Vous êtes sur la page 1sur 2

NAMA : GIOVALEN ANDREASELNAT

NIM : 44218035
CHANGE THE PROCEDURES TO CLEAN THE PUMP ON A WHIRLPOOL WASHING
MACHINE BELOW INTO PASSIVE SENTENCES

1. Unplug the washer's electrical cord from the wall outlet.

Answer : From the wall outlet, The washer’s electrical is unplugged.

2. Unhook the drain hose from the drain or stationary tub.

Answer : From the drain or stationary tub, the drain hose is undhooked.

3. Unscrew the water hose fittings from the machine using a pair of slip-joint
pliers.

Answer : From the machine, the water hose fittings is unscrewed using a pair
of slip-joint.

4. Turn the fittings counterclockwise to loosen them.

Answer : To loosen the fittings turned them counterclockwise

5. Pull the washer away from the wall several feet.

Answer : From the wall several feet, the washer is pulled away.

6. Lay an old blanket on the floor in front of the washer and tilt the washer
forward

Answer : On the floor in front of the washer, an old blanked is layed and
tilted the washer forward.

7. Locate the pump underneath the bottom of the washing machine.

Answer : Underneath the bottom of the washing machine, the pump is


located.

8. Squeeze the spring clips that secure the two hoses to the pump using a pair of
slip-joint pliers.

Answer : Using a pair of slip-joint pliers, the spring clips that secure the two
hoses to the pump is squeezed.

9. Pull the pump off the drive shaft and remove it from the washer cavity.

Answer : The drive shaft is pulled the pump off and from the washer cavity it
is removed.

10. Douse the pump with a spray solvent and scrub the interior with an old
toothbrush.

Answer : with a spray solvent the pump is doused and the interior with an old
toothbrush is scrubbed.

11. Remove the dirt and debris .


Answer : The dirt and debris is removed.

12. Flush the pump with water for several minutes to ensure that it is clean.

Answer : To ensure that it is clean the pump is Flushed with water for several
minutes.

13. Place the pump on the drive shaft and reconnect the hoses.

Anwer : On the drive shaft, the pump is placed and the hoses is reconnected

14. Set the machine upright and push it against the wall and reconnect the water
hoses.

Answer : The machine is set upright and the wall is pushed it against and the
water hooses is reconnected.

15. Plug the cord into the outlet and replace the drain hose into the drain or
stationary tub.

Answer : The cord into the outlet is plugged and the drain hose into the drain
or stationary tub is replaced.

Vous aimerez peut-être aussi