Vous êtes sur la page 1sur 4

FREE PROJECT

FIVE-POCKET
SHOWER ORGANIZER
1. Baste INTERFACING
to wrong side of each
matching FABRIC sec-
tion, having raw edges
even.

2. Press under 1⁄4”


(6mm) on upper edge
UPPER POCKET. Turn
upper edge to inside
on hemline. Stitch hem
in place along pressed
under edge.

3. To make center pleat,


crease on line with
small circles and bring
to line of large circles.
Press. Baste across
upper and lower
edges of pleats. Make
side pleats in same
manner.

4. Press under ½"


(1.3cm) on lower edge
of pocket.

SUGGESTED FABRICS:
Fabric: Nylon; Pockets: Mesh
YOU WILL NEED: 5. With right sides
Fabric: 45"- 60" wide – ½ yd. up, pin pocket to one
FRONT AND BACK
Mesh (pockets): 60" wide – ½ yd. section, placing lower
Sew-in Interfacing: 21"- 25" wide – 1 yd. edge along placement
line and matching large
Notions: Two 7⁄8 " buttons OR Qwik-Tack™Tape circles. EDGESTITCH
and Flex-On™Loops lower edge in place.
Baste side edges.
Please read all the instructions before you
start your project.
All seam allowances are ½" (13mm) unless
otherwise indicated. ©2010 The McCall Pattern Company.
All rights reserved
SHOWER ORGANIZER pg. 2

6. Remove pleat 11. Pin front and 16. Turn right side
basting. Stitch back sections, right out. Press. Baste
pocket along sides together. raw edges together.
stitching line, Stitch, leaving an Stitch along
keeping pleats free. opening for turning. previous stitching
Baste side edges on pockets through
together. all thicknesses.
EDGESTITCH outer
edges of caddy.

7. Finish upper 12. Turn right side


edge of LOWER out. SLIPSTITCH
POCKET 3 in same opening edges.
manner as upper Press.
pocket. Pin pocket 17. Beginning and
to lower edge of ending between
front and back, loops without slit,
matching large cut a piece of Qwik-
circles and having Tack® Tape 10"
raw edges even. (25.5cm) long.
To form sections,
stitch pocket along
stitching lines.
Baste raw edges 13. Stitch along 18. Slip caddy
together. previous stitching between folds of
NOTE: Caddy can on pockets through tape, having outer
be finished with all thicknesses. edges even.
straps or optional EDGESTITCH outer EDGE-STITCH and
tape and loops. edges of caddy. TOPSTITCH lower
TOPSTITCH 1" edge of tape.
(2.5cm) from upper
edge of caddy.

8. For each strap, 19. Finish edges of


stitch two STRAP tape with a close-
sections leaving set zig zag stitch,
ends with circles keeping slits free.
free.

9. Turn right side 14. Make 20. Place Flex-On®


out. Press. Baste buttonholes on Loops with prongs
raw edges together. ends of straps.Cut on right side of
buttonholes open. Qwik-Tack® Tape,
Sew buttons to aligining slit in ring
caddy at markings. with opening in
fabric and inserting
prongs into holes.
Snap remaining
LOOPS® sec-
tion over prongs,
10. Pin straps to OPTIONAL TAPE AND LOOPS: matching slit open-
upper edge of ing. To hang caddy,
front and back, slide LOOPS® over
matching small 15. Pin front and rod.
circles. Baste. back sections, right
sides together.
Stitch sides and
lower edge.

©2010 The McCall Pattern Company.


All rights reserved
SHOWER ORGANIZER pg. 3

ENLARGE ALL
PATTERN PIECES
200%

ENLARGE 200%
ENLARGE 200%

©2010 The McCall Pattern Company.


All rights reserved
SHOWER ORGANIZER pg. 4

ENLARGE 200%

ENLARGE 200%

ENLARGE
ALL
PATTERN
PIECES
200%

©2010 The McCall Pattern Company.


All rights reserved

Vous aimerez peut-être aussi