Académique Documents
Professionnel Documents
Culture Documents
___________________
Student’s Name: ______________________________________________________ Section:
___________________
PAIR TASK
Activity #03-00-03
Simple Relay Circuit on Breadboard
Components:
QT PART DESIGNAT NOTES QT PART DESIGNATOR NOTES
Y OR Y
1 Relay 6 volts 1 Breadboard
2 LED 5mm Red Wires #22
1 Resistor 10k Ohm 1 Battery 9Volts
1 Switch 1 Battery Clip
Schematic Diagram of simple relay circuit:
Step 2: Insert the relay on the breadboard. Make sure all the terminal are inserted in the bread board.
Coil is Terminal 1
The longer part of the LED is the Anode and the shorter part Cathode.
Step 4: Connect the Anode of the first LED to the Terminal 4 (NO). Then the Cathode to the negative rail of the breadboard.
Step 5: Connect the Anode of the second LED to the Terminal 3 (NC). Then the Cathode to the negative rail of the breadboard.
Step 6: Insert the first wire of resistor to the Terminal 5. Then the other wire to the positive rail of the breadboard.
Step 7: Connect the switch positive wire to the Terminal 2 and the switch negative wire to the terminal 1.
Step 9: Connect the negative terminal to the negative rail of the breadboard. Then the positive to terminal to the positive rail of the
breadboard.
Step 10: One of the LED must lighten. If the switch is On another LED will lighten.