Académique Documents
Professionnel Documents
Culture Documents
B
A
2. For No Emblem Grilles: Unbolt the Ford emblem and use 4. Once the paint has cured, align the mesh section
a grinder to grind flush the emblem base with the grille. onto the back of the studed frame. Align the grille,
3. For Five Hundred models with an argent (silver) factory passing the studs through the existing openings in the
grille insert: Use masking tape to tape up the edges of the factory grille. Install a black plastic washer (lower
factory chrome around the grille and emblem. Mask the
areas with protective paper to protect the bumper and washers may require trimming to fit flush) and an
1. Remove the plastic push fasteners using a phillips headlights against paint overspray. Scuff the factory grille ESNA half nut onto each stud and finger tighten only!
screw driver (A) and an 8mm socket (B) on each and apply semi-gloss black paint. 5. Remove any protective masking tape that could get
side. caught once the grille is tightened.
Car Accessories | Ford Accessories | Ford Grilles Copyright 2006 by E&G Classics, Inc.
6
8
6. Use a 9mm socket to tighten the seven (7) ESNA 7. Apply black paint to the studs on the emblem sur- 8. Align the emblem surround into place and install a
half nuts to secure the frame and mesh over the round to conseal them once the surround is black plastic washer and an 8-32 ESNA half nut
factory grille. Do not overtighten or you could installed. onto each stud and tighten.
damage the frame by indenting where the studs
are located.
Car Accessories | Ford Accessories | Ford Grilles 2 Copyright 2006 by E&G Classics, Inc.