Académique Documents
Professionnel Documents
Culture Documents
Bottom of Form
INSTALLATION PROCEDURE FOR ANTENNA
3.1 Assemble the wall mount/ground mount stand as per the drawing, Mark the holes
on wall/terrace roof, use proper electrical drill machine and drill bit, Drill should
be 8 mm thick and drill hole up to 3 inch depth deep in the wall for all the holes,
Insert wooden grip plug up to 3 inch depth deep in the hole properly, mark center
point on all inserted wooden grips. screw all the sheet metal screws and washer
(Item No: 13 / 11) up to maximum depth using the proper screw driver.
3.2 Tight all the Nuts, Bolts and screws(Item No:2 / 12 / 13 ), Make sure that it
should not be lose at all. completing this, check for the wall mount stand
grip/strength It should be strong enough to take the antenna load, Check the
Rigidity of the antenna by shaking the Antenna mount.
3.3 Assemble Az-El mount as per drawing ,Make sure the degree marking must be as
per the drawing, this is most important for correct elevation alignment , first fit
LNB arm properly with the big clamp than remove small screw/Nut ( 4-mm /
item no 15/16) from the big clamp, Assemble small clamp with U-bolts, Nuts and
washer , insert the small clamp in to the big clamp than fit small screws and nut
as per the drawing in the center of the clamp, insert 5/16 “ bolt/Nut/washer
( Item no:6/7/8) as per the drawing, keep all nuts and bolts loose up to the final
assembly.
3.4 Fit Az-El Mount with antenna as marked in the drawing (Keep Doordarshan
Logo -upper side) tight all Nuts, Bolts and Washer of (item no:01/02/11)
3.5 Now fit properly LNB holder (Plastic clamp) as per the drawing also fit LNBF on
the LNB holder, keep the output connector direction towards the ground side,
3.6 Mount the entire antenna assembly on the wall mounted stand ,keep Nuts and
Bolts of Az-El mount partly loose up to the antenna alignment
3.7 Now interconnect all cables like LNB to Receiver and Receiver to TV set as per
the drawing.
3.8 Make sure that distance between antenna and receiver should not be more than 25
mtrs. Do not connect any additional cable..
3.9 Align the antenna to the correct satellite using the general Procedure followed to
align the Antenna ( see the IRD installation Instruction)
3.10 Optimize the antenna up to the maximum “quality” level in the IRD.
3.11 After optimizing and receiving all TV channels, tight all the nuts and bolts of Az-
El mount fully without disturbing the elevation and azimuth, make sure that when
you tight nuts and bolts of Az-El mount the “quality” level Should not decrease.
Mark the elevation and azimuth angle for your future reference using with the
permanent marker pen or oil paint on Az-El clamp.
Top of Form
Bottom of Form