . . . . . . . . . . . . . 8W-80-95
Receiver-Satellite C2 . . . . . . . . . . . . . . . . 8W-80-83 Solenoid-A/C Compressor . . . . . . . . . . . . . 8W-80-95
Relay-Cabin Heater 1 (Diesel) . . . . . . . . . 8W-80-83 Solenoid-Camshaft 1/1 Position (Gas) . . . . 8W-80-95
Relay-Cabin Heater 2 (Diesel) . . . . . . . . . 8W-80-83 Solenoid-Camshaft 1/2 Position (Gas) . . . . 8W-80-96
Resistor-Blower Motor . . . . . . . . . . . . . . . 8W-80-84 Solenoid-Electronically Controlled Clutch
Seat Belt-Tensioner-Driver . . . . . . . . . . . . 8W-80-84 (ECC) . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-96
Seat Belt-Tensioner-Passenger . . . . . . . . . 8W-80-84 Solenoid-EVAP Purge (Gas) . . . . . . . . . . . 8W-80-96
Sensor-Accelerator Pedal Position . . . . . . 8W-80-84 Speaker-Instrument Panel-Left
Sensor-Ambient Air Temperature . . . . . . . 8W-80-85 (Premium) . . . . . . . . . . . . . . . . . . . . . . 8W-80-96
Sensor-Brake Fluid Level . . . . . . . . . . . . . 8W-80-85 Speaker-Instrument Panel-Right
Sensor-Camshaft 1/1 Position (Gas) . . . . . 8W-80-85 (Premium) . . . . . . . . . . . . . . . . . . . . . . 8W-80-96
Sensor-Camshaft 1/2 Position (Gas) . . . . . 8W-80-85 Speaker-Left Front Door . . . . . . . . . . . . . . 8W-80-97
Sensor-Camshaft Position (Diesel) . . . . . . 8W-80-86 Speaker-Left Rear . . . . . . . . . . . . . . . . . . 8W-80-97
Sensor-Crankshaft Position (Diesel) . . . . . 8W-80-86 Speaker-Liftgate (Except Base) . . . . . . . . . 8W-80-97
Sensor-Crankshaft Position (Gas) . . . . . . . 8W-80-86 Speaker-Right Front Door . . . . . . . . . . . . 8W-80-97
Sensor-Dynamics (ESP) . . . . . . . . . . . . . . 8W-80-86 Speaker-Right Rear . . . . . . . . . . . . . . . . . 8W-80-98
Sensor-Engine Coolant Temperature Speaker-Subwoofer (Premium) . . . . . . . . . 8W-80-98
(Diesel) . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-87 Starter . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-98
Sensor-Engine Coolant Temperature 1 Starter-Eyelet-Battery Side (Gas) . . . . . . . 8W-80-98
(Gas) . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-87 Starter-Eyelet-Battery Side (Diesel) . . . . . 8W-80-98
Sensor-Engine Coolant Temperature 2 Starter-Eyelet-Generator Side . . . . . . . . . 8W-80-99
(Gas) . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-87 Switch-Backup Lamp (Diesel) . . . . . . . . . . 8W-80-99
Sensor-Evaporator Temperature . . . . . . . . 8W-80-87 Switch-Backup Lamp (Gas MTX) . . . . . . . 8W-80-99
Sensor-Front Impact-Left . . . . . . . . . . . . . 8W-80-88 Switch-Bank . . . . . . . . . . . . . . . . . . . . . . . 8W-80-99
Sensor-Front Impact-Right . . . . . . . . . . . . 8W-80-88 Switch-Clutch Interlock (MTX) . . . . . . . . 8W-80-100
Sensor-Fuel Temperature (Diesel) . . . . . . 8W-80-88 Switch-Engine Oil Pressure (Gas) . . . . . . 8W-80-100
Sensor-Input Speed (CVT) . . . . . . . . . . . . 8W-80-88
8W - 80 - 4 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 5
cardiagn.com
AIRBAG-DRIVER SQUIB 2 - NATURAL/YELLOW 2 WAY
CAV CIRCUIT FUNCTION
1 R63 20RD DRIVER SQUIB 2 LINE 1
2 R61 20YL DRIVER SQUIB 2 LINE 2
cardiagn.com
AIRBAG-SIDE CURTAIN-LEFT - YELLOW/BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 R1 18LB/WT LEFT CURTAIN SQUIB 1 LINE 2
2 R3 18LB/OR LEFT CURTAIN SQUIB 1 LINE 1
cardiagn.com
7 X51 18DG/DB LEFT REAR SPEAKER (+)
8 X52 18GY/DB RIGHT REAR SPEAKER (+)
9 Z960 16BK/LB GROUND
10 X299 18GY/BR LEFT INSTRUMENT PANEL SPEAKER (-)
11 X298 18GY/LG RIGHT INSTRUMENT PANEL SPEAKER (-)
12 - -
13 A420 18WT/RD FUSED B(+) (I.O.D.)
14 - -
15 - -
16 - -
17 D54 20WT/PK CAN B BUS (-)
18 X57 18DG/BR LEFT REAR SPEAKER (-)
19 X58 18GY/OR RIGHT REAR SPEAKER (-)
20 Z960 16BK/LB GROUND
cardiagn.com
ASSEMBLY-SHIFT LEVER (EXCEPT AUTOSTICK) - LT. GRAY 4 WAY
CAV CIRCUIT FUNCTION
1 Z937 20BK/YL GROUND
2 E12 20OR/GY PANEL LAMPS DRIVER
3 Z937 20BK/YL GROUND
4 K321 20BR/YL BRAKE TRANSMISSION SHIFT INTERLOCK SOLENOID
UNLOCK
cardiagn.com
18 T21 18DG/YL PRIMARY PRESSURE SENSOR SIGNAL
19 T13 18DG/VT SENSOR GROUND
20 - -
21 T302 18DG/BR CLOCK SELECT
22 T327 18GY/YL DATA IN/OUT SELECT
cardiagn.com
BATTERY-NEGATIVE (GAS) - 1 WAY
CAV CIRCUIT FUNCTION
1 Z901 4BK GROUND
1 Z912 4BK GROUND
cardiagn.com
4 K343 20BR/YL FUSED MAIN RELAY OUTPUT
5 K344 20BR/GY FUSED MAIN RELAY OUTPUT
6 V71 20VT/OR S/C SIGNAL 1
7 A202 16RD/WT GLOW PLUG 1 CONTROL
8 A203 16RD GLOW PLUG 2 CONTROL
9 A204 16RD/YL GLOW PLUG 3 CONTROL
10 A208 16RD/OR GLOW PLUG 4 CONTROL
11 K957 20BR/OR MAF SENSOR GROUND
12 T750 16YL/GY STARTER CONTROL OUTPUT
13 K157 20BR/OR MAF SENSOR SIGNAL
14 K92 20BR GEN OUTPUT SIGNAL
15 G329 20VT/OR CHARGE INDICATOR SIGNAL
16 F855 20PK/YL 5 VOLT SUPPLY
17 K35 20DB/VT EGR SOLENOID CONTROL
18 - -
19 - -
20 - -
8W - 80 - 12 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
18 - -
19 - -
20 - -
cardiagn.com
C101 (DIESEL) - BLACK (ENGINE SIDE) 14 WAY
CAV CIRCUIT FUNCTION
1 K844 20DB/YL CMP SENSOR 5 VOLT SUPPLY
2 K44 20DB/GY CMP 1/1 SIGNAL
3 K944 20BK/GY CMP SENSOR GROUND
4 K853 20DB/BR CKP SENSOR 5 VOLT SUPPLY
5 K24 20BR/LB CKP SENSOR SIGNAL
6 K925 20DB/WT CKP SENSOR GROUND
7 G6 20VT/GY EOP SIGNAL
8 K343 16BR/YL FUSED MAIN RELAY OUTPUT
9 K601 16BR/VT EGR AIR FLOW CONTROL VALVE CONTROL
10 K604 20BR/WT EGR AIR FLOW CONTROL VALVE SIGNAL
11 Z924 16BK GROUND
12 - -
13 - -
14 - -
cardiagn.com
4 K542 12BR MAIN RELAY OUTPUT
5 B2 20DG/LB RIGHT REAR WHEEL SPEED SENSOR 12 VOLT SUP-
PLY
6 B1 20DG/OR RIGHT REAR WHEEL SPEED SENSOR SIGNAL
7 F202 20PK/GY IGNITION SWITCH OUTPUT (RUN-START)
8 B1 20DG/PK RIGHT REAR WHEEL SPEED SENSOR SIGNAL
9 - -
10 N1 18DB/OR (DIESEL) FUEL PUMP CONTROL OUTPUT
10 K107 18VT/WT (GAS EXCEPT EXPORT) ESM SIGNAL
11 B2 20DG/TN RIGHT REAR WHEEL SPEED SENSOR 12 VOLT SUP-
PLY
12 - -
13 R79 20LB/VT LEFT FRONT IMPACT SENSOR SIGNAL
14 R80 20VT/LB RIGHT FRONT IMPACT SENSOR SIGNAL
15 R81 20LB/WT LEFT FRONT IMPACT SENSOR GROUND
16 R82 20WT/BK RIGHT FRONT IMPACT SENSOR GROUND
17 - -
18 V71 20VT/OR S/C SIGNAL 1
19 V72 20OR/VT S/C SIGNAL 2
20 V937 20VT/BR S/C SWITCH GROUND
21 - -
22 F963 20PK/DB (CVT) START ENABLE
23 F962 20PK/BK (CVT) IGNITION SWITCH OUTPUT (START)
24 A414 20RD/LG FUSED B(+) (I.O.D.)
25 B215 20DG/OR BRAKE SIGNAL 2
26 L161 18WT/LG LEFT TURN SIGNAL (OUT)
27 F20 20PK/WT IGNITION SWITCH OUTPUT (RUN-START)
28 D465 20WT/DB DYNAMICS SENSOR HIGH DATA LINK
29 D464 20WT/YL DYNAMICS SENSOR LOW DATA LINK
30 D64 20WT/LB CAN C BUS (-)
31 D65 20WT/BK CAN C BUS (+)
32 - -
33 K132 20DB/LB (DIESEL) CABIN HEATER RELAY 1 CONTROL
33 K914 18BR/WT (GAS) SENSOR GROUND
34 K232 20BR/LB (DIESEL) CABIN HEATER RELAY 2 CONTROL
34 K75 18WT/OR (GAS) VEHICLE SPEED SIGNAL
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 15
cardiagn.com
16 R82 20WT/OR RIGHT FRONT IMPACT SENSOR GROUND
17 - -
18 V71 20VT/OR S/C SIGNAL 1
19 V72 20OR/VT S/C SIGNAL 2
20 V937 20VT/BR S/C SWITCH GROUND
21 - -
22 F963 20PK/DB START ENABLE
23 F962 20PK/BK IGNITION SWITCH OUTPUT (START)
24 A414 18RD/LB FUSED B(+) (I.O.D.)
25 B215 20DG/OR BRAKE SIGNAL 2
26 L161 20WT/LG LEFT TURN SIGNAL (OUT)
27 F20 20PK/WT IGNITION SWITCH OUTPUT (RUN-START)
28 D465 20WT/DB DYNAMICS SENSOR HIGH DATA LINK
29 D464 20WT/YL DYNAMICS SENSOR LOW DATA LINK
30 D64 20WT/LB CAN C BUS (-)
31 D65 20WT/BK CAN C BUS (+)
32 - -
33 K132 20DB/LB (DIESEL) CABIN HEATER RELAY 1 CONTROL
33 K914 20DB/PK (GAS) SENSOR GROUND
34 K232 20BR/LB (DIESEL) CABIN HEATER RELAY 2 CONTROL
34 K75 20DB/OR (GAS) VEHICLE SPEED SIGNAL
8W - 80 - 16 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
16 T141 20YL/RD CLUTCH INTERLOCK SIGNAL
17 T26 20DG/OR (DIESEL) CLUTCH UPSTOP SWITCH SIGNAL
18 G4 18VT/LB (ESP) DYNAMICS SENSOR SUPPLY
19 - -
20 G94 18VT/DB (ESP) DYNAMICS SENSOR GROUND
cardiagn.com
C106 (CVT) - BLACK (BODY SIDE) 6 WAY
CAV CIRCUIT FUNCTION
1 T13 18DG/VT SENSOR GROUND
2 T14 18DG/BK INPUT SPEED SENSOR SIGNAL
3 T16 18YL/OR TRANSMISSION CONTROL OUTPUT
4 - -
5 T52 18DG/WT OUTPUT SPEED SENSOR SIGNAL
6 T130 18TN/DG OUTPUT SPEED SENSOR GROUND
cardiagn.com
16 N4 20DB/WT FUEL LEVEL SIGNAL 1
17 G75 20VT/BK LEFT FRONT DOOR AJAR SWITCH SENSE
18 R9 18LB/YL DRIVER KNEE BLOCKER SQUIB LINE 2
19 R11 18LB/DB DRIVER KNEE BLOCKER SQUIB LINE 1
20 R43 18LG/BR DRIVER SQUIB 1 LINE 2
21 - -
22 D508 20WT/GY COM-LIN TIRE PRESSURE MONITOR LAN
23 G76 20VT/YL RIGHT REAR DOOR AJAR SWITCH SENSE
24 G77 20VT/GY LEFT REAR DOOR AJAR SWITCH SENSE
25 - -
26 - -
27 L53 20DG/GY STOP LAMP SWITCH OUTPUT
28 N5 20DB/BK FUEL LEVEL SIGNAL 2
29 - -
30 P697 20LG/DG DOOR LOCK SWITCH MUX
31 R42 18LB/BR PASSENGER SQUIB 1 LINE 2
32 - -
33 R44 18LB/OR PASSENGER SQUIB 1 LINE 1
34 R45 18LG/RD DRIVER SQUIB 1 LINE 1
35 R57 20LG/GY DRIVER SEAT BELT SWITCH SENSE
36 R58 20LB/GY PASSENGER SEAT BELT SWITCH SENSE
37 - -
38 - -
39 P238 18TN/DG DRIVER DOOR UNLOCK DRIVER
40 - -
41 D506 20WT/DG (HEATED SEATS) LIN BUS
42 F20 20PK/WT IGNITION SWITCH OUTPUT (RUN-START)
43 F985 18PK/YL FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 19
cardiagn.com
17 G75 20VT/BK LEFT FRONT DOOR AJAR SWITCH SENSE
18 R9 18LB/YL DRIVER KNEE BLOCKER SQUIB LINE 2
19 R11 18LB/DB DRIVER KNEE BLOCKER SQUIB LINE 1
20 R43 18LG/BR DRIVER SQUIB 1 LINE 2
21 - -
22 D508 20WT/GY COM-LIN TIRE PRESSURE MONITOR LAN
23 G76 20VT/YL RIGHT REAR DOOR AJAR SWITCH SENSE
24 G77 20VT/GY LEFT REAR DOOR AJAR SWITCH SENSE
25 - -
26 - -
27 L53 18DG/GY STOP LAMP SWITCH OUTPUT
28 N5 20DB/WT FUEL LEVEL SIGNAL 2
29 - -
30 P697 20LG/DG DOOR LOCK SWITCH MUX
31 R42 18LB/BR PASSENGER SQUIB 1 LINE 2
32 - -
33 R44 18LB/OR PASSENGER SQUIB 1 LINE 1
34 R45 18LG/RD DRIVER SQUIB 1 LINE 1
35 R57 20LG/GY DRIVER SEAT BELT SWITCH SENSE
36 - -
37 - -
38 - -
39 P238 18LG/OR DRIVER DOOR UNLOCK DRIVER
40 - -
41 D506 20WT/DG (HEATED SEATS) LIN BUS
42 F20 20PK/WT IGNITION SWITCH OUTPUT (RUN-START)
43 F985 18PK/YL FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
8W - 80 - 20 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
17 - -
18 A935 20RD FUSED B(+)
19 A999 16RD/PK FUSED B(+)
20 X298 20GY/LG RIGHT INSTRUMENT PANEL SPEAKER (-)
21 X201 18GY/VT (BASE) LEFT FRONT DOOR SPEAKER (+)
22 X291 18GY/YL (BASE) LEFT FRONT DOOR SPEAKER (-)
23 X202 18DG/VT (BASE) RIGHT FRONT DOOR SPEAKER (+)
24 X292 18DG/YL (BASE) RIGHT FRONT DOOR SPEAKER (-)
25 X51 18DG/DB LEFT REAR SPEAKER (+)
26 X52 18GY/DB RIGHT REAR SPEAKER (+)
27 X58 18GY/OR RIGHT REAR SPEAKER (-)
28 F961 20PK/LB IGNITION SWITCH OUTPUT (START)
29 R61 18LG/VT DRIVER SQUIB 2 LINE 2
30 R62 18LB/VT PASSENGER SQUIB 2 LINE 2
31 R63 18LG/BK DRIVER SQUIB 2 LINE 1
32 - -
33 D264 20DB/WT CAN C BUS (-)
34 D265 20DB CAN C BUS (+)
35 X57 18DG/BR LEFT REAR SPEAKER (-)
36 - -
37 - -
38 - -
39 - -
40 X208 20GY/DG RIGHT INSTRUMENT PANEL SPEAKER (+)
41 X209 20GY/TN LEFT INSTRUMENT PANEL SPEAKER (+)
42 X299 20GY/BR LEFT INSTRUMENT PANEL SPEAKER (-)
43 C7 14DB/PK BLOWER MOTOR CONTROL
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 21
cardiagn.com
18 A935 20RD FUSED B(+)
19 A999 16RD/WT FUSED B(+)
20 X298 18GY/LG RIGHT INSTRUMENT PANEL SPEAKER (-)
21 X201 18GY/VT (BASE) LEFT FRONT DOOR SPEAKER (+)
22 X291 18GY/YL (BASE) LEFT FRONT DOOR SPEAKER (-)
23 X202 18DG/VT (BASE) RIGHT FRONT DOOR SPEAKER (+)
24 X292 18DG/YL (BASE) RIGHT FRONT DOOR SPEAKER (-)
25 X51 18DG/DB LEFT REAR SPEAKER (+)
26 X52 18GY/DB RIGHT REAR SPEAKER (+)
27 X58 18GY/OR RIGHT REAR SPEAKER (-)
28 F961 20PK/LB IGNITION SWITCH OUTPUT (START)
29 R61 18LG/VT DRIVER SQUIB 2 LINE 2
30 R62 18LB/VT PASSENGER SQUIB 2 LINE 2
31 R63 18LG/BK DRIVER SQUIB 2 LINE 1
32 - -
33 D264 20DB/WT CAN C BUS (-)
34 D265 20DB/WT CAN C BUS (+)
35 X57 18DG/BR LEFT REAR SPEAKER (-)
36 - -
37 - -
38 - -
39 - -
40 X208 18GY/DG RIGHT INSTRUMENT PANEL SPEAKER (+)
41 X209 18GY/TN LEFT INSTRUMENT PANEL SPEAKER (+)
42 X299 18GY/BR LEFT INSTRUMENT PANEL SPEAKER (-)
43 C7 14DB/PK BLOWER MOTOR CONTROL
8W - 80 - 22 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
14 Q4 20OR/YL SUNROOF VENT SWITCH SENSE
15 Q5 20OR/LB SUNROOF CLOSE SWITCH SENSE
16 Q6 20OR/LG SUNROOF SWITCH SUPPLY
17 Q3 20OR/TN SUNROOF OPEN SWITCH SENSE
18 - -
19 F202 20PK/GY IGNITION SWITCH OUTPUT (RUN-START)
20 F985 18PK/YL FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
cardiagn.com
1 A927 20RD/GY (EXCEPT SUNROOF) FUSED B(+)
1 A927 16RD/GY (SUNROOF) FUSED B(+)
2 Q3 20OR/TN SUNROOF OPEN SWITCH SENSE
3 - -
4 - -
5 Q4 20OR/YL SUNROOF VENT SWITCH SENSE
6 F996 20PK/YL FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
7 Q5 20OR/LB SUNROOF CLOSE SWITCH SENSE
8 Q6 20OR/LG SUNROOF SWITCH SUPPLY
9 Z937 16BK/YL GROUND
10 - -
11 - -
12 - -
cardiagn.com
3 T312 20YL/VT REAR DIFFERENTIAL SOLENOID CONTROL
4 T78 20YL/BK SOLENOID SUPPLY VOLTAGE
cardiagn.com
12 A417 20RD/DG (POWER LOCKS FUSED B(+) (I.O.D.)
EXCEPT HEATED MIRRORS)
13 C16 20DB/GY FUSED REAR WINDOW DEFOGGER CONTROL OUT-
PUT
14 - -
15 - -
16 - -
cardiagn.com
15 P235 20LG/TN SECONDARY LOCK DRIVER
16 P237 20DG/TN SECONDARY UNLOCK DRIVER
cardiagn.com
C302 (RHD) - BLACK (BODY SIDE) 14 WAY
CAV CIRCUIT FUNCTION
1 Z960 20BK/LB GROUND
2 - -
3 - -
4 Q16 14OR/TN MASTER WINDOW SWITCH PASSENGER (UP)
5 Q26 14OR/GY MASTER WINDOW SWITCH PASSENGER (DOWN)
6 Q15 14OR/LB WINDOW LOCK OUT SWITCH OUTPUT
7 - -
8 - -
9 - -
10 - -
11 - -
12 - -
13 - -
14 - -
cardiagn.com
C303 - BLACK (BODY SIDE) 14 WAY
CAV CIRCUIT FUNCTION
1 G74 20VT/WT RIGHT FRONT DOOR AJAR SWITCH SENSE
2 P33 20LG/TN (LHD) DOOR LOCK DRIVER
2 Z960 20BK/LB (RHD) GROUND
3 P240 20LG/YL (LHD) PASSENGER DOOR UNLOCK DRIVER
3 Z961 20BK/YL (RHD) GROUND
4 Q16 14OR/TN MASTER WINDOW SWITCH PASSENGER (UP)
5 Q26 14OR/GY MASTER WINDOW SWITCH PASSENGER (DOWN)
6 Q15 14OR/LB WINDOW LOCK OUT SWITCH OUTPUT
7 P76 20TN/LB (LHD) MIRROR COMMON DRIVER
8 P72 20TN/GY (LHD) RIGHT MIRROR VERTICAL DRIVER
8 P110 20TN/RD (RHD) FOLDING MIRROR RETURN
9 P74 20TN/OR (LHD) RIGHT MIRROR HORIZONTAL DRIVER
9 P699 20TN/LG (RHD) MIRROR-POWER FOLDING/UNFOLDING
10 Z960 20BK/LB (LHD) GROUND
10 Q411 14OR/WT (RHD) LEFT REAR WINDOW DRIVER (UP)
11 C16 20DB/GY (LHD) FUSED REAR WINDOW DEFOGGER CONTROL OUT-
PUT
11 Q412 14OR/LG (RHD) RIGHT REAR WINDOW DRIVER (UP)
12 X202 18DG/VT (LHD BASE AUDIO) RIGHT FRONT DOOR SPEAKER (+)
12 X154 18GY/YL (LHD PREMIUM AMPLIFIED RIGHT FRONT DOOR SPEAKER (-)
AUDIO)
12 Q611 14OR/RD (RHD) LEFT REAR WINDOW DRIVER (DOWN)
13 X292 18DG/YL (LHD BASE AUDIO) RIGHT FRONT DOOR SPEAKER (-)
13 X156 18GY/LB (LHD PREMIUM AMPLIFIED RIGHT FRONT DOOR SPEAKER (+)
AUDIO)
13 Q612 14OR/DB (RHD) RIGHT REAR WINDOW DRIVER (DOWN)
14 F981 14PK/BR (RHD) IGNITION SWITCH OUTPUT (RUN-ACC)
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 29
cardiagn.com
12 Q611 14OR/GY (RHD) LEFT REAR WINDOW DRIVER (DOWN)
13 X292 18DG/YL (LHD) RIGHT FRONT DOOR SPEAKER (-)
13 Q612 14OR/DB (RHD) RIGHT REAR WINDOW DRIVER (DOWN)
14 F981 14PK/YL (RHD) IGNITION SWITCH OUTPUT (RUN-ACC)
cardiagn.com
C305 - LT. GRAY (DRIVER SEAT SIDE) 8 WAY
CAV CIRCUIT FUNCTION
1 R261 20LB/WT DRIVER SEAT POSITION SENSOR DATA
2 R263 20LB/VT DRIVER SEAT POSITION SENSOR VOLTAGE
3 Z960 18BK (HEATED SEATS) GROUND
4 - -
5 D506 20WT/DG (HEATED SEATS) LIN BUS
6 F937 14PK/YL (HEATED SEATS) FUSED IGNITION SWITCH OUTPUT (RUN)
7 P188 16LG/VT (LHD HEATED SEATS) RIGHT SEAT HEATER B(+) DRIVER
7 P187 16LG/VT (RHD HEATED SEATS) LEFT SEAT HEATER B(+) DRIVER
8 - -
cardiagn.com
16 C16 20DB/GY FUSED REAR WINDOW DEFOGGER CONTROL OUT-
PUT
cardiagn.com
C308 - LT. GRAY (LEFT REAR DOOR SIDE) 14 WAY
CAV CIRCUIT FUNCTION
1 Q411 14OR/WT LEFT REAR WINDOW DRIVER (UP)
2 P33 20TN/DB DOOR LOCK DRIVER
3 P240 20LG/YL (LHD) PASSENGER DOOR UNLOCK DRIVER
3 P240 20TN/WT (RHD) PASSENGER DOOR UNLOCK DRIVER
4 G77 20VT/GY LEFT REAR DOOR AJAR SWITCH SENSE
5 X303 18DG/TN (BASE) LEFT REAR SPEAKER (+)
5 X205 18GY/LG (PREMIUM) AMPLIFIED LEFT REAR SPEAKER (+)
6 X393 18DG/TN (BASE) LEFT REAR SPEAKER (-)
6 X295 18GY/DG (PREMIUM) AMPLIFIED LEFT REAR SPEAKER (-)
7 Q15 14OR/LB WINDOW LOCK OUT SWITCH OUTPUT
8 Q611 14OR/GY LEFT REAR WINDOW DRIVER (DOWN)
9 Z929 20BK (EXCEPT LHD/POWER GROUND
LOCKS)
9 Z928 20BK/LG (LHD/POWER LOCKS) GROUND
10 - -
11 - -
12 - -
13 P235 20LG/TN (RHD) SECONDARY LOCK DRIVER
14 P237 20DG/TN (RHD) SECONDARY UNLOCK DRIVER
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 33
cardiagn.com
14 P237 20DG/TN SECONDARY UNLOCK DRIVER
cardiagn.com
2 W13 18BR/LG REAR WIPER MOTOR CONTROL
3 P240 18LG/YL PASSENGER DOOR UNLOCK DRIVER
4 F996 16PK/YL FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
5 P33 18LG/TN DOOR LOCK DRIVER
6 G78 20VT/OR LIFTGATE AJAR SWITCH SENSE
7 - -
8 L217 20WT/VT PARK LAMP CONTROL OUTPUT
cardiagn.com
C313 - LT. GRAY (SDARS JUMPER SIDE) 4 WAY
CAV CIRCUIT FUNCTION
1 A417 18RD FUSED B(+) (I.O.D.)
2 Z965 18BK GROUND
3 D54 20WT CAN B BUS (-)
4 D55 20WT/OR CAN B BUS (+)
cardiagn.com
6 P235 18LG/TN (RHD) SECONDARY LOCK DRIVER
7 P240 18TN/WT PASSENGER DOOR UNLOCK DRIVER
8 Z936 18BK/LB GROUND
9 P33 18TN/DB (LHD) DOOR LOCK DRIVER
9 P33 18LG/TN (RHD) DOOR LOCK DRIVER
10 A932 16RD/BR DOOR LOCK POWER-FUSED B(+)
cardiagn.com
18 - -
19 - -
20 - -
cardiagn.com
COIL-IGNITION 3 (GAS) - DK. GRAY 3 WAY
CAV CIRCUIT FUNCTION
1 - -
2 K18 18DB/OR COIL 3 CONTROL
3 K344 18BR/GY FUSED MAIN RELAY OUTPUT
cardiagn.com
8 - -
9 - -
10 - -
11 - -
12 - -
13 - -
14 D71 20WT/DB DIAGNOSTIC CAN C (-)
15 - -
16 A933 20RD FUSED B(+)
cardiagn.com
GENERATOR-EYELET - 1 WAY
CAV CIRCUIT FUNCTION
1 A801 6RD/GY B(+)
cardiagn.com
GLOW PLUG 4 (DIESEL) - BLACK 1 WAY
CAV CIRCUIT FUNCTION
1 A208 16BK/GY GLOW PLUG 4 CONTROL
cardiagn.com
HEATER-SEAT BACK-LEFT - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 P187 18BK LEFT SEAT HEATER B(+) DRIVER
2 Z960 18BK GROUND
cardiagn.com
HEATER-SEAT CUSHION-RIGHT (COMPONENT SIDE) - GREEN 2 WAY
CAV CIRCUIT FUNCTION
1 P188 18BK RIGHT SEAT HEATER B(+) DRIVER
2 Z940 18BK GROUND
cardiagn.com
INJECTOR-FUEL 1 (GAS) - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 K11 20BR/YL INJECTOR 1 CONTROL
2 K343 16BR/YL FUSED MAIN RELAY OUTPUT
cardiagn.com
INJECTOR-FUEL 3 (DIESEL) - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 K663 16BR/YL FUEL INJECTOR HIGH-SIDE COMMON
2 K613 16BR/WT FUEL INJECTOR 3 LOW-SIDE CONTROL
cardiagn.com
LAMP-BACKUP-RIGHT - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 Z964 20BK/WT GROUND
2 L1 20WT/LG BACKUP LAMP SWITCH OUTPUT
cardiagn.com
LAMP-DOME (RECHARGABLE) - 3 WAY
CAV CIRCUIT FUNCTION
1 F985 18PK/YL FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
2 M24 20YL/WT COURTESY LAMPS DRIVER
3 Z936 20BK/LB GROUND
cardiagn.com
LAMP-HIGH MOUNTED STOP - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 L53 18DG/WT STOP LAMP SWITCH OUTPUT
2 Z960 20BK GROUND
cardiagn.com
LAMP-SIDE REPEATER-LEFT (EXPORT) - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 L161 18WT/LG LEFT TURN SIGNAL (OUT)
2 Z960 20BK/LB GROUND
cardiagn.com
LAMP-TAIL/STOP-LEFT (EXCEPT EXPORT) - BLACK 3 WAY
CAV CIRCUIT FUNCTION
1 L55 18WT/OR STOP LAMP CONTROL OUTPUT
2 L217 20WT/VT PARK LAMP CONTROL OUTPUT
3 Z960 20BK/LB GROUND
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 51
cardiagn.com
CAV CIRCUIT FUNCTION
1 Z960 20BK/LB GROUND
2 L55 18WT/OR STOP LAMP CONTROL OUTPUT
3 L217 18WT/VT PARK LAMP CONTROL OUTPUT
4 L239 18WT/DG REAR FOG LAMP CONTROL OUTPUT
cardiagn.com
LATCH-DOOR-DRIVER (EXCEPT LHD BASE) - BLACK 4 WAY
CAV CIRCUIT FUNCTION
1 P238 20LG/OR DRIVER DOOR UNLOCK DRIVER
2 P33 20LG/TN DOOR LOCK DRIVER
3 G75 20VT/BK (EXCEPT HEATED MIR- LEFT FRONT DOOR AJAR SWITCH SENSE
RORS)
3 G75 20VT (HEATED MIRRORS) LEFT FRONT DOOR AJAR SWITCH SENSE
4 Z928 20BK/LG (EXCEPT HEATED MIR- GROUND
RORS)
4 Z928 20BK (HEATED MIRRORS) GROUND
cardiagn.com
LATCH-DOOR-LEFT REAR (RHD) - 8 WAY
CAV CIRCUIT FUNCTION
1 - -
2 - -
3 P237 20DG/TN SECONDARY UNLOCK DRIVER
4 P235 20LG/TN SECONDARY LOCK DRIVER
5 P240 20TN/WT PASSENGER DOOR UNLOCK DRIVER
6 P33 20TN/DB DOOR LOCK DRIVER
7 G77 20VT/GY LEFT REAR DOOR AJAR SWITCH SENSE
8 Z929 20BK GROUND
cardiagn.com
CAV CIRCUIT FUNCTION
1 P240 20TN/WT (EXCEPT HEATED MIR- PASSENGER DOOR UNLOCK DRIVER
RORS)
1 P240 18LG/YL (HEATED MIRRORS) PASSENGER DOOR UNLOCK DRIVER
2 P33 18TN/DB (EXCEPT HEATED MIR- DOOR LOCK DRIVER
RORS)
2 P33 18LG/TN (HEATED MIRRORS) DOOR LOCK DRIVER
3 G74 20VT/WT (LHD) RIGHT FRONT DOOR AJAR SWITCH SENSE
3 G75 20VT/WT (RHD) LEFT FRONT DOOR AJAR SWITCH SENSE
4 Z960 20BK/LB (EXCEPT HEATED MIR- GROUND
RORS)
4 Z928 20BK (HEATED MIRRORS) GROUND
cardiagn.com
5 P240 20TN/WT PASSENGER DOOR UNLOCK DRIVER
6 P33 20TN/DB DOOR LOCK DRIVER
7 G76 20VT/YL RIGHT REAR DOOR AJAR SWITCH SENSE
8 Z928 20BK/LG GROUND
cardiagn.com
6 X712 20DG/LB MICROPHONE 1 IN(+)
7 X793 20DG/YL MICROPHONE FEED
8 - -
9 X730 20GY/YL VOICE RECOGNITION/PHONE SWITCH SIGNAL
10 - -
11 X835 20BK/DB SENSOR GROUND
12 X792 20BK/VT MICROPHONE IN(-)
cardiagn.com
MODULE-ALL WHEEL DRIVE CONTROL (AWD) - 16 WAY
CAV CIRCUIT FUNCTION
1 - -
2 - -
3 - -
4 D65 20WT/BK CAN C BUS (+)
5 F202 20PK/GY IGNITION SWITCH OUTPUT (RUN-START)
6 A923 20RD FUSED B(+)
7 - -
8 T312 20YL/VT REAR DIFFERENTIAL SOLENOID CONTROL
9 - -
10 - -
11 - -
12 D64 20WT/LB CAN C BUS (-)
13 - -
14 - -
15 Z967 20BK GROUND
16 T78 20YL/BK SOLENOID SUPPLY VOLTAGE
8W - 80 - 58 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
17 - -
18 D465 20WT/DB (ESP) DYNAMICS SENSOR HIGH DATA LINK
19 D464 20WT/YL (ESP) DYNAMICS SENSOR LOW DATA LINK
20 - -
21 - -
22 G4 18VT/LB (ESP) DYNAMICS SENSOR SUPPLY
23 - -
24 - -
25 - -
26 - -
27 - -
28 - -
29 G94 18VT/DB (ESP) DYNAMICS SENSOR GROUND
30 - -
31 - -
32 A922 12RD/DB (ESP) FUSED B(+) (VALVE)
32 A922 14RD/BK (TCS) FUSED B(+) (VALVE)
33 B6 20WT/DB RIGHT FRONT WHEEL SPEED SENSOR SIGNAL
34 B7 20WT RIGHT FRONT WHEEL SPEED SENSOR 12 VOLT
SUPPLY
35 - -
36 B4 20LG LEFT REAR WHEEL SPEED SENSOR 12 VOLT SUP-
PLY
37 B3 20LG/DB LEFT REAR WHEEL SPEED SENSOR SIGNAL
38 - -
39 - -
40 - -
41 - -
42 B1 20YL/DB RIGHT REAR WHEEL SPEED SENSOR SIGNAL
43 B2 20YL RIGHT REAR WHEEL SPEED SENSOR 12 VOLT SUP-
PLY
44 - -
45 B9 20DG/LG LEFT FRONT WHEEL SPEED SENSOR 12 VOLT SUP-
PLY
46 B8 20DG/TN LEFT FRONT WHEEL SPEED SENSOR SIGNAL
47 Z902 12BK/WT GROUND
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 59
cardiagn.com
MODULE-ELECTRONIC OVERHEAD C2 - BLACK 4 WAY
CAV CIRCUIT FUNCTION
A Q4 20OR/YL SUNROOF VENT SWITCH SENSE
B Q6 20OR/LG SUNROOF SWITCH SUPPLY
C Q3 20OR/TN SUNROOF OPEN SWITCH SENSE
D Q5 20OR/LB SUNROOF CLOSE SWITCH SENSE
8W - 80 - 60 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
18 F202 20PK/GY IGNITION SWITCH OUTPUT (RUN-START)
19 T26 20DG/OR CLUTCH UPSTOP SWITCH SIGNAL
20 - -
21 - -
22 - -
23 - -
24 - -
25 - -
26 G329 20VT/OR CHARGE INDICATOR SIGNAL
27 G329 20VT/OR CHARGE INDICATOR SIGNAL
28 - -
29 V72 20OR/VT S/C SIGNAL 2
30 K202 20DB/BR GLOW PLUG RELAY CONTROL
31 - -
32 - -
33 - -
34 - -
35 - -
36 - -
37 - -
38 K48 20DB/WT IAT SENSOR SIGNAL
39 K167 20BR/YL APP SENSOR GROUND 1
40 F855 20PK/YL 5 VOLT SUPPLY
41 - -
42 - -
43 - -
44 - -
45 - -
46 V937 20VT/BR S/C SWITCH GROUND
47 - -
48 - -
49 K51 20BR/LG MAIN RELAY CONTROL
50 - -
51 - -
52 K31 20DB/BK FUEL PUMP CONTROL
53 - -
54 - -
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 61
cardiagn.com
73 - -
74 - -
75 - -
76 K656 20GY/BR SENSOR GROUND
77 - -
78 K37 20BR/OR BOOST PRESSURE SENSOR SIGNAL
79 - -
80 - -
81 T141 20YL/RD CLUTCH INTERLOCK SIGNAL
82 K157 20BR/OR MAF SENSOR SIGNAL
83 K23 20BR/OR APP SIGNAL 1
84 K852 20BR/VT 5 VOLT SUPPLY
85 - -
86 F961 20PK/LB IGNITION SWITCH OUTPUT (START)
87 B15 20DG/WT BRAKE SIGNAL 1
88 - -
89 D65 20WT/BK CAN C BUS (+)
90 - -
91 - -
92 T752 20DG/OR STARTER CONTROL
93 - -
94 - -
8W - 80 - 62 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
20 - -
21 - -
22 V71 20VT/OR S/C SIGNAL 1
23 - -
24 - -
25 K604 20BR/WT EGR AIR FLOW CONTROL VALVE SIGNAL
26 - -
27 K844 20DB/YL CMP SENSOR 5 VOLT SUPPLY
28 K44 20DB/GY CMP 1/1 SIGNAL
29 K137 20DB/OR BOOST PRESSURE CONTROL
30 - -
31 K663 20BR/GY FUEL INJECTOR HIGH-SIDE COMMON
32 K663 20BR/GY FUEL INJECTOR HIGH-SIDE COMMON
33 - -
34 - -
35 - -
36 - -
37 - -
38 - -
39 K156 20BR/YL FUEL TEMPERATURE SENSOR SIGNAL
40 K900 20DB/DG SENSOR GROUND
41 - -
42 K853 20DB/BR CKP SENSOR 5 VOLT SUPPLY
43 - -
44 - -
45 C27 20LB/WT A/C COMPRESSOR CONTROL
46 K611 14OR/BR FUEL INJECTOR 1 LOW-SIDE CONTROL
47 K614 14WT/BR FUEL INJECTOR 4 LOW-SIDE CONTROL
48 K612 14YL/BR FUEL INJECTOR 2 LOW-SIDE CONTROL
49 - -
50 - -
51 - -
52 K2 20VT/OR ECT 1 SIGNAL
53 K915 20BR/WT SENSOR GROUND
54 - -
55 - -
56 - -
57 K925 20DB/GY CKP SENSOR GROUND
58 K24 20BR/LB CKP SENSOR SIGNAL
59 - -
60 K601 20BR/VT EGR AIR FLOW CONTROL VALVE CONTROL
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 63
cardiagn.com
5 N1 20DB/OR FUEL PUMP CONTROL OUTPUT
cardiagn.com
16 X712 20DG/LB MICROPHONE 1 IN(+)
17 X792 20LB/TN MICROPHONE IN(-)
18 - -
19 - -
20 X793 20DG/YL MICROPHONE FEED
21 X835 20OR/BK SENSOR GROUND
22 Z937 18BK/YL (OPTION 1) GROUND
22 Z937 20BK/YL (OPTION 2) GROUND
cardiagn.com
1 A415 20RD/TN FUSED B(+) (I.O.D.)
2 - -
3 D55 20WT/OR CAN B BUS (+)
4 D54 20WT/PK CAN B BUS (-)
5 D96 20WT/LB SIREN SIGNAL CONTROL
6 Z936 20BK/LB (OPTION 1) GROUND
6 Z941 20BK/YL (OPTION 2) GROUND
cardiagn.com
5 D54 20WT CAN B BUS (-)
6 - -
7 R263 20LB/VT DRIVER SEAT POSITION SENSOR VOLTAGE
8 - -
9 R261 20LB/WT DRIVER SEAT POSITION SENSOR DATA
10 Z944 20BK GROUND
cardiagn.com
18 R45 18LG/RD DRIVER SQUIB 1 LINE 1
19 R44 18LB/OR PASSENGER SQUIB 1 LINE 1
20 R42 18LB/BR PASSENGER SQUIB 1 LINE 2
21 R61 18LG/VT DRIVER SQUIB 2 LINE 2
22 R63 18LG/BK DRIVER SQUIB 2 LINE 1
23 R64 18LB/WT PASSENGER SQUIB 2 LINE 1
24 R62 18LB/VT PASSENGER SQUIB 2 LINE 2
8W - 80 - 68 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
17 F200 18PK/LB (EXCEPT BASE) FUSED IGNITION SWITCH OUTPUT (RUN-START)
18 F100 20DG/YL FUSED IGNITION SWITCH OUTPUT (RUN)
19 - -
20 Z944 18BK/LG GROUND
21 R272 20LB/VT (EXCEPT EXPORT) PASSENGER HALL EFFECT (-)
22 - -
23 - -
24 R274 20LB/WT (EXCEPT EXPORT) PASSENGER HALL EFFECT (+)
25 - -
26 - -
27 R14 20TN/LG (SIDE AIR BAG) RIGHT SIDE IMPACT SENSOR 1 SIGNAL
28 R16 20BR/LG (SIDE AIR BAG) RIGHT SIDE IMPACT SENSOR 1 GROUND
29 R15 20LG/BR (SIDE AIR BAG) LEFT SIDE IMPACT SENSOR 1 GROUND
30 R13 20LG/TN (SIDE AIR BAG) LEFT SIDE IMPACT SENSOR 1 SIGNAL
31 - -
32 - -
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 69
cardiagn.com
19 K31 20BR FUEL PUMP CONTROL
20 K904 20DB/DG O2 1/2 RETURN
21 K141 20DB/YL O2 1/2 SIGNAL
22 K858 20BR/GY 5 VOLT SUPPLY
23 F856 20YL/PK 5 VOLT SUPPLY
24 - -
25 T752 20DG/OR STARTER CONTROL
26 V72 20OR/VT S/C SIGNAL 2
27 V71 20VT/OR S/C SIGNAL 1
28 - -
29 - -
30 K914 20DB/PK SENSOR GROUND
31 - -
32 B15 20DG/WT BRAKE SIGNAL 1
33 - -
34 K400 20BR/VT APP SENSOR GROUND 2
35 K70 20DB/BR EVAP PURGE RETURN
36 K167 20BR/YL APP SENSOR GROUND 1
37 F963 20PK/DB START ENABLE
38 K75 20DB/OR VEHICLE SPEED SIGNAL
39 K52 20DB/WT EVAP PURGE CONTROL
40 - -
41 D65 20WT/BK CAN C BUS (+)
42 - -
43 - -
44 - -
45 - -
46 - -
47 K107 20VT/WT ESM SIGNAL
48 K29 20WT/BR APP SIGNAL 2
49 K23 20BR/OR APP SIGNAL 1
50 T141 20YL/RD CLUTCH INTERLOCK SIGNAL
51 - -
52 B215 20DG/OR BRAKE SIGNAL 2
53 A804 16RD/GY GEN SENSE
54 D64 20WT/LB CAN C BUS (-)
55 - -
56 - -
57 - -
58 K51 20BR/LG MAIN RELAY CONTROL
8W - 80 - 70 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
18 - -
19 - -
20 - -
21 K13 20BR/LB INJECTOR 3 CONTROL
22 K14 20BR/TN INJECTOR 4 CONTROL
23 K11 20BR/YL INJECTOR 1 CONTROL
24 K12 20BR/DB INJECTOR 2 CONTROL
25 K126 20DB/LG ETC MOTOR (-)
26 - -
27 K601 20BR/VT MFV CONTROL
28 - -
29 - -
30 - -
31 - -
32 - -
33 K41 20BK/DG O2 1/1 SIGNAL
34 - -
35 - -
36 K902 20BR/DG O2 1/1 RETURN
37 G24 20VT/BR EOT SIGNAL
38 K441 20DB/BR CMP 1/2 SIGNAL
39 - -
40 - -
41 F855 20PK/YL 5 VOLT SUPPLY
42 K857 20BR/LG 5 VOLT SUPPLY
43 - -
44 - -
45 - -
46 - -
47 - -
48 - -
49 K99 20BR/OR O2 1/1 HEATER CONTROL
50 - -
51 K20 20BR/GY GEN FIELD CONTROL
52 - -
53 - -
54 - -
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 71
cardiagn.com
73 K15 20DB/GY COIL 4 CONTROL
74 K18 20DB/OR COIL 3 CONTROL
75 K17 20DB/TN COIL 2 CONTROL
76 K19 20DB/DG COIL 1 CONTROL
77 - -
78 - -
79 K24 20BR/LB CKP SIGNAL
80 - -
81 - -
82 K900 20DB/DG SENSOR GROUND
83 K2 20VT/OR ECT 1 SIGNAL
84 K602 20YL/DB MFV SIGNAL
85 K1 20VT/BR MAP SIGNAL
86 G6 20VT/GY EOP SIGNAL
87 - -
88 K42 20DB/LG KS SIGNAL
89 - -
90 - -
91 - -
92 - -
93 - -
94 - -
95 - -
96 - -
8W - 80 - 72 8W-80 CONNECTOR PIN-OUTS PM
cardiagn.com
4 F202 20PK/GY IGNITION SWITCH OUTPUT (RUN-START)
cardiagn.com
5 - -
6 K232 20BR/LB (DIESEL) CABIN HEATER RELAY 2 CONTROL
7 K132 20DB/LB (DIESEL) CABIN HEATER RELAY 1 CONTROL
8 - -
9 - -
10 - -
11 - -
12 B20 20DG/RD BRAKE FLUID LEVEL SWITCH SENSE
13 Z924 20BK/LB GROUND
cardiagn.com
17 A921 12RD/YL (ESP) FUSED B(+) (PUMP)
17 A921 12RD/DB (TCS) FUSED B(+) (PUMP)
18 - -
19 A931 20RD/WT (GAS) FUSED B(+)
20 - -
21 Z971 16BK GROUND
22 N112 20DB/OR RAD FAN RELAY CONTROL
cardiagn.com
PLY
cardiagn.com
CAV CIRCUIT FUNCTION
1 - -
2 A923 20RD (AWD) FUSED B(+)
3 A924 20DG/WT FUSED B(+)
4 A952 20RD/OR FUSED B(+)
5 F200 20PK/LB (BASE) FUSED IGNITION SWITCH OUTPUT (RUN-START)
5 F200 18PK/LB (EXCEPT BASE) FUSED IGNITION SWITCH OUTPUT (RUN-START)
6 - -
7 F100 20DG/YL FUSED IGNITION SWITCH OUTPUT (RUN)
8 - -
9 A933 20RD FUSED B(+)
10 - -
11 N1 20DB/OR FUEL PUMP CONTROL OUTPUT
12 - -
13 A417 20RD/DG FUSED B(+) (I.O.D.)
14 - -
15 A418 20RD/BK FUSED B(+) (I.O.D.)
16 A412 20RD/DB FUSED B(+) (I.O.D.)
17 A16 12RD/BR FUSED B(+)
18 A932 16RD/BR DOOR LOCK POWER-FUSED B(+)
19 F996 14PK/YL FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
20 - -
21 F981 14PK/BR (EXCEPT BASE) IGNITION SWITCH OUTPUT (RUN-ACC)
22 A999 16RD/WT (EXCEPT EXPORT) FUSED B(+)
PM 8W-80 CONNECTOR PIN-OUTS 8W - 80 - 77
cardiagn.com
15 - -
16 - -
17 C515 12LB/OR REAR WINDOW DEFOGGER CONTROL OUTPUT
18 A413 18RD/LB FUSED B(+) (I.O.D.)
19 T16 18YL/OR (CVT) TRANSMISSION CONTROL OUTPUT
20 F985 18PK/YL FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
21 F986 16PK/BK FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
22 K542 12BR MAIN RELAY OUTPUT
cardiagn.com
18 T41 20YL/BK TRS T41 SENSE
19 T16 18YL/OR TRANSMISSION CONTROL OUTPUT
20 T316 18YL/WT STEP MOTOR CONTROL C
21 T317 18TN/YL STEP MOTOR CONTROL D
22 T42 20DG/PK TRS T42 SENSE
23 - -
24 - -
cardiagn.com
9 - -
10 Q5 20OR/LB SUNROOF CLOSE SWITCH SENSE
cardiagn.com
MOTOR-WIPER-FRONT - LT. GRAY 5 WAY
CAV CIRCUIT FUNCTION
1 W3 16BR/WT (LHD) FRONT WIPER LOW SPEED CONTROL OUTPUT
1 W7 20BR/DB (RHD) FRONT WIPER PARK SWITCH SENSE
2 - -
3 W7 20BR/DB (LHD) FRONT WIPER PARK SWITCH SENSE
3 W4 16BR/LB (RHD) FRONT WIPER HIGH SPEED CONTROL OUTPUT
4 W4 16BR/LB (LHD) FRONT WIPER HIGH SPEED CONTROL OUTPUT
4 Z971 16BK (RHD) GROUND
5 Z971 16BK (LHD) GROUND
5 W3 16BR/WT (RHD) FRONT WIPER LOW SPEED CONTROL OUTPUT
cardiagn.com
3 Z940 16BK/LG GROUND
cardiagn.com
18 X51 18DG/DB LEFT REAR SPEAKER (+)
19 X57 18DG/BR LEFT REAR SPEAKER (-)
20 X58 18GY/OR RIGHT REAR SPEAKER (-)
21 X52 18GY/DB RIGHT REAR SPEAKER (+)
22 Z937 16BK/YL GROUND
cardiagn.com
1 D106 6WT/LG SATELLITE ANTENNA SIGNAL
2 D126 WT/TN SATELLITE ANTENNA SHIELD
cardiagn.com
SEAT BELT-TENSIONER-PASSENGER - YELLOW/BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 R54 18LB/YL PASSENGER SEAT BELT TENSIONER LINE 2
2 R56 18LB/DG PASSENGER SEAT BELT TENSIONER LINE 1
cardiagn.com
SENSOR-CAMSHAFT 1/1 POSITION (GAS) - BLACK 3 WAY
CAV CIRCUIT FUNCTION
1 K857 20BR/LG 5 VOLT SUPPLY
2 K900 20DB/DG SENSOR GROUND
3 K44 20DB/GY CMP 1/1 SIGNAL
cardiagn.com
SENSOR-CRANKSHAFT POSITION (GAS) - 3 WAY
CAV CIRCUIT FUNCTION
1 F855 20PK/YL 5 VOLT SUPPLY
2 K900 20DB/DG SENSOR GROUND
3 K24 20BR/LB CKP SIGNAL
cardiagn.com
SENSOR-ENGINE COOLANT TEMPERATURE 2 (GAS) - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 K915 20BR/WT SENSOR GROUND
2 K222 20BR/YL ECT 2 SIGNAL
cardiagn.com
SENSOR-FUEL TEMPERATURE (DIESEL) - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 K900 20DB/DG SENSOR GROUND
2 K156 20BR/YL FUEL TEMPERATURE SENSOR SIGNAL
cardiagn.com
SENSOR-MAP (GAS) - BLACK 3 WAY
CAV CIRCUIT FUNCTION
1 K1 20VT/BR MAP SIGNAL
2 K900 20DB/DG SENSOR GROUND
3 K857 20BR/LG 5 VOLT SUPPLY
cardiagn.com
SENSOR-OXYGEN 1/1 (GAS) - GRAY 4 WAY
CAV CIRCUIT FUNCTION
1 Z916 18BK GROUND
2 K99 20BR/OR O2 1/1 HEATER CONTROL
3 K902 20BR/DG O2 1/1 RETURN
4 K41 20BK/DG O2 1/1 SIGNAL
cardiagn.com
SENSOR-SEAT WEIGHT-LEFT FRONT - BLACK 3 WAY
CAV CIRCUIT FUNCTION
1 R728 20LB/YL SEAT WEIGHT SENSOR GROUND
2 R717 20LG/DG SEAT WEIGHT LEFT FRONT SENSOR SIGNAL
3 R701 20LG SEAT WEIGHT SENSOR 5 VOLT
cardiagn.com
2 R706 20LB/OR SEAT WEIGHT RIGHT REAR SENSOR SIGNAL
3 R701 20LG SEAT WEIGHT SENSOR 5 VOLT
cardiagn.com
SENSOR-STEERING ANGLE - WHITE 4 WAY
CAV CIRCUIT FUNCTION
1 D265 20DB CAN C BUS (+)
2 D264 20DB/WT CAN C BUS (-)
3 Z937 20BK/YL GROUND
4 F202 20PK/GY IGNITION SWITCH OUTPUT (RUN-START)
cardiagn.com
SENSOR-WHEEL SPEED-ABS-LEFT REAR - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 B4 20LG LEFT REAR WHEEL SPEED SENSOR 12 VOLT SUP-
PLY
2 B3 20LG/DB LEFT REAR WHEEL SPEED SENSOR SIGNAL
cardiagn.com
SOLENOID-A/C COMPRESSOR - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 K343 20BR/YL (DIESEL) FUSED MAIN RELAY OUTPUT
1 C27 20LB/WT (GAS) A/C COMPRESSOR CONTROL
2 C27 20LB/WT (DIESEL) A/C COMPRESSOR CONTROL
2 Z916 20BK (GAS) GROUND
cardiagn.com
SOLENOID-EVAP PURGE (GAS) - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 K52 20DB/WT EVAP PURGE CONTROL
2 K70 20DB/BR EVAP PURGE RETURN
cardiagn.com
SPEAKER-LIFTGATE (EXCEPT BASE) - LT. GRAY 4 WAY
CAV CIRCUIT FUNCTION
1 X214 18DG/DB AMPLIFIED LIFTGATE SPEAKER 1 (+)
2 X284 18DG/TN AMPLIFIED LIFTGATE SPEAKER 1 (-)
3 X212 18GY/DB AMPLIFIED LIFTGATE SPEAKER 2 (+)
4 X282 18GY/TN AMPLIFIED LIFTGATE SPEAKER 2 (-)
cardiagn.com
6 - -
7 X205 18GY/LG AMPLIFIED LEFT REAR SPEAKER (+)
8 X295 18GY/BK AMPLIFIED LEFT REAR SPEAKER (-)
9 X206 18DG/LG AMPLIFIED RIGHT REAR SPEAKER (+)
10 X296 18DG/LB AMPLIFIED RIGHT REAR SPEAKER (-)
cardiagn.com
SWITCH-BACKUP LAMP (GAS MTX) - GRAY 2 WAY
CAV CIRCUIT FUNCTION
A Z967 18BK/VT GROUND
B T22 18YL/VT BACKUP LAMP SWITCH SIGNAL
cardiagn.com
SWITCH-EVAP SYSTEM MONITOR (EXCEPT EXPORT) - BLACK 2 WAY
CAV CIRCUIT FUNCTION
1 Z965 20BK (AWD) GROUND
1 Z965 20BK/GY (FWD) GROUND
2 K106 18VT/LB (AWD) ESM SIGNAL
2 K107 18VT/WT (FWD) ESM SIGNAL
cardiagn.com
6 P72 20TN/GY RIGHT MIRROR VERTICAL DRIVER
7 P71 20TN/DG LEFT MIRROR VERTICAL DRIVER
8 P74 20TN/OR RIGHT MIRROR HORIZONTAL DRIVER
9 P75 20TN/LG LEFT MIRROR HORIZONTAL DRIVER
10 - -
cardiagn.com
SWITCH-POWER WINDOW-DRIVER C1 - LT. GRAY 6 WAY
CAV CIRCUIT FUNCTION
1 Q411 14OR/WT LEFT REAR WINDOW DRIVER (UP)
2 Q412 14OR/LB RIGHT REAR WINDOW DRIVER (UP)
3 Q612 14OR/DB RIGHT REAR WINDOW DRIVER (DOWN)
4 Q611 14OR/GY LEFT REAR WINDOW DRIVER (DOWN)
5 Q26 14OR/GY (LHD) MASTER WINDOW SWITCH PASSENGER (DOWN)
5 Q22 14OR/VT (RHD) RIGHT FRONT WINDOW DRIVER (DOWN)
6 Q16 14OR/TN (LHD) MASTER WINDOW SWITCH PASSENGER (UP)
6 Q12 14OR/BR (RHD) RIGHT FRONT WINDOW DRIVER (UP)
cardiagn.com
5 - -
6 Q15 14OR/LB WINDOW LOCK OUT SWITCH OUTPUT
cardiagn.com
SWITCH-SEAT BELT-PASSENGER - WHITE 2 WAY
CAV CIRCUIT FUNCTION
1 R274 20LB/WT PASSENGER HALL EFFECT (+)
2 R272 20LB/VT PASSENGER HALL EFFECT (-)
cardiagn.com
TRANSDUCER-A/C PRESSURE - GRAY 4 WAY
CAV CIRCUIT FUNCTION
1 C918 20BK/LB A/C PRESSURE SENSOR GROUND
2 C818 20LB/TN A/C PRESSURE SENSOR SUPPLY
3 C18 20LB/BR A/C PRESSURE SENSOR SIGNAL
4 - -
cardiagn.com
TRANSPONDER-TIRE PRESSURE-RIGHT REAR (TIRE PRESSURE MONITOR) - BLACK 6 WAY
CAV CIRCUIT FUNCTION
1 F202 20PK/GY IGNITION SWITCH OUTPUT (RUN-START)
2 D508 20WT/GY COM-LIN TIRE PRESSURE MONITOR LAN
3 Z965 20BK/GY GROUND
4 - -
5 - -
6 Z965 20BK/GY GROUND
TABLE OF CONTENTS
page
CONNECTOR/GROUND/SPLICE LOCATION
DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
CONNECTOR/GROUND/SPLICE LOCATION
DESCRIPTION
This section provides illustrations identifying connector, ground and splice locations in the vehicle. Connector,
ground and splice indexes are provided. Use the wiring diagrams in each section for connector, ground and splice
identification. Refer to the appropriate index for the proper figure number. For items that are not shown in this sec-
tion N/S is placed in the Fig. column.
cardiagn.com
CONNECTORS
cardiagn.com
38, 44, 46
C202 Lt. Gray Base of Left A-Pillar 23, 24, 26, 29, 31, 33,
36, 42
C203 Lt. Gray Upper Right Side Instrument Panel 23, 25, 29, 30, 32, 41
C204 Natural Below Center Console 35, 40
C300 Lt. Gray Left Side of Luggage Compartment 60
C301 Green Left Kick Panel 44, 46, 53
C302 Black Left Kick Panel 44, 46, 53
C303 Black Below Left Side of Instrument Panel 45, 47, 53
C304 Lt. Gray Below Passenger Seat 50, 57
C305 Lt. Gray Below Driver Seat 48, 57
C306 Green Below Left Side of Instrument Panel 47, 53
C308 Lt. Gray Left B-Pillar 48, 55, 56
C309 Lt. Gray Right B-Pillar 50, 55, 56
C310 Lt. Gray Body Near Left Top Corner of 65, 67
Liftgate
C311 Lt. Gray Body Near Left Top Corner of 65, 67
Liftgate
C312 Lt. Gray Left Side of Instrument Panel 23, 24, 26, 37, 61
C313 Lt. Gray Left Side of Luggage Compartment 60, 62, 64
Capacitor-Ignition Natural Left Side of Engine 14, 16
Cluster C1 Black Driver’s Side of Instrument Panel 26, 32
Cluster C2 Brown Driver’s Side of Instrument Panel 26, 32
Cluster C3 Black Driver’s Side of Instrument Panel 26, 32
Cluster C4 Lt. Gray Driver’s Side of Instrument Panel 26, 32
Coil-Ignition 1 Dk. Gray Right Top of Engine 16
Coil-Ignition 2 Dk. Gray Right Top of Engine 16
Coil-Ignition 3 Dk. Gray Left Top of Engine 16
Coil-Ignition 4 Dk. Gray Left Top of Engine 16
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 3
cardiagn.com
Glow Plug 3 Black Left Top of Engine 20
Glow Plug 4 Black Left Top of Engine 20
Heater-Cabin Lower Instrument Panel 39, 44, 46
Heater-PCV Black Right Top of Engine 18
Heater-Seat Back-Left Black Left Seat N/S
Heater-Seat Back-Right Black Right Seat N/S
Heater-Seat Cushion-Left Green Left Seat 57
Heater-Seat Cushion-Right Green Right Seat 57
Horn 1 Black Left Inner Fender 10
Horn 2 Black Right Inner Fender 2
Injector-Fuel 1 (Diesel) Black Right Top of Engine 20
Injector-Fuel 1 (Gas) Black Right Top of Engine 16
Injector-Fuel 2 (Diesel) Black Right Top of Engine 20
Injector-Fuel 2 (Gas) Black Right Top of Engine 16
Injector-Fuel 3 (Diesel) Black Left Top of Engine 20
Injector-Fuel 3 (Gas) Black Left Top of Engine 16
Injector-Fuel 4 (Diesel) Black Left Top of Engine 20
Injector-Fuel 4 (Gas) Black Left Top of Engine 16
Lamp-Backup-Left Black Left Side of Rear Fascia 60
Lamp-Backup-Right Black Right Side of Rear Fascia 63, 68, 69
Lamp-Cargo Black Cargo Area 43
Lamp-Cup Holder Lt. Gray In Center Console 40
Lamp-Dome Center of Headliner 43
Lamp-Fog-Left Front Black Lower Left Front Fascia 10
Lamp-Fog-Right Front Black Lower Right Front Fascia 2
Lamp-Headlamp-Left Dk. Green At Headlamp Assembly 10
Lamp-Headlamp-Right Dk. Green Right Front Headlamp Assembly 1, 2
Lamp-High Mounted Stop Black Top of Liftgate 67
8W - 91 - 4 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Export)
Lamp-Tail/Stop-Right (Except Black In Rear Lamp Assembly 63, 68
Export)
Lamp-Turn-Left Front (Export) Natural Left Front of Vehicle 2
Lamp-Turn-Right Front Natural Right Front of Vehicle 2
(Export)
Lamp-Vanity-Left Black Left Front Side of Headliner 43
Latch-Door-Driver Black Left Door 53
Latch-Door-Left Rear Black Rear of Left Rear Door 55
Latch-Door-Liftgate C1 Black Inside Liftgate 67
Latch-Door-Liftgate C2 White Inside Liftgate 67
Latch-Door-Passenger Black Right Door 53
Latch-Door-Right Rear Black Right Rear Door 55
Mirror-Inside Rearview C1 Black Center Top Windshield 43
Mirror-Inside Rearview C2 Black Center Top Windshield 43
Mirror-Outside Rearview- Black Left Front Door 52, 53
Driver
Mirror-Outside Rearview- Black Right Front Door 53
Passenger
Module-All Wheel Drive Natural Left Kick Panel Near Grommet to 44
(AWD) Control Engine Compartment
Module-Anti-lock Brakes Black Engine Compartment Near Right 5, 8
Shock Tower
Module-Compass Black Center Stack 29, 32
Module-Electronic Overhead Black Front Center of Headliner 43
C1 (Overhead Console)
Module-Electronic Overhead Black Front Center of Headliner 43
C2 (Overhead Console)
Module-Engine Control C1 Black Left Side of Engine Compartment 8
Module-Engine Control C2 Black Left Side of Engine Compartment 18
Module-Fuel Pump (FWD) Dk. Gray On Fuel Tank 58
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 5
cardiagn.com
Module-Inverter C2 Orange Lower Center Instrument Panel 24, 26
Module-Occupant Black Front of Passenger Seat 57
Classification C1
Module-Occupant Black Front of Passenger Seat 57
Classification C2
Module-Occupant Restraint Yellow/Black Under Center Console 45, 46
Controller C1
Module-Occupant Restraint Yellow/Black Under Center Console 45, 46
Controller C2
Module-Powertrain Control C1 Black Left Side Engine Compartment 8
Module-Powertrain Control C2 Black Left Side Engine Compartment 8, 14, 16
Module-Sentry Key Remote Black Right of Steering Column 28
Entry
Module-Steering Control C1 White At Steering Column 28
Module-Steering Control C2 White At Steering Column 28
Module-Steering Control C4 White At Steering Column 28
Module-Steering Control C5 White At Steering Column 34
Module-Totally Integrated Black Left Side Engine Compartment 8, 9
Power C1
Module-Totally Integrated Lt. Gray Left Side Engine Compartment 8, 9
Power C2
Module-Totally Integrated Brown Left Side Engine Compartment 9
Power C3
Module-Totally Integrated Black Left Side Engine Compartment 8, 9
Power C4
Module-Totally Integrated Blue Left Side Engine Compartment 9
Power C5
Module-Totally Integrated Lt. Gray Left Side Engine Compartment 9
Power C6
Module-Totally Integrated Lt. Gray Left Side Engine Compartment 9
Power C7
8W - 91 - 6 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Motor-Window-Left Front Black Left Front Door 53
Motor-Window-Left Rear Black Left Rear Door 56
Motor-Window-Right Front Black Right Front Door 53
Motor-Window-Right Rear Black Right Rear Door 56
Motor-Wiper-Front Lt. Gray Center of Cowl Panel 8
Motor-Wiper-Rear Green Center of Liftgate 67
Power Outlet-AC Orange In Center Console 40
Power Outlet-Instrument Gray Bottom Center of Instrument Panel 35
Panel
Pump-Washer-Windshield Black Right Front Inner Fender Attached 2, 4
to Washer Reservoir
Radio C1 Dk. Gray Center of Instrument Panel 26, 32
Radio C2 Dk. Gray Center of Instrument Panel 26
Receiver-Satellite Antenna 1 Black Left Rear Body 64
Receiver-Satellite Antenna 2 Tan Left Rear Body 64
Receiver-Satellite C1 — Left Rear Body N/S
Receiver-Satellite C2 — Left Rear Body 64
Relay-Cabin Heater 1 Black Lower Left Front Fender 12
Relay-Cabin Heater 2 Black Lower Left Front Fender 12
Resistor-Blower Motor Gray Lower Passenger Side Instrument 25, 27, 31, 33
Panel
Seat Belt-Tensioner-Driver Yellow/Black Right B-Pillar 48
Seat Belt-Tensioner- Yellow/Black Left B-Pillar 50
Passenger
Sensor-Accelerator Pedal Black At Base of Pedal 44, 47
Position
Sensor-Ambient Black Lower Left Front Fascia 10
AirTemperature
Sensor-Brake Fluid Level Black Left Rear Engine Compartment 6, 8
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 7
cardiagn.com
Temperature 1 (Gas)
Sensor-Engine Coolant Black Center Front of Engine Under Intake 14, 15
Temperature 2 (Gas) Manifold
Sensor-Evaporator Natural Left Side of HVAC Unit 23, 24, 26, 29, 30, 32
Temperature
Sensor-Front Impact-Left Yellow Left Side Body 7
Sensor-Front Impact-Right Yellow Right Front Engine Compartment 4
Sensor-Fuel Temperature Black Left Front of Engine 18
Sensor-Input Speed (CVT) Black Front of Transmission 21
Sensor-Intake Air Temperature Black Left Top of Engine 14
(Gas)
Sensor-Intake Air Black Lower Left Front Fender 12
Temperature/Boost Pressure
(Diesel)
Sensor-Knock Black Left Front of Engine 14, 15
Sensor-MAP Black Right Front of Engine 14
Sensor-Mass Air Flow (Diesel) Black Left Top of Engine 18
Sensor-Oil Temperature Black Top Front of Engine 14
Sensor-Output Speed Black Rear of Transmission 21
Sensor-Oxygen 1/1 Gray Left Side of Engine 14, 16, 17
Sensor-Oxygen 1/2 Black Lower Right Engine Compartment 8
Sensor-Seat Track Position- Dk. Gray Right Rear of Driver Seat 57
Driver
Sensor-Seat Track Position- Dk. Gray Right Rear of Passenger Seat 57
Passenger
Sensor-Seat Weight-Left Front Black Passenger Seat 57
Sensor-Seat Weight-Left Rear Black Passenger Seat 57
Sensor-Seat Weight-Right Black Passenger Seat 57
Front
Sensor-Seat Weight-Right Black Passenger Seat 57
Rear
8W - 91 - 8 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Right Rear
Siren Black Right Front Wheel Opening 3
Solenoid-A/C Compressor Black Lower Front of Engine at 14, 18
Compressor
Solenoid-Camshaft 1/1 Black Right Side of Enginet 14
Position
Solenoid-Camshaft 1/2 Black Right Rear of Engine 14
Position
Solenoid-Electronically At Rear Differential 59
Controlled Clutch
Solenoid-EVAP Purge Black Lower Rear of Engine Compartment 8
Speaker-Instrument White Left Upper Instrument Panel 23, 24, 29, 31, 33
Panel-Left (Premium)
Speaker-Instrument White Right Upper Instrument Panel 23, 25, 29, 30, 32
Panel-Right (Premium)
Speaker-Left Front Door White Left Door 53
Speaker-Left Rear White Left Side Body 55, 56
Speaker-Liftgate Lt. Gray Lower Center of Liftgate 67
Speaker-Right Front Door White Right Door 53
Speaker-Right Rear White Right Side Body 55, 56
Speaker-Subwoofer White Right Side of Luggage 63
Compartment
Starter (Diesel) - Lower Left Front of Engine 18
Starter (Gas) - Left Front of Engine 14, 15
Starter-Eyelet-Battery Side - Lower Left Front of Engine 18
(Diesel)
Starter-Eyelet-Battery Side - Left Front of Engine 15
(Gas)
Starter-Eyelet-Generator Side - Lower Left Front of Engine 18
(Diesel)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 9
cardiagn.com
Switch-Power Window-Driver Lt. Gray Driver Door at Switch 54
C1
Switch-Power Window-Driver Lt. Gray Driver Door at Switch 54
C2
Switch-Power Window-Left Lt. Gray Left Rear Door at Switch 56
Rear
Switch-Power Window- Lt. Gray Passenger Front Door at Switch 54
Passenger
Switch-Power Window-Right Lt. Gray Right Rear Door at Switch 56
Rear
Switch-Remote Radio-Left Black Left Side of Steering Wheel 34
Switch-Remote Radio-Right Black Right Side of Steering Wheel 34
Switch-Seat Belt-Driver Black Lower Left B-Pillar 48
Switch-Seat Belt-Passenger White Passenger Seat 57
Switch-Security Hood Black Left Rear Engine Compartment 8
Switch-Speed Control Black On Steering Wheel 34
Switch-Stop Lamp Black Left Side of Brake Pedal 44, 47
Throttle Body Black Left Front of Engine 14
Transducer-A/C Pressure Gray Top Right of Radiator Fan Assembly 4
Transponder-Tire Pressure- Yellow Rear of Left Front Fender 13
Left Front
Transponder-Tire Pressure- Black At Left Rear Wheel Well 58
Left Rear
Transponder-Tire Pressure- Black At Right Rear Wheel Well 59
Right Rear
Valve-EGR Air Flow Control Black Left Front of Engine 19
(Diesel)
Valve-Manifold Flow Black Left Front of Engine 14
8W - 91 - 10 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
GROUNDS
cardiagn.com
SPLICES
cardiagn.com
S202 (RHD) Center of Instrument Panel 30
S203 (LHD) Left of Instrument Panel 24
S203 (RHD) Center of Instrument Panel 30
S204 (LHD) Left of Instrument Panel 25
S204 (RHD) Left of Instrument Panel 31
S205 (LHD) Left of Instrument Panel 24
S205 (RHD) Right of Instrument Panel 30
S206 (LHD) Left of Instrument Panel 24
S206 (RHD) Center of Instrument Pane 30
S207 Left of Instrument Panel 24, 31
S208 (LHD) Left of Instrument Panel 24
S208 (RHD) Right of Instrument Panel 30
S209 Left of Instrument Panel 24, 31
S214 Lower Center of Instrument Panel 30, 35
S216 (LHD) Left of Instrument Panel 24
S216 (RHD) Right of Instrument Panel 30
S217 In Cluster T/O 29
S220 Left Side of Instrument Panel 24
S225 (LHD) Right Side of Steering Wheel 34
S300 Left Side Body Below B-Pillar 48
S301 (LHD) Body Harness Below Right Side of Instrument Panel 45
S301 (RHD) Body Harness Below Left Side of Instrument Panel 46
S302 (LHD) Body Harness Below Right Side of Instrument Panel 45
S302 (RHD) Body Harness Below Left Side of Instrument Panel 46
S303 Left Front Fender 13
S304 Rear of Left Front Fender 13
S305 Body Harness Near Left Side Instrument Panel 44
S306 Left Side Body Below Front Door Opening 48
S307 Body Harness Below Left Side Instrument Panel 44, 46
S308 Left Side Body Below Front Door Opening 48
S309 Body Harness Below Center of Instrument Panel 45
8W - 91 - 12 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
S333 Body Harness Under Left Seat 48
S334 Left Front Engine Compartment 11
S335 Left Front Engine Compartment 11
S336 Left Front Fender 13
S340 Left Side Body Below Left Rear Door Opening 49
S345 Above Right Rear Wheel Well 63
S348 Above Right Rear Wheel Well 63
S349 Front of Left Front Door 53
S350 Front of Left Front Door 53
S351 Center of Right Front Door 53
S352 Front of Right Front Door 53
S353 Center of Right Front Door 53
S354 Front of Right Front Door 53
S355 Near Upper Left Corner of Liftgate 67
S360 Left Front Headliner 42
S361 Left Front Headliner 42
S362 Left Front Headliner 42
S368 Above Right Rear Wheel Well 63
S370 Center of Left Front Door 53
S372 Right Body Below Right Rear Door Opening 50, 51
S373 Right Body Below Right Rear Door Opening 51, 63
S374 Above Right Rear Wheel Well 63
S375 Passenger Seat 57
S376 Right Side of Passenger Seat 57
S377 Left Side of Passenger Seat 57
S378 Left Side of Passenger Seat 57
S381 Driver Seat 57
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 13
cardiagn.com
Fig. 1 LIGHTING - RIGHT FRONT (LEFT SIMILAR)
8W - 91 - 14
8W-91 CONNECTOR/GROUND/SPLICE LOCATION
PM
cardiagn.com
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 15
cardiagn.com
Fig. 3 WHEEL WELL - RIGHT FRONT
cardiagn.com
Fig. 5 SHOCK TOWER - RIGHT FRONT (LHD)
cardiagn.com
Fig. 7 ENGINE COMPARTMENT - FRONT
8W - 91 - 18 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 19
cardiagn.com
8W - 91 - 20 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 21
cardiagn.com
Fig. 11 FRAME RAIL - LEFT FRONT (GAS)
8W - 91 - 22 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 23
cardiagn.com
Fig. 13 WHEEL WELL - LEFT FRONT
8W - 91 - 24 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 14 ENGINE - LEFT FRONT (GAS)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 25
cardiagn.com
Fig. 15 ENGINE - FRONT (GAS)
8W - 91 - 26 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 16 ENGINE - LEFT REAR (GAS)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 27
cardiagn.com
Fig. 17 ENGINE - REAR (GAS)
8W - 91 - 28 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 18 ENGINE - LEFT FRONT (DIESEL)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 29
cardiagn.com
Fig. 19 ENGINE - LOWER LEFT FRONT (DIESEL)
8W - 91 - 30 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 20 ENGINE - TOP (DIESEL)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 31
cardiagn.com
Fig. 21 TRANSMISSION (CVT)
8W - 91 - 32 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 22 BATTERY
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 33
cardiagn.com
Fig. 23 INSTRUMENT PANEL (LHD)
8W - 91 - 34 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 24 INSTRUMENT PANEL - LEFT (LHD)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 35
cardiagn.com
Fig. 25 INSTRUMENT PANEL - LWR RT (LHD)
8W - 91 - 36
8W-91 CONNECTOR/GROUND/SPLICE LOCATION
PM
cardiagn.com
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 37
cardiagn.com
Fig. 27 HVAC
cardiagn.com
Fig. 29 INSTRUMENT PANEL (RHD)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 39
cardiagn.com
Fig. 30 INSTRUMENT PANEL - RIGHT (RHD)
8W - 91 - 40 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 31 INSTRUMENT PANEL - LEFT (RHD)
PM
8W-91 CONNECTOR/GROUND/SPLICE LOCATION
8W - 91 - 41
cardiagn.com
8W - 91 - 42 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 33 INSTRUMENT PANEL - LOWER LEFT (RHD)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 43
cardiagn.com
Fig. 34 STEERING WHEEL
8W - 91 - 44 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 35 BODY - FRONT CENTER
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 45
cardiagn.com
Fig. 36 A-PILLAR - LEFT
cardiagn.com
Fig. 38 INSTRUMENT PANEL - LOWER LEFT SIDE (RHD)
cardiagn.com
Fig. 40 CENTER CONSOLE
8W - 91 - 48 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 41 A-PILLAR - RIGHT
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 49
cardiagn.com
Fig. 42 HEADLINER - FRONT
8W - 91 - 50 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 43 HEADLINER
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 51
cardiagn.com
Fig. 44 BODY - LEFT FRONT (LHD)
8W - 91 - 52 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 45 BODY - RIGHT FRONT (LHD)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 53
cardiagn.com
Fig. 46 BODY - LEFT FRONT (RHD)
8W - 91 - 54 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 47 BODY - RIGHT FRONT (RHD)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 55
cardiagn.com
Fig. 48 B-PILLAR - LEFT
8W - 91 - 56 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 49 BODY - LOWER LEFT REAR
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 57
cardiagn.com
Fig. 50 B-PILLAR - RIGHT
8W - 91 - 58 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 51 BODY - LOWER RIGHT REAR
cardiagn.com
8W - 91 - 60 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 54 FRONT DOOR - WITH TRIM (LEFT SHOWN, RIGHT SIMILAR)
cardiagn.com
Fig. 56 REAR DOOR - WITH TRIM (LEFT SHOWN, RIGHT SIMILAR)
8W - 91 - 62 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 57 SEATS - FRONT
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 63
cardiagn.com
Fig. 58 UNDERBODY - LEFT REAR
8W - 91 - 64 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 59 UNDERBODY - RIGHT REAR
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 65
cardiagn.com
Fig. 60 BODY - LEFT REAR
8W - 91 - 66
8W-91 CONNECTOR/GROUND/SPLICE LOCATION
PM
cardiagn.com
PM
8W-91 CONNECTOR/GROUND/SPLICE LOCATION
8W - 91 - 67
cardiagn.com
8W - 91 - 68 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
Fig. 63 BODY - RIGHT REAR
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 69
cardiagn.com
Fig. 64 LUGGAGE COMPARTMENT - LOWER LEFT (SATELLITE RADIO)
cardiagn.com
Fig. 66 BODY - UPPER LEFT REAR (SATELLITE RADIO)
PM 8W-91 CONNECTOR/GROUND/SPLICE LOCATION 8W - 91 - 71
cardiagn.com
Fig. 67 LIFTGATE
8W - 91 - 72 8W-91 CONNECTOR/GROUND/SPLICE LOCATION PM
cardiagn.com
PM
8W-91 CONNECTOR/GROUND/SPLICE LOCATION
8W - 91 - 73
cardiagn.com
cardiagn.com
PM 8W-97 POWER DISTRIBUTION 8W - 97 - 1
TABLE OF CONTENTS
page page
cardiagn.com
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
8W - 97 - 2 8W-97 POWER DISTRIBUTION PM
POWER DISTRIBUTION
DESCRIPTION
The power distribution system for this vehicle consists of the following components:
• Totally Integrated Power Module (TIPM)
• Fuse Block
OPERATION
The power distribution system for this vehicle is designed to provide safe, reliable, centralized, and convenient to
access, distribution of the electrical current required to operate all of the many standard and optional factory-in-
stalled electrical and electronic powertrain, chassis, safety, comfort and convenience systems. At the same time,
these systems were designed to provide centralized locations for conducting diagnosis of faulty circuits, and for
sourcing the additional current requirements of many aftermarket vehicle accessory and convenience items.
These power distribution systems also incorporate various types of circuit control and protection features, including:
• Fuses
• Fuse cartridges
• Fusible links
cardiagn.com
• Automatic resetting circuit breakers
• Relays
• Flashers
• Timers
• Circuit splice blocks.
PM 8W-97 POWER DISTRIBUTION 8W - 97 - 3
cardiagn.com
when the ignition is in the ON or ACC positions. The rear power outlet is installed in the right rear quarter trim
panel, near the spare tire jack (2). The power outlet base and mount are secured by a snap fit within the quarter
trim panel. A plastic protective cap snaps into the power outlet base when the power outlet is not being used, and
hangs from the power outlet base mount by an integral bail strap while the power outlet is in use. While the power
outlet is very similar to a cigar lighter base unit, it does not include the two small spring-clip retainers inside the
bottom of the receptacle shell that are used to secure the cigar lighter heating element to the insulated contact. It
has 12 volt battery voltage when the ignition is in the ON or ACC positions.
OPERATION
CIGAR LIGHTER/POWER OUTLET
The cigar lighter consists of two major components: a knob and heating element unit, and the cigar lighter base or
receptacle shell. The receptacle shell is connected to ground, and an insulated contact in the bottom of the shell is
connected to battery current.
The cigar lighter knob and heating element are encased within a spring-loaded housing, which also features a slid-
ing protective heat shield. When the knob and heating element are inserted in the receptacle shell, the heating
element resistor coil is grounded through its housing to the receptacle shell. If the cigar lighter knob is pushed
inward, the heat shield slides up toward the knob exposing the heating element, and the heating element extends
from the housing toward the insulated contact in the bottom of the receptacle shell.
Two small spring-clip retainers are located on either side of the insulated contact inside the bottom of the receptacle
shell. These clips engage and hold the heating element against the insulated contact long enough for the resistor
coil to heat up. When the heating element is engaged with the contact, battery current can flow through the resistor
coil to ground, causing the resistor coil to heat.
When the resistor coil becomes sufficiently heated, excess heat radiates from the heating element causing the
spring-clips to expand. Once the spring-clips expand far enough to release the heating element, the spring-loaded
housing forces the knob and heating element to pop back outward to their relaxed position. When the cigar lighter
knob and element are pulled out of the receptacle shell, the protective heat shield slides downward on the housing
so that the heating element is recessed and shielded around its circumference for safety.
POWER OUTLET
The power outlet base or receptacle shell is connected to ground, and an insulated contact in the bottom of the
shell is connected to battery current. The power outlet receives battery voltage from a fuse in the Totally Integrated
Power Module (TIPM) through a fuse in the fuse block when the ignition is in the ON or ACC positions.
8W - 97 - 4 8W-97 POWER DISTRIBUTION PM
REMOVAL
1. Disconnect and isolate the battery negative cable.
2. Look inside and note position of the retaining
bosses (1).
3. Using special tool 9857 Power Outlet Remover.
Insert the tool forcing the bosses out of base.
4. Pull out the base through mounting ring (4) by gen-
tly rocking the tool (3).
5. Disconnect the base wires.
6. Set base aside and remove base mount ring.
cardiagn.com
INSTALLATION
1. Position mount ring to the instrument panel and feed the wires through ring. Index the cap and the mount ring
with the index tab at 9 o’clock to the key in the instrument panel. Install the ring.
2. Connect wires to base. Orient base alignment rib at 11 o’clock to mate the groove in mount ring at the same
location
3. Push base into the bezel till it locks.
4. Install cigar lighter cap.
5. Connect the battery negative cable.
PM 8W-97 POWER DISTRIBUTION 8W - 97 - 5
FUSE BLOCK
DESCRIPTION
An electrical Fuse Block is located in the left front
bumper fascia. It serves to simplify and centralize
numerous electrical components, as well as to distrib-
ute electrical current to many of the accessory sys-
tems in the vehicle.
The Fuse Block is positioned on a mounting bracket
up and under the left instrument panel. It is secured
by two screws. The fuse block is concealed behind a
fuse panel cover. The fuse panel cover is a snap-fit
access cover that conceals the fuse block fuses. A
fuse layout placard is on the back of the end cap to
ensure proper fuse identification.
cardiagn.com
OPERATION
The fuse block houses blade-type fuses and automatic resetting circuit breakers. Internal connection of all the fuse
block circuits is accomplished by an intricate network of hard wiring and bus bars. Refer to Wiring Diagrams for
complete circuit diagrams.
The fuses and circuit breakers are available for service replacement. The fuse block unit cannot be repaired and is
only serviced as an assembly. If any circuit or the fuse block housing is faulty or damaged, the entire fuse block
must be replaced.
REMOVAL
WARNING: ON VEHICLES EQUIPPED WITH AIR-
BAGS, REFER TO RESTRAINT SYSTEMS BEFORE
ATTEMPTING ANY STEERING COLUMN OR
INSTRUMENT PANEL COMPONENT DIAGNOSIS
OR SERVICE. FAILURE TO TAKE THE PROPER
PRECAUTIONS COULD RESULT IN ACCIDENTAL
AIRBAG DEPLOYMENT AND POSSIBLE PER-
SONAL INJURY.
INSTALLATION
WARNING: ON VEHICLES EQUIPPED WITH AIR-
BAGS, REFER TO RESTRAINT SYSTEMS BEFORE
ATTEMPTING ANY STEERING COLUMN OR
INSTRUMENT PANEL COMPONENT DIAGNOSIS
OR SERVICE. FAILURE TO TAKE THE PROPER
PRECAUTIONS COULD RESULT IN ACCIDENTAL
AIRBAG DEPLOYMENT AND POSSIBLE PER-
SONAL INJURY.
cardiagn.com
PM 8W-97 POWER DISTRIBUTION 8W - 97 - 7
IOD FUSE
DESCRIPTION
All vehicles are equipped with an Ignition-Off Draw (IOD) fuse that is disconnected within the Totally Integrated
Power Module (TIPM) when the vehicle is shipped from the factory. Dealer personnel are to reconnect the IOD fuse
in the TIPM as part of the preparation procedures performed just prior to new vehicle delivery.
OPERATION
The term ignition-off draw identifies a normal condition where power is being drained from the battery with the igni-
tion switch in the Off position. The IOD fuse feeds the memory and sleep mode functions for some of the electronic
modules in the vehicle as well as various other accessories that require battery current when the ignition switch is
in the Off position, including the clock. The only reason the IOD fuse is disconnected is to reduce the normal IOD
of the vehicle electrical system during new vehicle transportation and pre-delivery storage to reduce battery deple-
tion, while still allowing vehicle operation so that the vehicle can be loaded, unloaded and moved as needed by both
vehicle transportation company and dealer personnel.
The IOD fuse is disconnected from Totally Integrated Power Module (TIPM) fuse cavity 18 when the vehicle is
shipped from the assembly plant. Dealer personnel must reconnect the IOD fuse when the vehicle is being prepared
for delivery in order to restore full electrical system operation. Once the vehicle is prepared for delivery, the IOD
function of this fuse becomes transparent and the fuse that has been assigned the IOD designation becomes only
cardiagn.com
another Fused B(+) circuit fuse. The IOD fuse serves no useful purpose to the dealer technician in the service or
diagnosis of any vehicle system or condition, other than the same purpose as that of any other standard circuit
protection device.
The IOD fuse can be used by the vehicle owner as a convenient means of reducing battery depletion when a vehi-
cle is to be stored for periods not to exceed about thirty days. However, it must be remembered that disconnecting
the IOD fuse will not eliminate IOD, but only reduce this normal condition. If a vehicle will be stored for more than
about thirty days, the battery negative cable should be disconnected to eliminate normal IOD; and, the battery
should be tested and recharged at regular intervals during the vehicle storage period to prevent the battery from
becoming discharged or damaged.
REMOVAL
NOTE: When removing or installing the IOD fuse, it is important that the ignition switch be in the Off posi-
tion. Failure to place the ignition switch in the Off position can cause the radio display to become scram-
bled when the IOD fuse is installed. Removing and installing the IOD fuse again with the ignition switch in
the Off position will usually correct the scrambled radio display condition.
INSTALLATION
1. Insert fuse 7/8 into the Totally Integrated Power Module (TIPM).
2. Install the cover to the TIPM.
8W - 97 - 8 8W-97 POWER DISTRIBUTION PM
OPERATION
All of the current from the generator cable connection goes to the battery through a 10 gauge fusible link that is
secured with a nut to the positive battery terminal at the starter. Internal connection of all the Totally Integrated
Power Module (TIPM) circuits is accomplished by an intricate network of hard wiring and bus bars. Refer to Wiring
Diagrams for complete circuit diagrams.
The fusible link, fuses and relays are available for service replacement. The TIPM unit cannot be repaired and is
only serviced as a unit with the engine compartment wire harness. If the TIPM is inoperative or damaged, the
cardiagn.com
engine compartment wire harness assembly must be replaced.
REMOVAL
The TIPM (TIPM) is serviced as a unit with the engine compartment wire harness. If any internal circuit of the TIPM
or the TIPM housing is faulty or damaged, the entire TIPM and engine compartment wire harness unit must be
replaced. Refer to Wiring Diagrams for more information on the locations of the affected connectors.
1. Open hood.
2. Disconnect and isolate the battery negative cable.
3. Disconnect each of the engine compartment wire harness connectors.
4. Remove the fasteners that secure each of the engine compartment wire harness ground eyelets to the vehicle
body and chassis components.
5. Disengage each of the retainers that secure the engine compartment wire harness to the vehicle body and chas-
sis components.
6. Disengage and remove the TIPM housing from its mounting bracket.
7. Remove the TIPM and the engine compartment wire harness from the engine compartment as a unit.
INSTALLATION
The Totally Integrated Power Module (TIPM) is serviced as a unit with the engine compartment wire harness. If any
internal circuit of the TIPM or the TIPM housing is faulty or damaged, the entire TIPM and engine compartment wire
harness unit must be replaced.
NOTE: If the power distribution center (TIPM) is being replaced with a new unit, be certain to transfer each
of the fuses and relays from the old power distribution center to the proper cavities of the new power dis-
tribution center. Refer to Wiring Diagrams for the proper power distribution center cavity assignments.
6. Torque nut retaining positive battery cable at TIPM to 96 - 141 N·m (85 - 130 in. lbs.).
7. Reconnect the battery negative cable.
8. Close hood.
9. Verify vehicle and system operation.
cardiagn.com
8W - 97 - 10 8W-97 POWER DISTRIBUTION PM
RELAY
REMOVAL
1. Disconnect and isolate the battery negative cable.
2. Remove cover from Totally Integrated Power mod-
ule (TIPM).
3. Using special tool C-4817 (1), grip the relay (2) by
the sides and pull upward with an even effort.
cardiagn.com
INSTALLATION
1. Align relay (2) with Totally Integrated Power Module
(TIPM) and press into position.
2. Install cover to TIPM.
3. Connect battery negative cable.