Vous êtes sur la page 1sur 47

A SMART GIRL'S GUIDE TO HAND KNIT 

 
 
This book will guide you to all the very newest hand knits to wear on and off campus! Carcoats, cardigans, pullovers, dickies, 
and lots more for the entire campus crowd. And you can knit them all so quickly with the clear "knitting made easy" instructions 
in this book.  
 
FOR GRADE A RESULTS use smooth, beautiful Botany Yarn, a name that has always stood for fine quality, You're sure to find 
just the type yarn you're looking for whether it's a big bulky yarn like "Colossal", the fastest knitting yarn ever, a Shetland type 
like "Scottie", or any other type you have in mind, including the famous Botany NO‐DYE‐LOT types.  
 
HIGH  SCORING  COLORS.  Botany's  fashion‐perfect  hues  are  made  for  you.  You'll  find  all  the  newest,  smartest  shades‐yes, 
heathers and oxfords, too.  
 
FROM  FROSH  TO  SENIOR  YEAR  and  then  some,  your  hand  knits  will  stay  young  and  beautiful  when  you  knit  them  with  top 
quality Botany‐it's one of the world's great names in wool.  

Check out other great patterns at PurpleKittyYarns.com,


FreeVintageCrochet.com & FreeVintageKnitting.com

Digital Restoration © 2009 Purple Kitty LLC 2


Helpful Information 
stitch gauge ‐ Important ‐ Knitted garments are planned on the basis of working to a specified number of stitches and rows to 1 inch; this 
is referred to as the GAUGE. Required gauge is given at beginning of instructions. If this gauge is not obtained the finished garment will 
not be the correct size. The size needles recommended will give the average knitter the correct gauge. However, if you do not obtain the 
gauge required, change the size needles to conform to the tension of your individual knitting; if your knitting is too loose use smaller size 
needles to tighten gauge; if your knitting is too tight, use larger size needles to loosen gauge. You MUST get gauge given to insure proper 
size of finished garment.  
 
measurements  of  garments  ‐  The  sizes  of  garments  in  this  book  are  based  on  the  actual  body  measurements  given  below.  In  the 
instructions an allowance has been made over the actual body measurements to give sufficient ease and insure correct fit. This allowance 
varies according to the style of garment, stitch, type of yarn and gauge of knitting. To determine which size garment you should make, 
take  your  own  accurate  body  measurements.  Then  use  instructions  for  size  with  body  measurements  nearest  to  your  own  body 
measurements. If adjustment is necessary be sure to allow the same number of inches over actual body measurements as allowed on 
garment you intend to make. See body measurement charts below.  
 
women's body measurements  
      Sizes   12   14   16   18   20   40   42   44  
        ‐   (32)   (34)   (36)   (38)   ‐   ‐   ‐  
Bust . . . . . . . . . . . . . . . . . . . .     30 ins.   32 ins.   34 ins.   36 ins.   38 ins.   40 ins.   42 ins.   44 ins.  
Waist . . . . . . . . . . . . . . . . . . .     25 ins.   26 ½ ins.  28 ins.   30 ins.   32 ins.   34 ins.   36 ins.   38 ins.  
Hip (7 ins. below waist) . . . .     33 ins.   35 ins.   37 ins.   39 ins.   41 ins.   43 ins.   45 ins.   47 ins.  
 
men's body measurements  
      Sizes   36   38   40   42   44  
Chest  . . . . . . . . . . . . . . . . . . .    36 ins.  38 ins.  40 ins.  42 ins.  44 ins. 
 
complete abbreviations  
  k ‐ knit       dec. (s) ‐ decrease(s)     in.(s) ‐ inch(es)  
  p ‐ purl       tog. ‐ together       yo ‐ yarn over  
  st(s) ‐ stitch(es)     beg. ‐ beginning       ch ‐ chain  
  inc. (s) ‐ increase (s)   pat. (s) ‐ pattern (s)     sc ‐ single crochet 
dc – double crochet  
 
slip, k and pass ‐ slip 1, k 1, pass the slipped st over the knitted st.  
An  asterisk  (*)  indicates  that  the  instructions  immediately  following  are  to  be  repeated  the  given  number  of  times  in  addition  to  the 
original.  
Dagger (†) is used in the same way.  
 
markers ‐ Make a small loop of contrasting color yarn and place on needle at point or points indicated in instructions. Slip loop from left 
to right needle without knitting.  
 
blocking or steaming ‐ To give a more tailored finish to knitted or crocheted garments it is preferable to block each piece separately. Care 
should be taken to block pieces to knitted shape. If the garment is sewn together first and blocked carefully after assembling, the result 
will also be satisfactory.  
 
to block separate pieces ‐ Lay pieces flat on pressing board, wrong side up, pin edges to board. Steam well with moderately hot iron over 
a wet cloth, taking care not to let weight of iron rest upon any one spot. After blocking leave pinned until thoroughly dry. Do not steam 
ribbing.  
 
to block finished garment ‐ Lay flat on pressing board, wrong side out. Steam first one side and when dry, steam other side.  
After blocking leave pinned until thoroughly dry, then steam all seams and crocheted edges. Do not steam ribbing.  
 
to block skirts ‐ Pin to board as above and block. When thoroughly dry, remove from board. Pin and block other half. Steam out creases.  
 
casing for elastic for skirts ‐ Holding wrong side of skirt toward you, join yarn on top edge of skirt, ch 5, skip 1 st, 1 slip st in next st at left 
in 6th row below, ch 5, skip 1 st, 1 slip st at top of skirt in 4th st at left of first st, ch 5, continue in this way around top of skirt, join with 
slip st in first st; ch 1, turn, 1 sc in each st around top of skirt; join. Fasten off. Insert elastic.  
 
beading for elastic for skirts ‐ Holding right side of skirt toward you, join yarn on top edge of skirt, ch 5; skip 1 st, 1 tr in next st, ch 1, skip 
1 st, 1 tr in next st; continue in this way around top of skirt, join with slip st in top of ch; ch 1, do not turn, 1 sc in each st around top of 
skirt; join. Fasten off. Insert elastic. 

Digital Restoration © 2009 Purple Kitty LLC 3


Style No. 130  
Sizes 12, 14, 16. 
Instructions are for size 12, changes for sizes 14 and 16 are in parentheses, see body measurement chart, page 3. 
           
  Size 12  Size 14  Size 16  
MATERIALS: BOTANY KWILTEE, 2 oz. skeins.           11 skeins      12 skeins    13 skeins  
 
KNITTING NEEDLES:  
1 pair "Boye" Non‐Inflammable Needles, Size 10 ½ ‐ 
0R SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 6 for Cuffs and Waistband.  
"Boye" Non‐Inflammable Hook, Size I.  
 
GAUGE: Size 10 ½  Needles ‐ 4 sts = 1 inch 
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
Width at bustline   inches  37  39   41  
Width of back at underarm   inches   18 ½    19 ½    20 ½   
 
BACK‐With size 6 needles, cast on 73 (77‐81) sts.   shoulder,  end  at  armhole  edge.  Shape  shoulder  same  as  left 
Row 1 ‐ wrong side ‐ p 1, * k 1, p 1; repeat from * to end.   shoulder  on  back.  Beg.  at  neck  edge,  work  left  side  to 
Row 2 ‐ k 1, * 1, k 1; repeat from * to end.   correspond  to  right  side,  shaping  shoulder  same  as  right 
Repeat these 2 rows until about 3 ¾ ins, from beg., end on right  shoulder on back. Do not break yarn. Sew shoulder seams.  
side.    
  FRONT  NECK  RIBBING  ‐  With  size  6  needles,  pick  up  and  k  15 
Inc. row ‐ wrong side ‐ Work ribbing for 19 (21‐23) sts, inc. 1 st  sts on left side of neck, take up and work 27 sts of neck, pick up 
in  next  st,  work  ribbing  for  41  sts,  inc.  1  st  in  next  st,  work  and k 15 sts on right side of neck; 57 sts.  
ribbing to end; 75 (79‐83) sts.    
  Next  row  ‐  wrong  side  ‐  Work  same  as  row  1  of  ribbing  on 
Cable  Pattern  ‐  Row  1  ‐  Cable  twist  ‐  With  size  10  ½  needles,  lower edge of back.  
work 10 (12‐14) sts in ribbing, * slip next 6 sts to hook, hold at  Work same as for back neck ribbing until same number of rows 
back of work, k next 6 sts, k sts from hook *, work next 31 sts in  above inc. row.  
ribbing, repeat between *'s once, work 10 (12‐14) sts in ribbing.    
Row  2  ‐  Work  10  (12‐14)  sts  in  ribbing,  p  12,  work  31  sts  in  Short rows ‐ Row 1 ‐ Work 54 sts, turn.  
ribbing, p 12, work 10 (12‐14) sts in ribbing.    
Row  3 ‐  Work  10  (12‐14)  sts,  k  12,  work  31  sts,  k  12,  work  10  Row 2 ‐ Slip first st as to p, work 50 sts, turn.  
(12‐14) sts. Repeat last 2 rows 7 times.    
Row 18 ‐ Same as row 2.   Row 3 ‐ Slip first st as top, work 47 sts, turn.  
Repeat these 18 rows for pat. Work even in pat. until about 10   
ins. above ribbing, end with pat. row 1. Mark for underarm.   Row 4 ‐ Slip first st as to p, work 44 sts, turn.  
  Continue to work 3 sts less every row for 14 rows more.  
Armholes ‐ Bind off 4 (5‐6) sts at beg. of each of next 2 rows; 67   
(69‐71) sts. Work even until armholes measure 7 ½  (7 ¾‐8) ins.,  Row 19 ‐ Turn, slip 1, work 2 sts. Break yarn and slip 27 sts from 
end on right side.   left  needle  to  right  needle;  57  sts.  Join  yarn  and  bind  off  in 
  ribbing.  
Shoulder Shaping ‐ Bind off 6 (0‐8) sts at beg. of each of next 2   
(0‐2) rows; 7 sts at beg. of each of next 4 (6‐4) rows; 27 sts.   SLEEVES  ‐  With  size  6  needles,  cast  on  37  (39‐41)  sts.  Work 
  ribbing as for back until 3 ¾ ins. from beg., end on wrong side. 
Back Neck Ribbing ‐ Inc. row ‐ With size 6 needles, work 3 sts, *  With size 10 ½  needles, continuing ribbing, inc. 1 st each side 
inc. 1 st in next st, work 3 sts; repeat from * to end; 33 sts.   of next row; repeat incs. every 6th row 0 (3‐7) times; every 8th 
Next row ‐ Work k 1, p 1 ribbing across row. Continue ribbing  row 8 (6‐3) times, with care to work increased sts in ribbing; 55 
until 1 ½ ins. above inc. row. With size 10 ½ needles, work even  (59‐63) sts. Work even until 17 ins. from beg. Bind off 4 (5‐6) sts 
in ribbing until 5 ½ ins. above inc. row. Bind off in ribbing.   at  beg.  of  each  of  next  2  rows.  Dec.  1  st  each  side  every  2nd 
  row 6 (7‐8) times. Bind off 2 sts at beg. of each of next 6 rows. 
FRONT ‐ With size 6 needles, cast on 73 (77‐81) sts. Work same  Bind off 23 sts.  
as  back  until  armhole  measures  about  5  ½  (5  ¾‐6)  ins.  above   
marker, end on wrong side; 67 (69‐71) sts.   FINISHING ‐ Sew seams, sewing part of cuff and collar for turn‐
Divide for Neck ‐ Work 20 (21‐22) sts, place on holder for left  over,  on  wrong  side.  Sew  in  sleeves  with  seam  at  center 
side, work 27 sts, place on holder for neck, work 20 (21‐22) sts.  underarm. Block, see page 3. 
Work  even  on  sts  of  right  side  until  same  length  as  back  to 

Digital Restoration © 2009 Purple Kitty LLC 4


Digital Restoration © 2009 Purple Kitty LLC 5
Style No. 120 
Instructions are for sizes 34, 36, 38, 40, 42 and 44, see body measurement chart, page 3. 
 
        Sizes  34  36  38  40  42 
MATERIALS: BOTANY CLASSIC SPORT, 1 oz. skeins             skeins  8  8  9  9  10 
or BOTANY NYLON AND WOOL SPORT, 1 oz. skeins           skeins  9  9  10  11  12 
   
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 4‐             
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.             
"Boye" Steel Hook, Size 3             
GAUGE: 7 sts = 1 inch             
To check gauge, see page 3.             
MEASUREMENTS FOR BLOCKING:              
                  Chest, buttoned ………………………………………………………………………………………………………………  inches  35  37  39  41  43 
                  Width of back at underarm ……………………………………………………………………………………………..  inches  17  18  19  20  21 
BACK ‐ Cast on for lower edge ………………………………………………………………………………………………………..  sts  110  116  124  130  138 
Ribbing ‐ Row 1 ‐* p 1, k 1 inserting needle in back of st ‐ twist st; repeat from * to end. Repeat             
this row until 10 rows from beg. 
Inc. row ‐ wrong side ‐ Continue ribbing, increasing 1 st in every ……………………………………………………    10th  10th  12th  12th  12th 
st 10 times, finish row …………………………………………………………………………………………………………………….   sts  120  126  134  140  148 
Work stockinette st ‐ k 1 row, p 1 row‐until 12 ins. from beg., end with p row.              
Armholes ‐ Row 1 ‐ right side ‐ Cast on 7 sts at beg. of row for border, * p 1, k 1 twist st; repeat             
from * twice, p1, k to end. 
Row 2 ‐ Cast on 7 sts at beg. of row for border, k 1, p1, * k 1 twist st, p1; repeat from * twice, p to             
within 7 sts of end, k 1 twist st † p1, k 1 twist st; repeat from † twice …………………………………………….  sts  134  140  148  154  162 
Dec. row ‐ right side ‐ * p 1, k 1 twist st; repeat from * twice, p 1 for border; slip, k and pass, k to             
within 9 sts of end, k 2 tog.; pi, † k 1 twist st, p1; repeat from † twice for border. 
Next row ‐ k 1, p1, * k 1 twist st, p1; repeat from * twice, p to within 7 sts of end, k 1 twist st, † p             
1, k 1 twist st; repeat from † twice. 
Repeat last 2 rows 22 times …………………………………………………………………………………………………………….   sts  88  94  102  108  116 
Work even continuing border on 7 sts each side as before until measurement above first 7 sts             
cast on for border is ………………………………………………………………………………………………………………………..  ins.  8 ½  9  9½  10  10½ 
Shoulder Shaping ‐ Bind off …………………………………………………………………………………………………………….   sts  6  6  6  7  7 
at beg. of each of next …………………………………………………………………………………………………………………….  rows  2  4  8  2  6 
bind off  ………………………………………………………………………………………………………………………………………….  sts  5  5  5  6  6 
at beg. of each of next …………………………………………………………………………………………………………………….   rows  8  6  2  8  4 
Bind off for back of neck remaining ………………………………….…………………………………………………………….   sts  36  40  44  46  50 
LEFT FRONT ‐ Cast on for lower edge ………………………………………………………………………………………………  sts  65  69  73  75  79 
Ribbing ‐ Row 1 ‐ wrong side‐k 1, * p 1, k 1 twist st; repeat from * to end.              
Row 2 ‐ p 1, * k 1 twist st, p1; repeat from * to end.              
FOR WOMAN'S CARDIGAN ‐ Repeat rows 1 and 2 of ribbing until 10 rows from beg., end on right             
side. 
FOR  MAN'S  CARDIGAN  ‐  Repeat  rows  1  and  2  of  ribbing  until  5  rows  from  beg.,  end  on  wrong             
side. 
Buttonhole rows ‐ Row 1 ‐ Work to within 6 sts of end, bind off 3 sts for buttonhole, finish row.              
Row 2 ‐ Work across, casting on 3 sts over buttonhole. Continue ribbing until 10 rows from beg.,             
end on right side. 
FOR WOMAN'S OR MAN'S CARDIGAN ‐ Inc. row ‐ wrong side ‐ Continue ribbing,              
increasing ……………………………………………………………………………………………………………………………………….  sts  4  4  3  4  4 
evenly spaced across row ……………………………………………………………………………………………………………….  sts  69  73  76  79  83 
Next row ‐ k to within 9 sts of end, work ribbing on remaining 9 sts for border. On following row,             
work  ribbing  on  first  9  sts,  p  to  end.  Continue  in  stockinette  st,  working  9  sts  at  front  edge  in 
ribbing (repeating buttonhole rows on Man's cardigan every 23rd and 24th row twice). Work until 
6½ ins. from beg., end on wrong side: 
Front  dec.  row  ‐  k  to  within  11  sts  of  end,  k  2  tog.,  work  ribbing  to  end.  Repeat  front  dec.  row             
every 6th row until same length as back to armholes, end on wrong side. 
Armhole‐Cast on 7 sts at beg. of row for border, * p1, k 1 twist st; repeat from * twice, p 1, finish              
row. Work ribbed border and shape armhole as for right armhole of back, at the same time,              
continue to dec. 1 st at inner edge of front border every 6th row until …………………………………………..  sts  20  21  22  23  25 
in all have been decreased at front edge.              
When armhole measures (above 7 sts cast on for armhole border) ………………………………………………..  ins.  8 ½  9  9½  10  10 ½
shape shoulder as follows: Bind off …………………………………………………………………………………………………  sts  6  6  6  7  7 
from armhole edge every 2nd row ………………………………………………………………………………………………….  times  1  2  4  1  3 
bind off ……………………………………………………………………………………………………………………………………………   sts  5  5  5  6  6 
from armhole edge every 2nd row ………………………………………………………………………………………………….  times  4  3  1  4  2 
             
(Continued on Page 39) 

Digital Restoration © 2009 Purple Kitty LLC 6


Digital Restoration © 2009 Purple Kitty LLC 7
Style No. 124 
Sizes 12 ‐ 14 and 16 ‐ 18. 
Instructions are for size 12‐14, changes for size 16‐18 are in parentheses, see body measurement chart, page 3. 
 
    Size 12‐14   Size 16‐18  
MATERIALS: BOTANY SCOTTIE "SHETLAND AND WOOL", 2 oz. skeins   10 skeins  12 skeins 
  
KNITTING NEEDLES: "Boye" Nylon Circular Needle, Size 7  
‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW. 
1 pair "Boye" Aluminium Needles, Size 3 for facing.  
 
GAUGE: Size 7 Needles ‐  
  6 sts = 1 inch   8 rounds or rows = 1 inch  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
Skirt ‐   Width at lower edge   inches   49   53½  
  Width at hipline, 7 ins. below waistline          inches     39½     44¼  
  At waistline   inches   30¼  35  
Waist ‐   Width at bust line   inches   37   41¼ 
  Width of back at underarm   inches   18½   20½  
 
Instructions  are  for  skirt  28  ins.  in  length.  Make  any  necessary  (110) sts. Work even in pat. until 43 rows or about 5½ ins. above first 
adjustment in length evenly divided before first 4 dec. rounds.   armhole dec. row, end on right side with pat. row 7.  
SKIRT  ‐  Cast  on  294  (322)  sts.  Join  with  care  not  to  twist  sts  on  Next row ‐ Work first 23 (26) sts for left half of back, slip next 52 (58) 
needle.   sts to holder for neck edge and the following 23 (26) sts to separate 
Pattern ‐ Round 1 ‐ right side ‐* p 5 (6), k 5, p 5 (6), k 6; repeat from  holder for right half of back.  
* 13 times. Mark end of round.   Left  Half  ‐  Work  even  in  pat.  on  first  23  (26)  sts  until  about  7½  (8) 
Round 2 ‐ * p 6 (7), k 1, p 1, k 1, p 6 (7), k 6; repeat from * to end.   ins. above first dec. row at armhole, end on right side. Bind off 3 (6) 
Carry up marker. Repeat rounds 1 and 2 twice more; 14 pat. stripes.   sts at beg. of next row for shoulder, then bind off 4 sts from armhole 
Round 7 ‐ Cable Twist ‐ * p 5 (6), k 5, p 5 (6), slip next 3 sts to hook,  edge every 2nd row 5 times more. Beg. at neck edge, finish right half 
hold sts in back of work, k next 3 sts, k 3 sts from hook; repeat from  to correspond.  
* to end.   FRONT ‐ Take up the 106 (120) sts. Beg. on right side, inc. same as 
Round 8 ‐ Same as round 2.   for  back;  112  (120)  sts.  Work  front  same  as  back  but  dec.  7  sts  at 
Repeat rounds 1 and 2 once more. Repeat these 10 rounds for pat.  armhole edge instead of 6 sts; 98 (110) sts. Finish to correspond to 
Work  even  in  pat.  until  about  9  ins.  from  beg.,  always  end with  an  back.  Block  to  given  measurements,  stretching  skirt  1  in.  in  length, 
even numbered pat. round before a dec. round.   see page 3.  
First dec. round ‐ * P 1 (2), P 2 tog., P 2, k 5, p 1 (2), P 2 tog., P 2, k 6;  NECK FACING ‐ From right side, slip the 52 (58) sts of back neck edge 
repeat from * to end; 266 (294) sts. Continue pat. with only 4 (5) sts  to size 3 needle, with free needle, beg. at right shoulder of back, pick 
in p stripe instead of 5 (6) sts until 17 ins. from beg.   up and k 24 (27) sts on side of neck edge, place a marker after last 
2nd dec. round ‐ p 1, p 2 tog., p 1 (2) in each of the 28 p stripes; 238  st, k 8 (11), * k 2 tog., k2, k 2 tog., k 9; repeat from" twice more, end 
(266) sts. Work even in pat. having 3 (4) sts in each p stripe until 22  last repeat k 8 (11) instead of k 9; place another marker before next 
ins. from beg.   st, pick up and k 24 (27) sts on other side of neck edge; 94 (106) sts, 
3rd dec. round ‐ P 0 (1), p 2 tog., p 1 in each of the 28 p stripes; 210  turn.  
(238) sts. Work even in pat. having 2 (3) sts in each p stripe until 25  Row 1 ‐ From wrong side, k 1 row inserting needle in back of sts for 
ins. from beg. or 3 ins. less than desired blocked length.   turning ridge.  
4th dec. round ‐ * p 2 tog., p 0 (1) in every p stripe; 182 (210) sts.   First  inc.  row  ‐ right  side  ‐  *  k  to  within  1  st  of  marker,  inc.  1 st  in 
Work even in pat. with 1  (2) sts in every p stripe until 27 ins.  from  each of the next 2 sts; repeat from * once, k to end.  
beg. end with pat. round 4. Mark for waistline.   Next row – P.  
WAIST  ‐  Continue  in  pat.  until  2  ins.  above  marker,  end  with  pat.  2nd inc. row ‐ * k to within 1 st of marker, inc. 1 st in each of next 2 
round 10.   sts; repeat from * once, k to end.  
First inc. round ‐ Inc. 1 st in every p stripe; 210 (238) sts. Work even  Repeat last 2 rows twice; 110 (122) sts. Bind off as to p.  
with  2  (3)  p  sts  in  every  p  stripe  until  about  4  ins.  above  waist  Work Front neck facing to correspond. Sew shoulder seams. Steam 
marker, end with pat. round 6.   seams.  
Divide for Back and Front ‐ Work first 5 sts of next row, slip the last  From right side, beg. at underarm edge, with size 3 needles, pick up 
106 (120) sts worked to holder for front.   and k 92 (98) sts around armhole edge.  
BACK ‐ On remaining 104 (118) sts work as follows: Inc. 1 st in first  Turn.  
st,  work  pat.  as  for  pat.  round  7,  inc.  1  st  in  last  st;  106  (120)  sts,  K 1 row inserting needle in back of sts for turning ridge. K 1 row, p 1 
turn.  Working  back  and  forth  on  circular  needle,  continue  pat.  row for 6 rows. Bind off as to p. Work other armhole to correspond.  
increasing  1  st  each  side  every  8th  row  twice  more;  110  (124)  sts.  FINISHING  ‐  Sew  underarm  seams.  Turn  up  hems  at  neck  and 
With care to keep pat., work even until about 7½ ins. above marker,  armhole  edges  along  turning  ridge  and  sew  on  wrong  side.  Steam 
end with pat. row 4.   neck and armhole facings, also side seams. From right side, work 1 
Armhole Shaping  ‐ Continuing pat., dec. 1 st each side on next row  row sc on lower edge of skirt. Work casing for elastic, see page 3.  
for  underarm.  Repeat  decs.  every  2nd  row  5  (6)  times  more;  98 

Digital Restoration © 2009 Purple Kitty LLC 8


Digital Restoration © 2009 Purple Kitty LLC 9
Style No. 129 
Sizes 34, 36, 38. 
Instructions are for size 34, changes for sizes 36 and 38 are in parentheses, see body measurement chart, page 3. 
 
   
MATERIALS: BOTANY CLASSIC SPORT, 1 oz. skeins.   Size 34   Size 36   Size 38  
  Black, Color A     12 skeins        12 skeins     13 skeins  
  White, Color B   7 skeins          7 skeins          8 skeins  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 3 –  
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 1 for facings and Collar and Cuff ribbing.  
 
GAUGE: Pattern ‐ Size 3 Needles  
  15 sts = 2 inches   17 rows = 2 inches  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
At bustline   inches   36   38 ½    40 ½  
Width of back at underarm   inches   18   19 ¼  20 ¼  
 
 
BACK ‐ With size 1 needles and A, cast on 135 (144‐153) sts for  Dec.  row  ‐  With  size  1  needles  and  A,  k  1  row  decreasing  14 
facing. P 1 row, k 1 row for 12 rows. K 1 row from wrong side,  (19‐24) sts evenly spaced across row; 64 (68‐72) sts.  
inserting  needle  in  back  of  sts  for  turning  ridge.  With  size  3  Cuff Ribbing ‐ Work k 1, p 1 ribbing for 4 ins. Bind off in ribbing.  
needles, beg. with row 1 on chart, k 1 row, p 1 row for 4 rows.   FRONT HALF OF COLLAR ‐ With size 1 needles and A, from right 
NOTE:  Carry  color  not  being  used  loosely  along  on  wrong side  side, beg. at left shoulder seam, pick up and k 30 (32‐34) sts on 
of work keeping work flat.   side edge of neck, pick up and k 22 sts on bound‐off sts of neck, 
Row 5 ‐ * K 3 A, 3 B, 3 A; repeat from * to end.   pick up and k 30 (32‐34) sts to right shoulder seam; 82 (86‐90) 
Row 6 ‐ * P 1 B, 1 A, 5 B, 1 A, 1 B; repeat from * to end.   sts.  Work  k  1,  P  1  ribbing  for  4  ins.  Bind  off  in  ribbing.  Work 
NOTE:  Carry  B  when  not  in  use  loosely  along  edge  of  work  back half of collar in same way.  
between stripes. Continue pat. following chart until about 16½   FINISHING ‐ Sew seams, matching pat. stripes. Sew side seams 
ins. above turning ridge, end with pat. row 6. Mark for under‐ on collar. Turn under facing on lower edge and hem on wrong 
arm.   side. Block, see page 3.  
Armholes  ‐  Bind  off  9  sts  at  beg.  of  each  of  next  2  rows;  117   
(126‐135)  sts.  Work  even  until  about  6  (6  ¼‐6½)  ins.  above 
marker, end with pat. row 6 (8‐10).  
Divide for Neck ‐ Work 48 (52‐56) sts, place on holder for right 
side, bind off 21 (22‐23) sts for neck, finish row; 48 (52‐56) sts. 
Continue  pat.,  decreasing  1  st  at  neck  edge  every  2nd  row  9 
(10‐10) times, with care to keep pat.; 39 (42‐46) sts. Work even 
until  8½  (9‐9½)  ins.  above  marker,  end  at  armhole  edge.  Bind 
off.  Take  up  sts  of  right  side  and  finish  to  correspond  to  left 
side.  
FRONT ‐ With size 1 needles and A, cast on 135 (144‐153) sts. 
Work same as for back. Sew shoulder seams.  
SLEEVES  ‐  With  size  3  needles  and  A,  pick  up  and  k  126  (135‐
144) sts evenly spaced around armhole edge‐this row counts as 
row 1 of pat. Continue pat., following chart until 24 rows from 
beg.  including  picked  up  row.  Dec.  1  st  each  side  of  next  row. 
With  care  to  keep  pat.,  repeat  decs.  every  4th  row  16  times; 
every  6th  row  7  times;  78  (87‐96)  sts.  Work  even  until  about 
16½  ins. from beg., end with pat. row 4. Break off B. 
 

Digital Restoration © 2009 Purple Kitty LLC 10


Digital Restoration © 2009 Purple Kitty LLC 11
Style No. 132  
Sizes 12‐14 and 16‐18. 
Instructions are for size 12‐14, changes for size 16‐18 are in parentheses, see body measurement chart page 3. 
      
  Size 12‐14   Size 16‐18  
MATERIALS: BOTANY KWILTEE, 2 oz. skeins.   15 skeins  17 skeins  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 10 ½ ‐  
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 5 for ribbing.  
 
GAUGE: Pattern ‐ Size 10 ½ Needles‐  
  9 sts = 2 inches   6 rows = 1 inch  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
Width at bust line, buttoned   inches   39   43  
Width of back at underarm   inches   18   19  
 
 
BACK  ‐  With  size  5  needles,  cast  on  80  (86)  sts.  Work  k  1,  P  1  RIGHT FRONT ‐ With size 5 needles, cast on 59 (65) sts.  
ribbing for 2 ½  ins.   Row 1 ‐ wrong side ‐ Work k 1, p 1 ribbing to within 15 sts of 
Pattern  ‐  Row  1  ‐  wrong  side  ‐  With  size  10  ½  needles,  p  1,  *  end, p 15.  
with  yarn  in  front,  slip  1  as  to  p,  p  5;  repeat  from  *,  end  last  Row  2  ‐  K  7  for  facing,  with  yarn  at  back,  slip  1  as  to  p  for 
repeat p 6.   turning st, k 7 for border, work ribbing to end. Repeat these 2 
Row 2 ‐ K 1, * k 3, knitting in front loop of sts, k 3rd st on left  rows until 7 rows from beg., end at front edge.  
needle,  do  not  slip  from  needle,  k  first  st,  do  not  slip  from  Buttonhole rows ‐ K 2, bind off 2 sts, work until 7 sts from bind‐
needle, k 2nd st, slip all 3 sts from needle; repeat from *, end k  off,  bind  off  2  sts,  finish  row.  On  next  row,  cast  on  2  sts  over 
last st.   each buttonhole.  
Row 3 ‐ P 1, * P 5, with yarn in front, slip 1 as to p; repeat from  Work  right  front  to  correspond  to  left  front,  repeating 
*, end p 1.   buttonholes  opposite  markers,  shaping  at  opposite  sides.  Sew 
Row 4 ‐ K 1, * inserting needle in back loop of sts, k 2nd st on  shoulder seams.  
left needle, do not slip from needle, k 3rd st, do not slip from  HOOD  ‐  With  size  10½    needles,  take  up  21  sts  of  right  front, 
needle,  k  first  st  from  front,  slip  all  3  sts  from  needle,  k  3;  join yarn, from right side pick up and k 18 sts on right neck edge 
repeat from *, end last repeat k 4.   to shoulder seam, take up 24 (26) sts of back and k, increasing 2 
Repeat  these  4  rows  for  pat.  Work  even  in  pat.  until  12  ins.  (0) sts, pick up and k 18 sts on left neck edge, take up 21 sts of 
above ribbing. Mark for underarm.   left front and k 13, slip 1, k 7; 104 sts.  
Armholes ‐ Bind off 6 sts at beg. of each of next 2 rows; 68 (74)  Row 1 ‐ wrong side ‐ P 15, place marker on needle, work as for 
sts. Work even until 7½  (8) ins. above marker.   pat.  row  1  on  back  to  within  15  sts  of  end,  place  marker  on 
Shoulder Shaping ‐ Bind off 11 (12) sts at beg. of each of next 4  needle, p 15.  
rows. Place 24 (26) sts on holder for back of hood.   Row 2 ‐ K 7, slip 1 as before, k 7, work as for pat. row 2 to next 
LEFT FRONT ‐ With size 5 needles, cast on 59 (65) sts.   marker, k 7, slip 1, k 7. Continue pat. on 74 center sts working 
Row 1 ‐ wrong side ‐ P 15, work k 1, p 1 ribbing to end.   borders  and  facing  each  side  for  front  of  hood  until  12  ins. 
Row  2  ‐  Work  ribbing  to  within  15  sts  of  end,  k  7  for  border,  above picked up row, end on right side. Work 52 sts of next row 
with yarn at back, slip 1 as to p for turning st, k 7 for facing.   and slip on size 5 needle, with size 10½ needle finish row. Break 
Repeat  last  2  rows  until  2½    ins.  from  beg.,  end  on  right  side.  off leaving an end for weaving. Weave sts tog., see page 47.  
With size 10½  needles, p 15 for facing and border, work as for  SLEEVES ‐ With size 5 needles, cast on 46 (50) sts. Work k 1, p 1 
pat. row 1 to end. Continue pat., working 15 sts at front edge  ribbing for 2½  ins. increasing 10 (12) sts evenly spaced across 
for  border  and  facing  as  before,  until  same  length  as  back  to  last  row;  56  (62)  sts.  With  size  10½    needles,  work  pat.  as  for 
armhole,  end  on  wrong  side‐underarm  edge.  Mark  for  back increasing 1 st each side every 2 ins. 6 times, with care to 
underarm.   carry  out  pat.  on  added  sts;  68  (74)  sts.  Work  even  until  14½ 
Armhole ‐ Bind off 12 sts at beg. of next row; 47 (53) sts. Work  ins. above ribbing. Place marker each side for end of sleeve and 
even until 6½  ins. above marker, end on right side‐front edge.   beg. of underarm. Work even for 2 ins. Bind off.  
Neck and Shoulder Shaping ‐ Work 21 sts, place on holder for  FINISHING  ‐  Sew  seams,  sewing  sleeve  seam  from  lower  edge 
hood,  finish  row.  Continue  pat.  decreasing  1  st  at  neck  edge  to underarm marker, leaving last 2 ins. free. Sew in sleeves with 
every  row  4  (8)  times,  shaping  shoulder  same  as  right  side  of  sleeve  seam  at  center  underarm,  sewing  2  ins.  left  free  to 
back when armhole is same length.   bound‐off  sts.  Turn  back  front  and  hood  facings  and  hem  On 
Mark  position  of  6  buttons  evenly  spaced  on  front  border,  wrong side. Finish buttonholes in blanket st. Block, see page 3. 
having first button 8 rows from lower edge and 6th button 1 ½ 
ins. below neck edge.  

Digital Restoration © 2009 Purple Kitty LLC 12


Digital Restoration © 2009 Purple Kitty LLC 13
Style No. 136  
Sizes 38, 40, 42. 
Instructions are for size 38, changes for sizes 40 and 42 are in parentheses, see body measurement chart, page 3. 
      
  Size 38   Size 40   Size 42  
MATERIALS: BOTANY KWILTEE, 2 oz. skeins.   12 skeins   12 skeins   13 skeins  
 

KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 10 – 
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 8.  
 

GAUGE: 4 sts = 1 inch To check gauge, see page 3.  
 

MEASUREMENTS FOR BLOCKING:  
At chest   inches   38   40   42  
Width of back at underarm   inches   19   20   21  
 
BACK ‐ With size 8 needles, cast on 76 (80‐84) sts.   times, shaping shoulder as for left side of back when armhole is 
Row 1 ‐ wrong side‐* K 2, P 2; repeat from * to end.   same length. Take up sts of left side.  
Repeat this row for ribbing. Work even in ribbing until 3 ¾  ins.  NOTE: To dec., p 2 tog. at beg. of p rows and slip, k and pass at 
from  beg.,  end  on  right  side.  With  size  10  needles,  work  end of k rows.  
stockinette  st‐p  1  row,  k  1  row‐until  11½    ins.  above  ribbing,  Beg. at neck edge, finish left side to correspond to right side. Do 
end with k row. Mark for underarm.   not break yarn.  
Armholes ‐ Bind off 4 sts at beg. of each of next 2 rows; 68 (72‐ FRONT  NECK  RIBBING  ‐  With  size  8  needles,  pick  up  and  k  16 
76) sts. P1 row.   sts on left side of neck, take up and k 18 sts, pick up and k 16 sts 
Dec. row ‐ K 2 tog., k to within 2 sts of end, slip, k and pass; 66  on right side; 50 sts.  
(70‐74)  sts.  Repeat  last  2  rows  3  times;  60  (64‐68)  sts.  Work  Row  1  ‐  wrong  side  ‐  Same  as  row  2  of  back  neck  ribbing, 
even until 8½  (9‐9½) ins. above marker, end with k row.  continue  ribbing  until  same  number  of  rows  as  on  back  neck 
Shoulders ‐ Bind off 5 sts at beg. of each of next 2 rows; 5 (6‐7)  ribbing. Bind off loosely in ribbing.  
sts at beg. of each of next 4 rows; 30 sts.   SLEEVES ‐ With size 8 needles, cast on 40 (44‐48) sts. Work k 2, 
Back Neck Ribbing ‐ Row 1 ‐ wrong side ‐ With size 8 needles, k  p 2 ribbing for 4 ins.  
2, * P 2, k 2; repeat from * to end.   With size 10 needles, k 1 row, p 1 row for 8 rows.  
Row 2 ‐ P 2, * k 2, p 2; repeat from * to end.   Inc. row ‐ Inc. 1 st in first st, k to within 2 sts of end, inc. 1 st in 
Repeat these 2 rows until there are 8 rows. Bind off loosely in  next  st,  k  1;  42  (46‐50)  sts.  Continue  stockinette  st  repeating 
ribbing.   inc. row every 10th row 8 times; 58 (62‐66) sts. Work even until 
FRONT  ‐  Work  same  as  back  until  6  ¼  (6  ¾‐7  ¼)  ins.  above  17 ins. above ribbing, end with k row. Bind off 4 sts at beg. of 
marker, end with p row; 60 (64‐68) sts.   each  of  next  2  rows;  2  sts  at  beg.  of  each  of  next  16  (18‐20) 
Divide for Neck ‐ K 21 (23‐25) sts, place on holder for left side, k  rows. Bind off 18 sts. 
18, place on holder for neck, k to end; 21 (23‐25) sts.   FINISHING ‐ Sew seams. Sew in sleeves with seam at underarm 
NOTE: To dec., p 2 tog. at end of p rows and k 2 tog. at beg. of k  seam. Block, see page 3. 
rows. Dec. 1 st at neck edge every row 3 times; every 2nd row 3   
 
Style No. 141 
Sizes 34‐36 and 40‐42. 
Instructions are for size 34‐36, changes for size 40‐42 are in parentheses, see body measurement chart, page 3. 
 
  Size 34‐36   Size 40‐42  
MATERIALS: BOTANY "WATER‐REPELLENT" SKI and SEA YARN, 2 oz. skeins.   11 skeins   16 skeins  
 

KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 8 – 
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW. 
1 pair "Boye" Non‐Inflammable Needles, Size 4.  
 

GAUGE: Size 8 Needles –  
11 sts = 2 inches   7 rows = 1 inch  
To check gauge, see page 3.  
 

MEASUREMENTS FOR BLOCKING:  
Width at chest   inches   39 ½    44  
Width of back at underarm   inches   19 ¾    22  
Width of sleeves at underarm   inches   16 ¼    18  
 
BACK ‐ With size 4 needles, cast on 108 (120) sts. Work k 1, p 1  work 5 sts in next st by knitting in front, back, front, back and 
ribbing  for  3  ½  (4)  ins.,  increasing  1  st  at  end  of  last  row;  109  front of next st; k 2, p 2, k 1, p 2, k 2, work 5 sts in next st as 
(121) sts.   before, k 3, p 1, place 2nd marker on needle for end of panel, 
Pattern ‐ Row 1 ‐ wrong side ‐ With size 8 needles, work k 1, p 1  work  k  1,  p  1  for  5  sts  for  seed  st;  repeat  between  *'s  once, 
for 11 (15) sts for seed st; * p 1, k 1, p 8, k 1, p 1, k 1, p 3 (5), k  work k 1, p 1, for seed st to end.  
1,  p  1,  k  1,  p  8,  k  1,  p  1  *,  k  1,  p  1  for  5  sts  for  seed  st,  place  (Continued on Page 38)  
marker  on  needle  for  beg.  of  center  panel  of  19  sts,  p  1,  k  3, 

Digital Restoration © 2009 Purple Kitty LLC 14


Digital Restoration © 2009 Purple Kitty LLC 15
Style No. 134  
Sizes 12, 14, 16. 
Instructions are for size 12, changes for sizes 14 and 16 are in parentheses, see body measurement chart, page 3. 
      
  Size 12   Size 14   Size 16 
MATERIALS: BOTANY KWILTEE, 2 oz. skeins.   12 skeins  13 skeins   14 skeins  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 10 ½ ‐  
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 8.  
"Boye" Non‐Inflammable Hook, Size J.  
 
GAUGE: Size 10 ½   Needles ‐ 4 sts = 1 inch 11 rows = 2 inches  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
At bust line, buttoned   inches   37 ¾    39¾   41¾  
Width of back at underarm   inches   18 ¼    19¼   20¼  
Width of sleeves  underarm   inches   15 ¾   16 ¾   17¾ 
 
BACK ‐ With size 8 needles, cast on 73 (77‐81) sts.   Buttonhole rows ‐ K 1, p 1, bind off 3 sts, work to end. On next 
Row 1 ‐ wrong side ‐ p 1, * k 1, p 1; repeat from * to end.   row, cast on 3 sts over buttonhole. Work 6 rows more, end on 
Row 2 ‐ K 1, * p 1, k 1; repeat from * to end.   wrong side.  
Repeat  these  2  rows  until  13  rows  from  beg.,  end  on  wrong  Pattern‐Row 1‐right side‐With size 10 ½ needles, work 8 sts in 
side.   ribbing for front border, place marker on needle, p 1, * k 1, p 1; 
Pattern‐Row 1 ‐ right side ‐ With size 10 ½  needles, p 1, * k 1, p  repeat from * to end. Carry up marker.  
1; repeat from * to end.   Row 2 ‐ K 1, * p 1, k 1; repeat from * to marker, work 8 sts in 
Row 2 ‐ K 1, * p 1, k 1; repeat from * to end.   ribbing.  
Row 3 ‐ K 1, * p 1, k 1; repeat from * to end.   Row 3 ‐ Work 8 sts, k 1, * p 1, k 1; repeat from * to end.  
Row 4 ‐ P 1, * k 1, p 1; repeat from * to end.   Row 4 ‐ P 1, * k 1, p 1; repeat from * to marker, work 8 sts in 
Repeat these 4 rows until about 13 ins. above ribbing, end with  ribbing.  Repeat  these  4  rows  until  4  ins.  above  ribbing, 
pat. row 3. Mark for underarm.   repeating buttonhole opposite marker, end with pat. row 2.  
Raglan Shaping ‐ Bind off 3∙ sts at beg. of each of next 2 rows.   Pocket  Opening  ‐  Work  14  (16‐18)  sts,  work  next  23  sts  and 
Next row‐P 1, * k 1, p 1; repeat from * to end.   place  on  holder  for  pocket  border,  work  6  sts.  Work  to 
Dec. row ‐ K 1, slip, k and pass, k 1, * p 1, k 1; repeat from * to  correspond  to  left  front  up  to  armhole,  repeating  buttonhole 
within 3 sts of end, k 2 tog., k 1. Repeat last 2 rows 24 (26‐28)  opposite markers, end with pat. row 3 at underarm edge. Mark 
times; 17 sts. Place sts on holder for collar. Break yarn.   for underarm.  
POCKET LININGS  ‐ With size 10 ½  needles, cast on 23 sts. Work  Raglan Shaping ‐ Bind off 3 sts at beg. of next row. Work 2 rows 
pat.  for  4 ins.,  end  with  pat.  row  3.  Place  sts  on  holder.  Break  even.  Continue  raglan  shaping  same  as  on  left  side  of  back, 
yarn. Make 2.   repeating buttonholes opposite markers, end on right side with 
LEFT FRONT ‐ With size 8 needles, cast on 43 (45‐47) sts. Work  a dec. row. Place 15 sts on holder for collar. Break yarn.  
ribbing as on back for 13 rows, end at underarm edge.   SLEEVES  ‐  With  size  8  needles,  cast  on  37  (39‐41)  sts.  Work 
Pattern ‐ Row 1 ‐ right side ‐ With size 10 ½  needles, p 1, * k 1,  ribbing as on back for 3 ½  ins., end with row 1. With size 10 ½ 
p  1;  repeat  from  *  to  within  8  sts  of  end,  place  marker  on  needles, work pat. as on back, increasing 1 st each side every 1 
needle, work 8 sts in ribbing for front border. Carry up marker.   in. 9 (10‐11) times with care to carry out pat. on added sts; 55 
Row 2 ‐ Work 8 sts in ribbing, k 1, * p 1, k 1; repeat from * to  (59‐63) sts. Work even until 12 ins. above ribbing, end with pat. 
end.   row 2, Inc. 1 st each side of next row and repeat incs. every 2nd 
Row 3 ‐ K 1, * p 1, k 1; repeat from * to marker, work 8 sts in  row  3  times;  63  (67‐71)  sts.  Work  2  rows  even,  end  with  pat. 
ribbing.   row 3.  
Row 4 ‐ Work 8 sts in ribbing, p 1, * k 1, p1; repeat from * to  Raglan Shaping ‐ Work same as on back. Place remaining 7 sts 
end.   on holder for collar. Break yarn.  
Repeat  these  4  rows  until  4  ins.  above  ribbing,  end  with  pat.  COLLAR ‐ With size 10 ½  needles, take up 15 sts of right front, 7 
row 2.   sleeve  sts,  17  back  sts,  7  sleeve  sts  and  15  sts  of  left  front, 
Pocket Opening ‐ Work 6 sts, work 23 sts and place on holder  having right side of each part toward you; 61 sts. Mark for beg. 
for pocket border, work 14 (16‐18) sts.   of collar. Work 14 sts, p 2 tog., work 5 sts, p 2 tog., work 15 sts, 
Next  row  ‐  Work  14  (16‐18)  sts,  take  up  and  work  23  sts  of  p 2 tog., work 5 sts, p 2 tog., work 14 sts; 57 sts.  
pocket lining, work 6 sts. Work even until same length as back  Pat. row 1 ‐ Work 8 sts in ribbing, p 1, * k 1, p 1; repeat from * 
to underarm, end with p at. row 4.   to within 8 sts of end, work 8 sts in ribbing. Continue pat. until 
Raglan  Shaping  ‐  Work  same  as  on  right  side  of  back,  end  at  5  ½  ins.  from  beg.  of  collar,  end  with  pat.  row  2.  Begin  collar 
front edge; 15 sts. Place sts on holder for collar. Do not break  border. Remove markers.  
yarn.   Row 1 ‐ K 1, * p 1, k 1; repeat from * to end.  
Mark  position  of  6  buttons  on  front  border  3  ½    ins.  apart,  Row 2 ‐ P 1, * k 1, p 1; repeat from * to end.  
having first button 6 rows from lower edge.   Repeat these 2 rows 4 times. Bind off in ribbing.  
RIGHT  FRONT  ‐  With  size  8  needles,  cast  on  43  (45‐47)  sts.   
Work ribbing as on back for 5 rows, end at front edge.   (Continued on Next Page)

Digital Restoration © 2009 Purple Kitty LLC 16


 
 
 
 
Style No 134 
(Continued from Page 16) 
 
POCKET BORDERS ‐ With size 8 needles, take up 23 sts of  ends of pocket borders to right side of fronts. Join yarn on 
left  pocket.  Join  yarn  and  work  ribbing  as  on  lower  edge  lower  right  front  edge,  work  1  row  sc  to  edge  of  collar, 
for  7  rows.  Bind  off  in  ribbing.  Work  right  border  to  working  1  sc  in  every  2nd  row,  keeping  work  flat.  Fasten 
correspond.   off. Join yarn on left front at collar edge and work 1 row sc 
FINISHING ‐ Sew raglan seams. Sew underarm and sleeve  to  lower  edge.  Fasten  off.  Work  buttonholes  in  blanket 
seams.  Sew  pocket  linings  to  wrong  side  of  fronts.  Sew  stitch. Block, see page 3. 
 
 

Digital Restoration © 2009 Purple Kitty LLC 17


Style No. 135  
Sizes 12, 14, 16. 
Instructions are for size 12, changes for sizes 14 and 16 are in parentheses, see body measurement chart, page 3. 
      
  Size 12       Size 14   Size 16 
MATERIALS: BOTANY KWILTEE, 2 oz. skeins   18 skeins  19 skeins   21 skeins  
and BUCILLA PURE SILK TWEED, 400 yd. tubes  8 tubes   10 tubes   10 tubes  
BUCILLA 100% IMPORTED FRENCH ANGORA,  
  Collar Facing   3 balls       3 balls   4 balls 
  Cuff Linings   2 balls       2 balls   3 balls  
 
KNITTING NEEDLES: 1 pair "Boye" 14‐inch Non‐Inflammable Needles,  
Size 10 ‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" 14‐inch Non‐Inflammable Needles,  
Size 8 for hems and Angora collar and cuffs.  
Note: If desired, coat may be made with Kwiltee only omitting Silk Tweed 
and using 1 pair "Boye" 14‐inch Non‐Inflammable Needles, Size 10 ½ ‐ 
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" 14‐inch Non‐Inflammable Needles,  
Size 8 for hems and Angora collar and cuffs.  
 
GAUGE: 4 sts = 1 inch  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
At bustline, buttoned   inches   42¾      44¾   46¾  
Width of back at underarm   inches   21¼   22¼           23¼   
Width of sleeve at underarm   inches   14½    15   16  
 
Use 1 strand of yarn and 2 strands of Silk Tweed for entire coat.   Shoulder‐Bind  off  4  (5‐6)  sts  at  beg.  of  next  row,  finish  row. 
BACK  ‐  With  smaller  size  needles,  cast  on  85  (89‐93)  sts  for  Bind off 5 sts from armhole edge every 2nd row 3 times.  
facing of hem. P 1 row, k 1 row for 8 rows for facing.   LEFT  FRONT‐With  smaller  size  needles,  cast  on  51  (53‐55)  sts. 
Turning  ridge‐K  on  wrong  side  inserting  needle  into  back  of  Work  facing  as  on  back  for  8  rows,  end  at  front  edge  with  k 
each st. With larger size needles, k 1 row, p 1 row and continue  row; cast on 5 sts at end of row.  
in  stockinette  st  until  22  ins.  above  turning  ridge.  Mark  for  Turning  ridge‐K  5  cast‐on  sts,  k  to  end  inserting  needle  into 
underarm.   back of sts. With larger size needles, k 1 row.  
Armholes‐Bind off 3 (4‐5) sts at beg. of each of next 2 rows; 2  Next row‐K 2 for facing, p to end. Work to correspond to right 
sts at beg. of each of next 8 rows. Dec. 1 st each side every 2nd  front up to pocket opening, end at underarm edge with p row.  
row 3 times; 57 (59‐61) sts. Work even until 8 (8‐8 ¼) ins. above  Divide for Pocket Opening‐K 30 (31‐32), slip last 27 sts worked 
marker.   to holder for pocket opening, k to end.  
Shoulders‐Bind off 4 (5‐6) sts at beg. of each of next 2 rows; 5  Next row‐K 2, p 24 (25‐26), take up and p across sts of pocket 
sts at beg. of each of next 6 rows. Bind off 19 sts.   lining, p to end.  
Pocket  Linings‐With  larger  size  needles,  cast  on  27  sts.  Work  Continue  to  correspond  to  right  front  until  1  row  more  than 
stockinette st for 7 ¼ ins., end with k row; break off. Place sts  right front to armhole, end with p row. Mark for underarm.  
on holder. Make 2.   Armhole‐Bind off 3 (4‐5) sts for underarm, finish row. Bind off 2 
RIGHT FRONT‐With smaller size needles, cast on 51 (53‐55) sts  sts from armhole edge every 2nd row twice. Work 1 row even, 
for  facing  of  hem.  Work  facing  and  turning  ridge  as  on  back,  end at armhole edge.  
end at front edge. With extra yarn, cast on 5 sts to free needle,  Neck‐Bind off 2 sts, work to within 23 sts of end, bind off last 23 
k these sts to same needle as sts of front; 56 (58‐60) sts. With  sts  for  neck.  Join  yarn  in  last  st  on  needle  and  finish  to 
larger size needles, k 1 row.   correspond to right front.  
Next  row‐P  to  within  2  sts  of  end,  k  2  for  garter  st  facing  of  SLEEVES‐With smaller size needles, cast on 44 (46‐50) sts. Work 
front hem. Repeat last 2 rows until 8 ¾ ins. above turning ridge,  facing  of  hem  and  turning  ridge  as  on  back.  With  larger  size 
end with p row.   needles,  work  stockinette  st  increasing  1  st  each  side  every 
Divide for Pocket Opening‐K 53 (54‐55), slip last 27 sts worked  12th  row  7  times;  58  (60‐64)  sts.  Work  even  until  16  ¼  ins. 
to holder for pocket border, k to end.   above turning ridge. Bind off 3 (4‐5) sts at beg. of each of next 2 
Next row‐P 3 (4‐5), take up and p across 27 sts of pocket lining,  rows. Dec. 1 st each side every 2nd row 14 (14‐15) times. Bind 
work  remaining  sts  of  front;  56  (58‐60)  sts.  Work  even  until  off 2 sts at beg. of each of next 4 rows. Bind off 16 sts.  
same  length  as  back  to  armhole,  end  with  k  row.  Mark  for  POCKET  BORDERS‐Beg.  at  underarm  edge  of  left  front  pocket 
underarm.   opening, slip 27 sts from holder to larger size needle.  
Armhole‐Bind off 3 (4‐5) sts for underarm, finish row. Bind off 2  Row 1‐wrong side‐K 1, * p 1, k 1; repeat from * to end.  
sts  from  armhole  edge  every  2nd  row  3  times,  end  at  front  Row 2‐P 1, * k 1, p 1; repeat from * to end.  
edge; 47 (48‐49) sts.   Repeat  these  2  rows  twice  more.  Bind  off  in  ribbing.  Work 
Neck‐Bind off 23 sts at beg. of next row for neck, finish row.   border on right front pocket to correspond. Block, see page 3. 
Next row‐Bind off 2 sts from armhole edge, finish row. Dec. 1 st  Sew shoulder seams.  
at  armhole  edge  every  2nd  row  3  times;  19  (20‐21)  sts.  Work  (Continued on Page 40)
even until armhole is same length as back, end with k row.  

Digital Restoration © 2009 Purple Kitty LLC 18


Digital Restoration © 2009 Purple Kitty LLC 19
Style No. 150  
Sizes 14, 16, 18. 
Instructions are for size 14, changes for sizes 16 and 18 are in parentheses, see body measurement chart, page 3. 
    
  Size 14   Size 16   Size 18  
MATERIALS: BOTANY COLOSSAL, 2 oz. skeins.    11 skeins  12 skeins   13 skeins  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 15 – 
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 13 for ribbing.  
"Boye" Non‐Inflammable Hook, Size J.  
 
GAUGE: Size 15 Needles –  
5 sts = 2 inches   7 rows = 2 inches  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
At bustline, buttoned   inches   36   39   41½  
Width of back at underarm   inches   17   18½   19½  
 
BACK ‐ With size 13 needles, cast on 35 
(39‐41) sts.  
Row  1  ‐  wrong  side‐K  1,  *  p  1,  k  1; 
repeat from * to end.  
Row 2 ‐ P 1, * k 1, p 1; repeat from * to 
end.  
Repeat  these  2  rows  until  9  rows  from 
beg., end with row 1.  
Inc.  row  ‐  K  increasing  8  sts  evenly 
spaced across row; 43 (47‐49) sts. With 
size 15 needles, work stockinette st ‐ p 
1  row,  k  1  row  ‐  until  31  (29‐27)  rows 
including  inc.  row  ‐  about  8½  (8‐7½) 
ins.‐above ribbing, end with k row.  
Raglan Shaping ‐ Bind off 2 (3‐3) sts at 
beg. of each of next 2 rows. P 1 row.  
Dec.  row  ‐  K  1,  slip,  k  and  pass,  k  to 
within 3 sts of end, k 2 tog., k 1; 37 (39‐
41) sts.  
Repeat last 2 rows 13 (14‐15) times; 11 
sts. P 1 row. Place 11 sts on holder for 
neck ribbing. Break yarn.  
RIGHT  FRONT  ‐  With  size  13  needles, 
cast on 23 (25‐27) sts.  
Row  1  ‐  wrong  side  ‐  P  1,  *  k  1,  p  1; 
repeat from * to end.  
Row 2 ‐ K 1, * p 1, k 1; repeat from * to 
end.  
Repeat row 1 once, end at front edge.  
Buttonhole  rows  ‐  K  1,  p  1,  bind  off  1 
st, loosen loop on needle and draw ball 
of  yarn  through  dropping  off  loop, 
binding  off  a  2nd  st,  work  ribbing  to 
end.  Cast  on  2  sts  over  buttonhole  in 
next  row.  Continue  ribbing  for  4  rows 
more, end at front edge.  
Inc.  row  ‐  Work  6  sts  in  ribbing  for 
border, k to end increasing 4 sts evenly 
spaced across row; 27 (29‐31) sts.  
Next  row  ‐  With  size  15  needles,  p  to 
within  6  sts  of  end,  work  ribbing  on  6 
border  sts.  Continue  border  on  6  sts, 
working  stockinette  st  on  21  (23‐25) 
sts,  repeating  buttonholes  every  9th 
and  10th  row  having  8  rows  between 
buttonholes‐about  3  ins.  Work  until 
same  length  as back  to  raglan  shaping, 
end on right side‐underarm edge.  
(Continued on Page 40) 

Digital Restoration © 2009 Purple Kitty LLC 20


Style No. 128 
Sizes 32‐34, 36‐38, 40‐42 
Instructions are for size 32‐34, changes for sizes 36‐38 and 40‐42 are in parentheses, see body measurement chart, page 3. 
 
MATERIALS: BOTANY KNITTING WORSTED, 4 oz. skeins.    Size 32‐34   Size 36‐38  Size 40‐42 
Navy, Color A   4 skeins   4 skeins   4 skeins  
  White, Color B   2 skeins   2 skeins   2 skeins  
  Yellow, Color C   2 skeins   2 skeins   2 skeins  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 6 –  
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW. 
1 pair "Boye" Non‐Inflammable Needles, Size 4 for facings and Collar ribbing.  
 
GAUGE: Size 6 Needles ‐ 11 sts = 2 inches  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
At bustline   inches   37   39   43  
Width of back at underarm   inches   18½    19½   21½ 
 
BACK ‐ With size 4 needles and A, cast   
on 101 (107‐119) sts for facing. P 1 row, 
k  1  row  for  16  rows.  K  1  row  from 
wrong  side,  inserting  needle  in  back  of 
sts for turning ridge. Break A.  
Pattern ‐ Row 1 ‐ right side ‐ With size 6 
needles  and  B,  k  4,  *  carrying  yarn 
loosely at front of work, slip 3 as to p, k 
3;  repeat  from  *,  end  last  repeat  k  4. 
Break B.  
Row 2 ‐ With A, p.  
Row 3 ‐ Knit.  
Row 4 ‐ Purl. Break A.  
Row  5  ‐  With  B,  k  1,  carrying  yarn 
loosely at front of work, slip 3 sts as to 
p,  k  1,  *  insert  right  needle  from  top 
under the B loop in 4th row below and 
slip loop to left needle, inserting needle 
in back of sts, k B loop and next st tog.; 
thus  twisting  the  B  loop,  k  1,  carrying 
yarn loosely at front, slip 3 sts as to p, k 
1  *  ;  repeat  between  *'s  to  end.  Break 
B.  
Rows 6, 7 and 8 ‐ Same as rows 2, 3 and 
4. Break A.  
Row 9 ‐ With B, k 2; repeat between *'s 
of row 5, end last repeat k 2. Break B.  
Repeat  last  8  rows  twice.  Repeat  rows 
2, 3 and 4 once again.  
Row 29 ‐ With C, k 5, * k the B loop in 
4th  row  below  tog.  with  next  st  as 
before,  k  5  *;  repeat  between  *'s  to 
end.  
With  C,  p  1  row,  k  1  row  for  7  rows. 
Break C.  
Row 37 ‐ With A, k. Break A.  
With  B,  p  1  row,  k  1  row  for  8  rows. 
Break B.  
With A, p 1 row. Break A.  
With  C,  k  1  row,  p  1  row  for  8  rows. 
Break  C.  Repeat  these  54 rows for  pat. 
Work even in pat. until about 17 ¼  ins. 
above  turning  ridge,  end  with  pat.  row 
12. Mark for underarm.  
(Continued on Page 38) 
 

Digital Restoration © 2009 Purple Kitty LLC 21


 
 
 
 
Style No. 123 
Instructions are for sizes 12, 14, 16 and 18, see body measurement chart, page 3. 
             
  Sizes   12   14   16   18  
MATERIALS: BOTANY SCOTTIE "SHETLAND AND WOOL" A, 2 oz. skeins.   skeins   7   7   8   8  
  and BUCILLA PURE SILK TWEED B, 400 yd. tubes.      tubes   3   3   4   4  
 
KNITTING NEEDLES: "Boye" Nylon Circular Needle, Size 8  
‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" 14‐inch Non‐Inflammable Needles, Size 5 for ribbing.  
 
GAUGE: Size 8 Needles ‐ 5 sts = 1 inch   7 rows = 1 inch  
To check gauge, see page 3.  
Note: Entire sweater is knitted with 1 strand A and 1 strand B or it can be knitted with A only.  

Digital Restoration © 2009 Purple Kitty LLC 22


Style No 123 (Continued from Page 22) 
 

MEASUREMENTS FOR BLOCKING:  Sizes  12  14  16  18 


          Width at bustline, buttoned  inches  35  37  39  41 
          Width of back at underarm  inches  17  18  19  20 
NECK RIBBING ‐ With size 5 needles and 1 strand each of A and B, cast on …………………………………….  sts  82  82  86  86 
Row 1 ‐ wrong side ‐ P 2, * k 2, p 2; repeat from * to end.            
Row 2 ‐ K 2, * p 2, k 2; repeat from * to end.            
Repeat these 2 rows once‐right front edge.            
Buttonhole rows ‐ P 2, bind off 3 sts, work to end. Cast on 3 sts over buttonhole in next row. Work           
4 rows more in ribbing‐right front edge.           
Raglan Shaping and Short Rows ‐Row 1 ‐ With size 5 needle, p 14 and leave on needle. With           
circular needle, p to within 12 sts of end, leave last 12 sts on straight needle.           
Row 2 ‐ Turn, slip 1, k………………………..……...………………………..……...………………………..……...……………..  sts  2  2  3  3 
* inc. 1 st in next st, k 1, place marker on needle, inc. 1 st in next st; k 9 for sleeve,            
inc. 1 st in next st, k 1, place marker on needle, inc. 1 st in next st *; k …………………………………………..  sts  21  21  23  23 
for back; repeat between *'s once, k ………………………………………………………………………………………………   sts  2  2  3  3 
k 2 sts from straight needle. There are on circular needle ………………………………………………………………  sts  66  66  70  70 
Carry up markers            
Row 3 ‐ Turn, slip 1, p all sts on circular needle, p 2 sts from straight needle. There are on circular            
needle …………………………………………………………………………………………………………………………………………….   sts  68  68  72  72 
Row 4 ‐ Turn, slip 1, * k to within 2 sts of marker, inc. 1 st in next st, k 1, inc. 1 st           
in next st *; repeat between *'s 3 times; k remaining sts on circular needle, k 2 sts            
from straight needle. There are on circular needle …………………………………………………………………………  sts  78  78  82  82 
Repeat rows 3 and 4 twice. There are on circular needle ………………………………………………………………..  sts  102  102  106  106 
Row 9 ‐ P all sts on circular needle and remaining 6 sts from straight needle. There           
are on circular needle ……………………………………………………………………………………………………………………..  sts  108  108  112  112 
Row 10 ‐ Repeat between *'s of row 4, four times, k remaining 6 sts from straight needle …………….  sts  122  122  126  126 
Continue to inc. 8 sts every k row as before, repeating buttonhole every 3 ½  ins            
until there are …………………………………………………………………………………………………………………………………  sts  306  314  326  342 
end with k row.            
Divide for Body and Sleeves ‐ P and place on holder for right front ……………………………………………….  sts  46  47  49  51 
P and place on holder for right sleeve …………………………………………………………………………………………….   sts  66  68  70  74 
P and place on holder for back  ………………………………………………………………………………………………………   sts  82  84  88  92 
P for left sleeve and leave on needle ……………………………………………………………………………………………..    sts  66  68  70  74 
Place on holder for left front remaining  ………………………………………………………………………………………..    sts  46  47  49  51 
Mark for beg. of sleeve.            
LEFT SLEEVE ‐ Cast on for underarm  ………………………………………………………………………………………………   sts  2  3  4  4 
turn and k across sleeve sts, cast on for underarm ………………………………………………………………………….  sts  2  3  4  4 
P 1 row on ………………………………………………………………………………………………………………………………………   sts  70  74  78  82 
Dec. row ‐ K 2, k 2 tog., k to within 4 sts of end, slip, k and pass, k 2 ……………………………………………….  sts  68  72  76  80 
Repeat dec. row every 2nd row ………………………………………………………………………………………………………  times  2  3  4  5 
every 10th row ……………………………………………………………………………………………………………………………….  times  3  3  4  5 
every 12th row ……………………………………………………………………………………………………………………………….  times  4  4  3  2 
Work even on ………………………………………………………………………………………………………………………………….  sts  50  52  54  56 
until 14 ins. from beg. of sleeve, end with p row.           
Dec. row ‐ K, decreasing across row ………………………………………………………………………………………………..  sts  6  8  6  8 
With size 5 needles, work k 2, p 2 ribbing for 4 ins. on ……………………………………………………………………  sts  44  44  48  48 
Bind off in ribbing.           
RIGHT SLEEVE ‐ With circular needle, take up right sleeve ………………………………………………………………  sts  66  68  70  74 
Join yarn at back edge and work to correspond to left sleeve. Sew sleeve seams, sewing turnback            
part of cuffs on right side.           
BODY ‐ With circular needle, take up left front  ………………………………………………………………………………  sts  46  47  49  51 
Join yarn at underarm edge and p‐front edge. Mark for beg. of body.           
Next row – K left front ……………………………………………………………………………………………………………………  sts  46  47  49  51 
pick up and k in underarm sts …………………………………………………………………………………………………………  sts  4  6  8  8 
take up and k back  ………………………………………………………………………………………………………………………….  sts  82  84  88  92 
pick up and k in underarm sts  …………………………………………………………………………………………………………  sts  4  6  8  8 
take up and k right front …………………………………………………………………………………………………………………  sts  46  47  49  51 
Work even on …………………………………………………………………………………………………………………………………  sts  182  190  202  210 
Continuing buttonholes as before, work even until measurement from marker is                
(end with k row) ……………………………………………………………………………………………………………………………..  ins.  13¼  13  12¾  12¼ 
having 2 rows below 7th buttonhole.            
With size 5 needles, work ribbing as on neck for   …………………………………………………………………………..  ins  1 ¾  2  2 ¼  2 ¼ 
Bind off in ribbing.            
 
FINISHING ‐ Block, see page 3. Finish buttonholes in blanket st. Face front edges with grosgrain ribbon. Cut buttonholes in ribbon and work 
with sewing thread and tack to buttonholes of front.
Digital Restoration © 2009 Purple Kitty LLC 23
Style No. 131 
Instructions are for sizes 34, 36, 38 and 40, see body measurement chart, page 3. 

  Sizes  34  36  38  40 


MATERIALS: BOTANY MANNIKIN, 2 oz. skeins  skeins  9  9  10  11 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 10            
‐ OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.            
1 pair "Boye" Non‐Inflammable Needles, Size 5 for ribbing.            
GAUGE: Size 10 Needles ‐              9 sts = 2 inches                      13 rows = 2 inches            
To check gauge, see page 3.            
MEASUREMENTS FOR BLOCKING:            
Chest  ……………………………………………………………………………………………………………………………  inches  36  38  40  42 
Width of back at underarm …………………………………………………………………………………………..  inches  18  19  20  21 
Width of sleeve at underarm ………………………………………………………………………………………..  inches  14 ½  15 ¼  16  17 
BACK  ‐With size 5 needles, cast on ………………………………………………………………………………  sts  81  85  91  95 
Ribbing ‐ Row 1 ‐ K 1, * p 1, k 1; repeat from * to end.            
Row 2 ‐ wrong side ‐ P 1, * k 1, p 1; repeat from * to end.            
Repeat these 2 rows until ribbing measures ………………………………………………………………….  ins.  3  3  3 ¼  3 ½ 
end with row 2. Begin pattern.            
Pattern – Row 1 – right side – With size 10 needles, k.           
Row 2 ‐ P 1, * k 1, p 1; repeat from * to end. Repeat these 2 rows for pattern.           
Work in pat. until measurement above ribbing is ………………………………………………………….  ins.  9 ¼  9 ½  10  10 ½ 
or desired length (end on wrong side with pat. row 2).            
Raglan Yoke Shaping ‐ First dec. row ‐ K 1, k 2 tog., k to within 3 sts of end, slip,           
k and pass, k 1 ………………………………………………………………………………………………………………  sts  79  83  89  93 
Next row ‐ P 2, * k 1, p 1; repeat from *, end last repeat p 2.            
2nd dec. row ‐ Same as first dec. row ……………………………………………………………………………  sts  77  81  87  91 
Next row ‐ P 1, * k 1, p 1; repeat from * across row.            
Dec. 1 st each side of next row and repeat decs. every 2nd row ……………………………………  times  25  27  29  31 
working pat. as in first 4 rows of raglan shaping ……………………………………………………………  sts  25  25  27  27 
Back Neck Ribbing ‐ Wide Turtle Neck ‐ With size 10 needles, work ribbing as for            
back for …………………………………………………………………………………………………………………………  ins.  3 ½  3 ½  4  4 
Bind off loosely in ribbing.            
Tight Turtle Neck ‐ Work same as for wide turtle neck using size 5 needles.           
Round Neck ‐ With size 5 needles, work ribbing for ………………………………………………………  ins.  1 ¼  1 ¼  1 ½  1 ½ 
Bind off loosely in ribbing.            
FRONT ‐ Work same as back until there are remaining on needle (end on right side            
with pat. row 1) …………………………………………………………………………………………………………….  sts  35  35  39  39 
Measurement above beg. of raglan yoke should be about ……………………………………………  ins.  7  7 ½  8  8 ½ 
Divide for neck as follows:            
Next row ‐ wrong side – Work ………………………………………………………………………………………  sts  12  12  14  14 
place these sts on holder for right side, work next 11 sts and place on holder for           
neck, finish row.            
Continue to dec. at armhole edge as before …………………………………………………………………  times  5  5  6  6 
at the same time, dec. 1 st at neck edge every row twice; every 2nd row …………………….  times  3  3  4  4 
Bind off remaining 2 sts.            
Take up sts of right side, work to correspond.            
SLEEVES ‐ With size 5 needles, cast on ………………………………………………………………………….  sts  41  41  45  45 
Work ribbing as on back for ………………………………………………………………………………………….  ins.  3 ½  3 ½  4  4 
With size 10 needles, work pat. as on back, increasing 1 st each side (keeping pat.)            
every ¾  ins …………………………………………………………………………………………………………………  times  3  7  7  11 
every 1 ¼ ins …………………………………………………………………………………………………………………  times  9  7  7  5 
(Continued on Next Page) 

Digital Restoration © 2009 Purple Kitty LLC 24


Style No. 131 (Continued from Page 24) 

  Sizes  34  36  38  40 


Work even on ....................................................................................................................  sts  65  69  73  77 
until length above ribbing is ………………………………………………………………………………………….  Ins.  14 ½  15  15  15 ¾ 
or desired length (end with pat. row 2).           
Working as for raglan yoke shaping on back, dec. 1 st each side of next row and            
repeat decs. every 2nd row …………………………………………………………………………………………..  times  27  29  31  33 
Work 1 row even after last dec. row, end on wrong side. Break yarn. Place sts on           
holder. Make second sleeve in same way; do not break yarn, leave sts on needle.           
FRONT NECK RIBBING ‐ Using same size needles as on back neck ribbing, k across            
9 sts of 2nd sleeve; from right side, pick up and k …………………………………………………………  sts  10  10  13  13 
on left neck edge of front; take up and k 11 sts from holder; pick up and k ………………….  sts  10  10  13  13 
on right neck edge, k across 9 sts of first sleeve ……………………………………………………………  sts  49  49  55  55 
Work ribbing as on back for same length as back neck. Bind off in ribbing.           
FINISHING ‐ Sew raglan seams joining sleeves to back and front. Sew underarm and sleeve seams. Steam, see page 3.  

Digital Restoration © 2009 Purple Kitty LLC 25


Style No. 133 
Sizes 12‐14 and 16‐18. 
Instructions are for size 12‐14, changes for size 16‐18 are in parentheses, see body measurement chart, page 3. 
   
MATERIALS: BOTANY KWILTEE, 2 oz. skeins.                                 Size 12‐14   Size 16‐18 
                                         Color A             12 skeins   13 skeins  
  Color B                                                                                             1 skein                     1 skein  
                                         Color C                                                                                           1 skein                     1 skein  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 10 ½  
‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
"Boye" Non‐Inflammable Hook, Size G.  
 
GAUGE:  Knitted Gauge ‐ 4 sts = 1 inch  
                 Blocked Gauge ‐ 7 sts = 2 inches To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
  At bustline, buttoned ...............................................   inches   39   42½  
  Width of back at underarm  ....................................   inches   18   19½ 
  Width of back above armhole shaping  ...................   inches   14   14½  
Width of fronts above front edge shaping to underarm   inches   11   12  
  Width of fronts above armhole shaping  .............   inches              7¾                        8½ 
  Width of sleeves at lower edge  ..........................   inches   10½   11  
  Width of sleeves at underarm  ............................   inches   13   13½  
 
NOTE: Length of all parts will be knitted length.   mark next st at lower edge for center st of first stripe, * skip 
BACK ‐ With A, cast on 64 (69) sts. K 1 row and mark this row  10  (11)  sts,  mark  next  st  at  lower  edge  for  center  st  of  next 
for wrong side.   stripe; repeat from * 4 times leaving 4 sts from left underarm 
Work even in garter st ‐ k every row ‐ until 16 ins. from beg.  edge.  
Mark for underarm.   Cut 2 strands of B about 18 ins. long and 4 strands of B about 
Armholes ‐ Bind off 2 sts at beg. of each of next 2 rows. Dec. 1  28  ins.  long.  Thread  tapestry  needle  with  18‐in.  strand  of  B. 
st each side every 2nd row 6 (7) times; 48 (51) sts. Work even  Fasten  strand  on  wrong  side  at  first  marker.  Draw  yarn 
until 7½ (8) ins. above marker.   through  to  right  side  at  this  st,  above  cast‐on  row.  Working 
Shoulder Shaping ‐ Bind off 4 (5) sts at beg. of each of next 2  from  right  side,  pass  over  first  ridge,  *  insert  needle  under 
rows; 4 sts at beg. of each of next 6 rows. Bind off 16 (17) sts.   upper loop of same st on following ridge, pass over next loop 
LEFT FRONT ‐ Cast on 33 (37) sts. K 1 row and mark for wrong  of same st on next ridge; repeat from * to underarm edge and 
side.   fasten  on  wrong  side.  With  28‐in.  strand  of  B,  beg.  at  2nd 
Inc. row ‐ right side ‐ K to within 1 st of end, inc. 1 st in last st ‐  marker,  work  2nd  stripe  in  same  way  as  first  stripe  to 
mark end of row for front edge. Continue garter st repeating  shoulder.  Work  a  stripe  at  3rd  and  4th  markers  extending 
inc.  row  every 2nd  row 5  times;  39 (43)  sts.  Work  even until 
stripe  to  neck.  Work  5th  stripe  same  as  2nd  stripe  and  6th 
16  ins.  from  beg.,  measured  at  center  of  work,  end  at 
stripe same as first stripe. Cut 4 strands of C about 38 ins. long 
underarm edge. Mark for underarm.  
Armhole  ‐  Bind  off  6  sts  at  beg.  of  next  row.  Dec.  1  st  at  and 8 strands of C about 60 ins. long. Draw 38‐in. strand of C 
armhole  edge  every  2nd  row  6  (7)  times;  27  (30)  sts.  Work  through to right side 1 st to right of first B stripe above cast‐on 
even until about 6½ (7) ins. above marker, end at front edge.  row, drawing up yarn to half its length leaving other end free. 
Bind  off  6  (7)  sts  at  beg.  of  next  row.  Dec. 1  st  at  neck  edge  Weave a stripe same as for first stripe. With free end weave a 
every  row 5 (6)  times, shaping  shoulder  same  as  right  shoul‐ stripe 1 st to left of B stripe in same way. Using yarn necessary 
der on back when armhole is same length.   length, work C stripes to correspond on each of next 5 stripes. 
RIGHT FRONT ‐ Cast on 33 (37) sts, K 2 rows.   Beg. at first group of stripes, draw 19 ins. of 38‐in. strand of C 
Inc. row ‐ wrong side ‐ K to within 1 st of end, inc. 1 st in last  through  to  right  side  to  right  between  Band  C  stripes  in  row 
st‐mark  end  of  row  for  front  edge.  Continue  garter  st  above  cast‐on  row,  leaving  19  ins.  free  and  weave  between 
repeating  inc.  row  every  2nd  row  5  times;  39  (43)  sts.  Work  sts,  going  under  the  loops  on  ridges  skipped  when  weaving 
even until 37 (39) rows from beg. measured at center of work,  first  and  2nd  stripes.  With  free  end,  weave  another  stripe 
end at front edge.  
between  2nd  and  3rd  stripes  in  same  way  as  illustrated,  see 
Buttonhole  rows  ‐  K  2  sts,  bind  off  2  sts,  k  to  end.  On  next 
below.  Using  yarn  necessary  length  work  2  more  C  stripes  in 
row, cast on 2 sts over buttonhole. Finish to correspond to left 
front, shaping at opposite sides, repeating buttonhole on 21st  same way on each of next 5 groups of stripes. 
and 22nd rows until there are 4 buttonholes in all.    
SLEEVES  ‐  Cast  on  37  (39)  sts.  Work  even  in  garter  st  until  4   
ins.  from  beg.  Inc.  1  st  each  side  of  next  row;  repeat  incs.   
every  3  ½    ins.  3  times;  45  (47)  sts.  Work  even  until  17  ins.   
from beg. Bind off 2 sts at beg. of each of next 2 rows. Dec. 1   
st each side every 2nd row 6 times; every 4th row 4 (5) times;   
every row 6 times. Bind off 9 sts.    
COLLAR ‐ Cast on 10 sts. Work even in garter st until 15 (15½)   
ins. from beg., end on wrong side. Bind off.    
Block each piece separately to given measurements, see page 
 
3.  Block  collar  at  outer  edge  to  16  (16½)  ins.  leaving  inner 
edge the knitted length.    
EMBROIDERY  –  BACK  ‐  Skip 4  sts  from  right  underarm  edge,  (Continued on Next Page) 

Digital Restoration © 2009 Purple Kitty LLC 26


 
 
Style No. 133 (Continued from Page 26) 
LEFT  FRONT  ‐  Skip  8  sts  from  underarm  edge,  mark  next  st  at  COLLAR ‐ With cast‐on row at lower edge, skip 3 sts from right 
lower edge for center st of first stripe, * skip 10 (11) sts, mark  edge,  mark  next  st  for  center  st  of  stripe.  Embroider  same  as 
next st  at lower edge for center st of next stripe; repeat from *  first stripe on back, extending stripe for length of collar.  
once. Embroider first 2 stripes same as for back.  
FINISHING  ‐  Sew  seams.  Sew  in  sleeves  with  seam  at  center 
Cutting yarn the required length, work 3rd stripe to neck edge;  underarm. Sew on collar with ends of collar at end of stripes at 
drawing  yarn  to  wrong  side,  continue  stripe  on  wrong  side  front  edge.  With  A,  from  right  side,  beg.  in  st  next  to 
working downward for 8 ins.   embroidered  stripe  on  right  front  edge,  work  1  row    sc  on 
shaped  edge  and  front  edge  until  opposite  top  buttonhole. 
RIGHT  FRONT  ‐  Mark  and  embroider  to  correspond  to  left 
Fasten off. Work 1 row sc on left front to correspond. Beg. 1 st 
front.  
above first sc on left front, from wrong side, work 1 row sc to 
SLEEVE  ‐  Beg.  at  lower  edge  of  sleeve,  skip  7  sts  from  right  neck  edge,  working  2  sc  in  corners,  continue  sc  across  bound‐
edge, mark next st at lower edge for center of first stripe, * skip  off sts, around collar and down right front edge to st above sc 
10  (11)  sts,  mark  next  st  at  lower  edge  for  center  st  of  next  rowan  right  front  edge,  join  and  fasten  off.  Steam  lightly,  see 
stripe;  repeat  from  *  once,  leaving  7  sts  from  left  edge.  page  3.  Sew  seam  binding  across  shoulder  seams  and  neck 
Embroider stripes same as for back.   edge.
  

Digital Restoration © 2009 Purple Kitty LLC 27


  
 
Style No. 149 
Instructions are for size 34‐36, changes for sizes 38‐40 and 42‐44 are in parentheses, see body measurement chart, page 3. 
 
MATERIALS: BOTANY COLOSSAL, 2 oz. skeins.                                                           Size 34‐36             Size 38‐40     Size 42‐44  
  Color A                                                    11 skeins     13 skeins             15 skeins  
  Color B                                                     2 skeins                2 skeins               3 skeins  
  Color C                                                     3 skeins                3 skeins               4 skeins  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 15  
‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 11.  
 
GAUGE: Size 15 Needles ‐ 5 sts = 2 inches   7 rows = 2 inches  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
  Chest.............................................................................  inches  38 ½  41    44  
  Width of back at underarm  .........................................   inches   18 ¾                       20 ½    22  
  Width of sleeves at underarm  .....................................   inches   15   17   17 ¾   
                                                                                                                                              (Continued on Next Page) 

Digital Restoration © 2009 Purple Kitty LLC 28


Style No. 149 (Continued from Page 28) 
 
BACK ‐ With size 11 needles and color A, cast on 47 (51‐55) sts.  Back Neck Ribbing ‐ With size 11 needles, work k 1, p 1 ribbing 
Work k 1, P 1 ribbing for 3 ½ ins.   for 5 rows. Bind off loosely in ribbing.  
With size 15 needles, work stockinette st‐p 1 row, k 1 row‐until  FRONT  ‐  With  size  11  needles  and  A,  cast  on  47  (51‐55)  sts. 
8¾ (9¾‐10¼) ins. above ribbing, end with k row. Begin Chevron  Work  same  as  back  until  armholes  measure  6  (6¾‐7¼)  ins. 
point at center.   above marker, end with p row.  
Row 1 ‐ P 23 (25‐27) sts, join B and p 1; join 2nd ball of A and p  Divide for Neck ‐ K 12 (13‐15), place on holder for left side; k 15 
23 (25‐27) sts.   (17‐17),  place  on  holder  for  neck,  k  to  end.  Work  even  until 
Row 2 ‐ With A, k 22 (24‐26), pass B under A on wrong side and  armhole is 1 row less in length then left side of back, end with k 
k 3 B, pass A under B on wrong side and k to end with A.   row. Break yarn, leaving a 27‐in. end for weaving.  
Note: Always pass next color to  be used under last color used  Take up 12 (13 ‐15) sts of left side, beg. at neck edge, work until 
on wrong side when changing colors.   same number of rows as on right side of front, end with k row. 
Row 3 ‐ P 21 (23‐25) A, 5 B, with A, P to end.   Break yarn, leaving a 27‐in. end. Weave shoulder sts tog.  
Continue to work 2 sts more with B at center and 1 st less with  FRONT NECK RIBBING ‐ With size 11 needles and C, beg. on left 
A at each side every row. Work until 11¼ (11¾‐12¼) ins. above  side of neck at shoulder, pick up and k 6 (8‐8) sts on left side of 
ribbing, end with p row.   neck  edge,  take  up  and  k  15  (17‐17)  sts  from  holder,  pick  up 
Armholes ‐ K 4 sts and place on holder for underarm, work to  and k 6 (8‐8) sts on right side of neck edge; 27 (33‐33) sts. Work 
within  4  sts  of  end  of  row,  place  last  4  sts  on  holder  for  p 1, k 1 ribbing for 5 rows. Bind off loosely in ribbing.  
underarm; 39 (43‐47) sts. Mark for underarm.   SLEEVES‐With  size  15  needles  and  A,  from  right  side,  take  up 
Continue  point  until  there  are  14  rows  in  B  stripe,  end  with  k  and k 4 underarm sts at left side of front, pick up and k 30 (34‐
row. Begin yoke at center.   36)  sts  on  armhole  edge‐about  1  st  in  every  2nd  row‐take  up 
Row 1 ‐ P 19 (21‐23) sts, join C and p 1, join 2nd ball of B and p  and  k  4  underarm  sts  of  back;  38  (42‐44)  sts.  Working 
14, with A, p to end.   stockinette st, dec. 1 st each side every 8th row 2 (4‐3) times; 
Row 2 ‐ K 18 (20‐22), k 3 C, 14 B, with A, k to end.   every  6th  row  6  (4‐6)  times,  decreasing  by  working  2  tog.  at 
Continue  to  work  Chevron  Stripe  and  yoke  in  this  way  until  beg. and slip, k and pass at end of k rows; 22 (26‐26) sts. Work 
there is only 1 st of A at each side. Break off both balls of A.   even until 15¾ (18‐19½) ins. from beg., end with p row. Dec. 1 
Continue  Chevron  Stripe  and  yoke  with  B  and  C  until  there  is  st  each  side  of  next  row;  20  (24‐24)  sts.  With  size  11  needles, 
only  1  st  of  B  at  each  side.  Break  off  both  balls  of  B.  With  C,  work ribbing for 3 ins. Bind off. Work right sleeve in same way.  
work  even  until  armholes  measure  8  ¼  (9  ½‐10)  ins.  above  FINISHING  ‐  Sew  underarm  and  sleeve  seams.  Sew  seams  on 
marker, end with p row.   ribbing  of  collar  and  cuffs  being  careful  to  keep  a  flat  seam. 
Next row ‐ K 12 (13‐15) sts and place on holder for shoulder, k  Block, see page 3. 
15 (17‐17) for neck, place remaining 12 (13‐15) sts on holder for 
shoulder.  
 
Style No. 151 (Shown on Page 7) 
Instructions are for Child's size, changes for Women's and Men's sizes are in parentheses. 
 
MATERIALS:      BOTANY COLOSSAL, 2 oz. skeins, 2 (3‐3) skeins.  
                            BUCILLA HANDI‐YARN, ART. 028, 2 cards of Contrasting Color.  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 11‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
 
GAUGE:       3 sts = 1 inch  
To check gauge, see page 3.  
 
Cast on 25 (29‐35) sts.   Next row ‐ Work 3 (5‐7) sts, p 3, work 3, p 3, work 3 (5‐7) sts.  
Row 1 ‐ wrong side ‐ K 9 (10‐12), p 1, k 5 (7‐9), p 1, k 9 (10‐12)  2nd dec. row ‐ Work 2 (4‐6) sts, k 2 tog., k 1, slip, k and pass, k 
sts.   1, k 2 tog., k 1, slip, k and pass, work 2 (4‐6) sts; 11 (15‐19) sts.  
Row 2 ‐ K all sts.   Draw end through all sts twice, fasten off securely.  
Repeat these 2 rows until 3½ (4‐5) ins. from beg., end on wrong  FINISHING  ‐  Fold  cast‐on  edge  in  half  and  sew  edges  tog.  on 
side.   wrong  side  for  back  of  heel,  gathering  the  center sts  securely. 
Next row ‐ Bind off 3 (3‐4) sts at beg. and end of next row; 19  Sew side edges of ribbing and foot tog. to end.  
(23‐27)  sts.  Break  off.  Turn,  join  yarn,  work  even  until  5  (6‐8)  POM‐PONS ‐ Wind yarn 40 times around a 2‐in. cardboard, cut 
ins.  from  beg.  or  2  (2½‐2½)  ins.  less  than  desired  finished  at one end, place strands flat on table, cut Art. 028 at one end 
length, allowing the 2 (2½‐2½) ins. for toe, end on right side.   of  card  and  place  strands  on  top  of  first  color,  with  separate 
TOE ‐ Row 1 ‐ wrong side ‐ K 1, * p 1, k 1; repeat from * to end.   strand of yarn tie strands tog. securely at center, leaving an end 
Row 2 ‐ P 1, * k 1, p 1; repeat from * to end.   for  sewing.  Trim  ends.  Make  2.  Sew  on  front  of  slippers  as 
Repeat last 2 rows 0 (1‐1) times; repeat row 1 once.   illustrated.  
First dec. row ‐ right side ‐ Work 3 (5‐7) sts, * slip, k and pass, k 
1, k 2 tog., work next 3 sts, slip, k and pass, k 1, k 2 tog., work 3 
(5‐7) sts; 15 (19‐23) sts.  

Digital Restoration © 2009 Purple Kitty LLC 29


Style No. 127 
Sizes 12, 14, 16. 
Instructions are for size 12, changes for sizes 14 and 16 are in parentheses, see body measurement chart, page 3. 
 
MATERIALS: BOTANY NYLON 'n WOOL GERMANTOWN KNITTING,   Size 12  Size 14  Size 16  
2 oz. skeins  
  Charcoal,      Color A  3 skeins  3 skeins   3 skeins  
Lt. Oxford,             Color B  3 skeins   3 skeins     3 skeins  
                  Scarlet,   Color C  3 skeins   3 skeins   4 skeins  
  Black,   Color D  1 skein   1 skein   1 skein  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 8 – 
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 6 for facings.  
"Boye" Steel Hook, Size 0.  
 
GAUGE: Size a Needles ‐ 9 sts = 2 inches   13 rows = 2 inches  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
At bustline   inches   33 ½    36   38 ½  
Width of back at underarm   inches   16 ½    18   19  
 
BACK ‐ With size 6 needles and A, cast on 17 (19‐21) sts; with B,  carry  out  pat.  joining  yarn  as  needed,  end  with  pat.  row  39. 
cast on 12 sts; with another skein of A, cast on 17 (19‐21) sts;  Break D.  
with another skein of B, cast on 12 sts; with another skein of A,  Turning  Ridge  ‐  wrong  side  ‐  With  size  6  needles,  k,  inserting 
cast on 17 (19‐21) sts; 75 (81‐87) sts.   needle in back of sts using matching colors.  
NOTE:  Always  bring  color  to  be  used  under  last  color  used  to  Next row ‐ K 13 (14‐15) B, 12 C, 17 (19‐21) B, 12 C, 13 (14‐15) B.  
prevent a hole.   Next row ‐ P 13 (14‐15) B, 12 C, 17 (19‐21) B, 12 C, 13 (14‐15) B. 
Row  1  ‐  wrong  side‐P  17  (19‐21)  A,  *  p  12  B,  17  (19‐21)  A;  Repeat last 2 rows twice for neck facing. Bind off with matching 
repeat from * once.   colors.  
Row  2  ‐  K  17  (19‐21)  A;  *  k  12  B,  17  (19‐21)  A;  repeat  from  *  FRONT ‐ Work same as back. 
once. Repeat rows 1 and 2, twice for facing.   SLEEVES  ‐  With  size  6  needles  and  A,  cast  on  15  (17‐19)  sts; 
Turning  Ridge  ‐  wrong  side  ‐  K,  inserting  needle  in  back  of  sts  with B, cast on 12 sts; with another strand of A, cast on 15 (17‐
using matching colors.   19) sts; 42 (46‐50) sts.  
Plaid Pattern ‐ Row 1 ‐ right side‐With size 8 needles, k 17 (19‐ Row 1 ‐ P 15 (17‐19) A, 12 B, 15 (17‐19) A.  
21) A, * k 12 B, 17 (19‐21) A; repeat from * once.   Row 2 ‐ K 15 (17‐19) A, 12 B, 15 (17‐19) A.  
Row  2  ‐  P  17  (19‐21)  A,  *  p  12  B;  17  (19‐21)  A;  repeat  from  *  Repeat rows 1 and 2 twice for facing. Work turning ridge as on 
once.   back.  
Repeat rows 1 and 2 once.   Plaid Pattern ‐ Row 1 ‐ right side ‐ With size 8 needles, k 15 (17‐
With C, k 1 row, p 1 row. Carry A and B up along edge and on  19) A, 12 B, 15 (17‐19) A.  
wrong side at center.   Row 2‐P 15 (17‐19) A, 12 B, 15 (17‐19) A.  
Rows 7 and 8 ‐ Repeat rows 1 and 2. With C, k 1 row, p 1 row.  Continue pat. as on back, increasing 1 st each side of 12th row 
Break C. Repeat rows 1 and 2 five times.   increasing  as  to  purl.  Repeat  incs.  every  12th  row  3  times, 
With C, k 1 row, p 1 row.   working increased sts in same color as square at each side; 50 
Rows  23  and  24  ‐  Repeat  rows  1  and  2.  With  C,  k  1  row,  p  1  (54‐58)  sts.  This  completes  first  48  rows  of  pat.  Break  B  in 
row. Break C. Repeat row 1 and 2 twice. Break A and B.   middle of work but do not break B at end of last row.  
These 30 rows complete first group of squares.    
Row 31 ‐ K 17 (19‐21) B, * k 12 C, 17 (19‐21) B; repeat from *   
once.  
Row 32 ‐ P 17 (19‐21) B, * p 12 C, 17 (19‐21) B; repeat from * 
once. Repeat rows 31 and 32 twice. With D, k 1 row, p 1 row.  
Rows 39 and 40 ‐ Repeat rows 31 and 32.  
With D, k 1 row, p 1 row. Break D. Repeat rows 31 and 32 three 
times. These 18 rows complete 2nd group of squares. These 48 
rows form one repeat of pat. Repeat the 30 rows of first group 
and 13 (11‐9) rows of 2nd group, end with pat. row 43 (41‐39), 
a k row, about 14 ¼ (14‐13 ¾) ins. above turning ridge. Mark for 
underarm.  
Armholes ‐ With B (D‐B) bind off 4 (5‐6) sts, work to within 4 (5‐
6)  sts  of  end  with  care  to  carry  out  pat.,  with  B  (D‐B)  bind  off   
last 4 (5‐6) sts; 67 (71‐75) sts. Break yarn at edges. Work even 
in pat. until about 6 ¾ (7‐7 ¼) ins. above marker, with care to 

Digital Restoration © 2009 Purple Kitty LLC 30


Next row ‐ K 2 B, 17 (19‐21) A, 12 B, 17   
(19‐21) A, join another skein B and k 2 
B.  Continue  pat.  increasing  1  st  each 
side every 10th row as before 3 times; 
56 (60‐64) sts. This completes 30 rows 
of this group of squares.  
Next row ‐ K 5 C, 17 (19‐21) B, 12 C, 17 
(19‐21) B, 5 C. Work next 8 rows of pat. 
Inc. 1 st each side of next row; 58 (62‐
66)  sts.  Work  8  rows  even.  Sleeve 
should measure about 14 ¾ ins. above 
turning ridge. Bind off.  
VERTICAL  CROCHET  STRIPES  ‐  First 
Stripe  ‐  Insert  hook  from  right  side 
between  3rd  and  4th  st  from  right 
edge  of  back,  just  above  turning  ridge 
at  lower  edge  and  draw  C  through  to 
right side, * insert hook between same 
sts above next row, draw yarn through 
from  wrong  side  and  through  loop  on 
hook; repeat from * to bound‐off sts at 
armhole.  Fasten  off  by  drawing 
through  to  wrong  side  below  bound‐
off  sts.  Skip  next  2  sts  and  work  2nd 
stripe with C, same as first stripe. Skip 
next  7  (9‐11)  sts  and  work  3rd  stripe 
with C working to turning ridge of neck 
facing.  Skip  2  sts  and  work  4th  stripe 
same as 3rd stripe. Skip 8 sts and work 
5th  stripe  with  D  same  as  3rd  stripe. 
Skip  2  sts  and  work  6th  stripe  with  D. 
Work  4  stripes  with  C  on  next  square 
to  correspond  to  first  square,  working 
all stripes to neck ridge; work 2 stripes 
with  D  on  next  square  and  4  stripes 
with C on next square to correspond to 
first square.  
Work stripes on front to correspond to 
back.  
Insert  hook  between  first  and  2nd  sts 
from  right  edge  of  sleeve  just  above 
turning  ridge  and  work  with  C  for  first 
stripe  to  top  of  sleeve.  Skip  2  sts  and 
work  2nd  stripe  with  C.  Continue  to 
work  stripes  to  correspond  to  back, 
ending  last  stripe  between  2nd  and 
last st from left edge.  
FINISHING  ‐  Sew  underarm  seams 
matching  pats.  Sew  sleeve  seams  to 
within  ¾  (1‐1¼)  ins.  of  top,  matching 
pats.  Turn  back  facings  and  hem  on 
wrong  side  leaving  an  opening  at  side 
on lower edge for inserting elastic. Sew 
shoulder  seams  sewing  through  sts  of 
turning ridge for 3 ½ (4‐4½) ins. at each 
side.  Sew  bound‐off  edge  of  top  of 
sleeve  to  armhole  edge,  sew  side 
edges  left  free  to  bound‐off  sts  of 
underarm. Block, see page 3.  
Insert  ½  in.  elastic  through  hem  on 
lower  edge  and  hold  in  to  desired 
measurement.

Digital Restoration © 2009 Purple Kitty LLC 31


 
 
Style No. 126 
Instructions are for sizes 12, 14, 16 and 18, see body measurement chart, page 3. 
 
MATERIALS: BOTANY SAXATONES, 1 oz. skeins.   Sizes   12   14   16   18  
  Color A   skeins   8   8   9   9  
  Color B  skeins   1   1   1   1  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 3 – 
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 2 for ribbing.  
"Boye" Non‐Inflammable Hook, Size D.  
 
GAUGE: Size 3 Needles ‐ 8 sts = 1 inch  
  To check gauge, see page 3.      
(Continued on Next Page) 

Digital Restoration © 2009 Purple Kitty LLC 32


Style No. 126 (Continued from Page 32) 
 
  Sizes  12  14  16  18 
MEASUREMENTS FOR BLOCKING:            
             At bustline …………………………………………………………………………………………………………  inches  33  35  37  39 
             Width of back at underarm ………………………………………………………………………………..  inches  16 ½  17 ½  18 ½  19 ½ 
             Width of sleeves at underarm ……………………………………………………………………………  inches  12 ½  13  13 ½  14 
The vertical stripes are worked in later with a slip stitch.           
           
BACK ‐ With size 2 needles and A, cast on …………………………………………………………………….  sts  130  138  146  154 
Work k 1, p 1 ribbing for 3 ins. Inc. 1 st in first st of last row.            
With size 3 needles, work stockinette st‐k 1 row, p 1 row‐on ………………………………………..  sts  131  139  147  155 
until 8½ ins. above ribbing. Mark for underarm.            
Armholes ‐ Bind off 8 sts at beg. of each of the next 2 rows.            
Dec. 1 st each side every 2nd row …………………………………………………………………………………  times  5  7  9  11 
Work even on ……………………………………………………………………………………………………………….  sts  105  109  113  117 
until measurements above underarm are …………………………………………………………………….  ins  7  7 ¼  7 ½  7 ¾ 
Shoulder Shaping ‐ Bind off at beg. of each of next 4 rows …………………………………………..  sts  8  8  9  9 
Bind off at beg. of each of next 4 rows ………………………………………………………………………….  sts  8  9  9  10 
Bind off remaining 41 sts.             
FRONT ‐ With size 2 needles and A, cast on……………………………………………………………………  sts  130  138  146  154 
Work same as for back until 7 ½ ins. above ribbing, end with p row …………………………….  sts  131  139  147  155 
Begin neck border. K ……………………………………………………………………………………………………..  sts  56  60  62  66 
* k 1, p 1; repeat from * ………………………………………………………………………………………………..  times  8  8  10  10 
k 1; k remaining   …………………………………………………………………………………………………………..  sts  56  60  62  66 
The rib panel will have ………………………………………………………………………………………………….  sts  19  19  21  21 
Next row – P …………………………………………………………………………………………………………………  sts  56  60  62  66 
* p 1, k 1; repeat from * ………………………………………………………………………………………………..  times  8  8  10  10 
p 1; p remaining      ………………………………………………………………………………………………………..  sts  56  60  62  66 
Repeat the last 2 rows until same length to underarm as back, end with p row.            
Armhole and Neck Shaping ‐ Bind off 8 sts at beg. of each of next 2 rows ……………………  sts  115  123  131  139 
Divide for Neck ‐ K 2 tog., k …………………………………………………………………………………………..  sts  45  49  51  55 
k 2 tog., * p 1, k 1; repeat from *  ………………………………………………………………………………….  times  3  3  4  4 
Place these sts on holder for left side ……………………………………………………………………………  sts  55  59  63  67 
Bind off 1 st for center of neck.           
Right Side ‐  * K 1, p 1; repeat from *   …………………………………………………………………………  times  3  3  4  4 
with yarn in back of work, slip 1 st as to p, k 1, pass slip st over k st, k to within            
2 sts of end, k 2 tog.            
Next row ‐ P………………………………………………………………………………………………..................  sts  47  51  53  57 
* k 1, p 1; repeat from *……………………………………………………………………………………………….  times  3  3  4  4 
Repeating last 2 rows of right side, dec. 1 st at armhole edge every 2nd row ……………….  times  4  6  8  10 
at the same time dec. 1 st at neck edge every 4th row 15 times …………………………………..  sts  36  38  40  42 
every 2nd row 4 times …………………………………………………………………………………………………..  sts  32  34  36  38 
always keeping the 8 sts at neck edge in ribbing.            
Work even until armhole measures same length as on back. Shape shoulder same as            
left shoulder on back.           
Beg. at neck edge, finish left side to correspond to right side.            
SLEEVES ‐ With size 3 needles and A, cast on ………………………………………………………………..  sts  80  84  88  92 
Entire sleeve is worked in k 1, p 1 ribbing. Inc. 1 st each side every 4th row 10 times …..  sts  100  104  108  112 
Work even until 5 ½ ins. from beg.            
Bind off 8 sts at beg. of each of the next 2 rows.            
Dec. 1 st each side every 2nd row …………………………………………………………………………………  times  27  28  29  30 
Bind off 3 sts at beg. of each of next 6 rows. Bind off in ribbing …………………………………….  sts  12  14  16  18 
COLLAR ‐ With size 3 needles and A, cast on ………………………………………….  sts  29  29  31 31
K 1, * p 1, k 1; repeat from * to end.            
Next row ‐ P 1, * k 1, p 1; repeat from * to end.            
Repeat last 2 rows for collar, working until ……………………………………………...  ins.  14  14 ½  15 15 ½ 
from beg. Bind off in ribbing.            
FINISHING ‐ With B, work  a  slip  st  in  each  row of each p st stripe on front rib panel, collar and sleeves. With A, work 1 row slip st  
around neck edge keeping work flat, 1 row slip st around collar and sleeve edges. Sew seams. Sew in sleeves matching seams. Sew on 
collar having center of collar at center of back. Block, see page 3.

Digital Restoration © 2009 Purple Kitty LLC 33


Style No. 122 
Instructions are for sizes 12, 14, 16, 18 and 20, see body measurement chart, page 3. 
Sizes  12  14  16  18  20 
MATERIALS: BOTANY SCOTTIE "SHETLAND AND WOOL", 2 oz. skeins  skeins  6  7  7  8  8 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 7              
‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.              
1 pair "Boye" Non‐Inflammable Needles, Size 4 for ribbing. "Boye" Non‐Inflammable Hook, Size F           
GAUGE: Size 7 Needles ‐ 11 sts = 2 inches   7 rows = 1 inch             
To check gauge, see page 3.              
MEASUREMENTS FOR BLOCKING:              
           At bust line, buttoned  inches   35  37  39  40 ½  42 ½ 
           Width of back at underarm  inches  17  18  19  20  21 
BACK ‐ With size 4 needles, cast on  sts  94  98  102  106  114 
Row 1 ‐ wrong side ‐ K 2, * p 2, k 2; repeat from * to end.             
Row 2 ‐ P 2, * k 2, p 2; repeat from * to end.              
Repeat these 2 rows until 2 ins. from beg., end with row 2, increasing in last row  sts  0  0  2  2  0 
With Size 7 needles, work stockinette st ‐ p 1 row, k 1 row, on  sts  94  98  104  108  114 
until 12 ins. above ribbing, end with k row. Mark for underarm.             
Armholes ‐ p 1 row.                 
Dec. row ‐ K 2, k 2 tog., k to within 4 sts of end, slip, k and pass, k 2     sts  92  96  102  106  112 
Repeat last 2 rows  times  10  11  12  13  14 
Work even on  sts  72  74  78  80  84 
until measurement above marker is (end with k row)  ins.  6 ¾  7  7 ¼  7 ½  7 ¾ 
Shoulders ‐ Bind off at beg. of each of next 2 rows     sts  7  8  10  11  11 
Bind off 8 sts at beg. of each of next 4 rows.              
Place on holder for neck ribbing  sts  26  26  26  26  30 
Break yarn.             
LEFT FRONT ‐ With size 4 needles, cast on  sts  50  54  58  58  62 
Row 1 ‐ wrong side ‐ P 2, * k 2, P 2; repeat from * to end.              
Row 2 ‐ K 2, * p 2, k 2; repeat from * to end.              
Repeat these 2 rows until same number of rows as ribbing on back, end with row 2,              
increasing in last row  sts  3  2  1  3  2 
With size 7 needles work even in stockinette st on  sts  53  56  59  61  64 
until same length as back to armhole, end with k row.              
Mark beg. of last row for underarm.              
Armhole ‐ Work 1 row even.             
Dec. row ‐ K 2, k 2 tog., k to end  sts  52  55  58  60  63 
Repeat last 2 rows  times  10  11  12  13  14 
Work even on  sts  42  44  46  47  49 
until armhole is same length as on back, end with p row at armhole edge.              
Shoulder ‐ Bind off    sts  23  24  26  27  27 
finish row, place on holder for neck ribbing remaining  sts  19  20  20  20  22 
Do not break yarn.             
Mark position of 6 buttons evenly spaced on front edge, having first button 1 in. from              
lower edge and 6th button 3 ins. below neck edge; 7th button will be in neck ribbing.             
RIGHT FRONT ‐ With size 4 needles, cast on  sts  50  54  58  58  62 
Work ribbing same as left front until opposite first marker for button, end on wrong              
side‐front edge.             
Buttonhole row ‐ Work 3 sts, bind off 2 sts, work to end. Cast on 2 sts over buttonhole              
in next row.             
Continue to correspond to left front, repeating buttonhole opposite markers, until              
same length as left front to armhole, end with k row. Mark end of row for armhole.              
Armhole ‐ Work 1 row even.             
Dec. row ‐ K to within 4 sts of end, slip, k and pass, k 2  sts  52  55  58  60  63 
Continue to correspond to left front repeating buttonholes opposite markers until              
armhole is same length, end with k row  sts  42  44  46  47  49 
Shoulder ‐ Bind off    sts  23  24  26  27  27 
place on holder for neck remaining  sts  19  20  20  20  22 
Break yarn.              
SLEEVES ‐ With size 4 needles, cast on  sts  44  44  48  48  52 
Work k 2, P 2 ribbing for 3 ins.              
Inc. row ‐ K, increasing evenly spaced across row  sts  5  8  8  12  12 
With size 7 needles, continue stockinette st on     sts  49  52  56  60  64 
increasing 1 st each side every 8th row 11 times     sts  71  74  78  82  86 
Work even until 15 ins. above ribbing, end with k row. Mark each side of last row.              
       
(Continued on Page 42)
Digital Restoration © 2009 Purple Kitty LLC 34
Digital Restoration © 2009 Purple Kitty LLC 35
FRINGE ‐ Wind B on a 4 ½‐in. cardboard. Cut at one end. Using 
6 strands,  knot a  fringe  in  space  between  3rd and  4th  st  from 
edge  on  bound‐off  row,  *    skip  6  sts,  knot  a  fringe  in  space 
between  6th  and  7th  st;  repeat  from  *  having  last  fringe  in 
space  between  3rd  and  4th  st  from  other  edge.  Trim  fringe 
evenly.  
Steam lightly to given measurements, see page 3.  

 
Style No. 139 
 
MATERIALS: BOTANY CLASSIC SPORT, 1 oz. skeins,  
Color A ‐ 1 skein      Color B ‐ 1 skein  
 
KNITTING  NEEDLES:  1  pair  "Boye"  Non‐Inflammable  Needles, 
Size 5‐0R SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
 
GAUGE:  21 sts = 2 inches   8 rows = 1 inch  
To check gauge, see page 3.  
 
With A, cast on 7 sts.  
Row 1 ‐ wrong side ‐ P 1, * k 1, p 1; repeat from * to end.  
Row 2 ‐ K 1, * p 1, k 1; repeat from * to end.  
Repeat last 2 rows until 10 ins. from beg. for tie string, end with 
row 1. Entire cap is made in ribbing.  
First  inc.  row  ‐  Inc.  1  st  in  each of  the  first  3 sts  (inc.  as  to  k), 
place a marker on needle, inc. 1 st in each of next 3 sts, k 1; 13 
sts.  
Next row ‐ Same as row 1, carry marker.  
2nd  inc.  row  ‐  Work  ribbing  as  on  row  2  to  within  1  st  of 
marker, inc. 1 st (as to p) in next st, slip marker, inc. 1 st (as to 
k) in next st, work p 1, k 1 ribbing to end; 15 sts.  
Next row ‐ Work same as row 1 to within 2 sts of marker, p 2, 
slip marker, p 1, work k 1, p 1 ribbing to end. Carry up marker 
by slipping it from left to right needle on every row.  
3rd inc. row ‐ Same as row 2 to within 1 st of marker, inc. 1 st 
(as to k) in next st, slip marker, inc. 1 st (as to k) in next st, work 
k 1, p 1 ribbing, end k 1; 17 sts.  
Repeat last 4 rows 4 times, 20 rows above first inc. row; 33 sts. 
Break A. Join B.  
 
First Stripe ‐ With B, repeat last 20 rows once; 53 sts. Break B. 
  This completes inc. rows. Join A.  
Style No. 138  Second Stripe ‐ With A, work even in ribbing for 20 rows. Break 
Approximate Size 9 inches by 65 inches without fringe.  A.  
  Center Stripe ‐ Row 1 ‐ wrong side ‐ With B, work 1 row even in 
MATERIALS: BOTANY CLASSIC SPORT, 1 oz. skeins,   ribbing.  
Color A‐5 skeins    Color B‐5 skeins   Row 2 ‐ Short rows ‐ Work ribbing to within 7 sts of end, turn.  
  Row 3 ‐ Slip first st as to k, work ribbing to end.  
KNITTING  NEEDLES:  1  pair  "Boye"  Non‐Inflammable  Needles,  Note:  To  prevent  a  hole  always  work  slipped  st  tog.  with  st 
Size 6 ‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.   directly below.  
  Row 4 ‐ Work ribbing to within 13 sts of end, turn.  
 
GAUGE:  10 sts = 1 inch   29 rows = 4 inches  
 (Continued on Next Page) 
To check gauge, see page 3.  
 
With A, cast on 90 sts.  
Work  k  1,  p  1  ribbing  until  about  3  ins.  from  beg.,  22  rows; 
always having an even number of rows. Break A. With B, work 
same number of rows as for first stripe. Break B.  
Repeat  these  2  stripes  until  scarf  measures  63  ins.  from  beg., 
end with an A stripe, having 11 A stripes and 10 B stripes. Bind 
off in ribbing.  
 

Digital Restoration © 2009 Purple Kitty LLC 36


Style No. 139 
(Continued from Page 36) 
 
Row 5 ‐ Slip 1 st, work ribbing to end.   First  dec.  row  ‐  Work  ribbing  to  within  2  sts  of  marker,  slip,  k 
Row 6 ‐ Work ribbing to within 19 sts of end, turn.   and pass, slip marker, slip, k and pass, work ribbing to end; 51 
Row 7 ‐ Slip 1 st, work ribbing to end.   sts.  
Row 8 ‐ Work ribbing to within 25 sts of end, turn.   Next row ‐ Work to within 2 sts of marker, p 2, slip marker, p 1, 
Row 9 ‐ Slip 1 st, work ribbing to end.  work to end.  
Rows 10 and 11 ‐ Work even in ribbing.   2nd dec. row ‐ Work ribbing to within 2 sts of marker, p 2 tog., 
Row 12 ‐ Same as row 8.   slip marker, slip, k and pass, work ribbing to end; 49 sts.  
Row 13 ‐ Same as row 7.   Next row ‐ Work even in ribbing. Repeat last 4 rows 4 times, 20 
Row 14 ‐ Same as row 6.   rows; 33 sts. Break A.  
Row 15 ‐ Same as row 5.   With  B,  repeat  last  20  rows  once;  13  sts.  Work  1  row  even  in 
Row 16 ‐ Same as row 4.   ribbing.  
Row 17 ‐ Same as row 3.   Final dec. row ‐ K 1, * k 2 tog., repeat from * 5 times; 7 sts.  
Row 18 ‐ Same as row 2.   Next row ‐ Work same as row 1 of rib pat. Work even in ribbing 
Row 19 ‐ Same as row 3.   until  tie‐string  is  same  length  as  first  tie‐string.  Bind  off  in 
Row 20 ‐ Work even in ribbing. Break B.   ribbing.  
With A, work even in ribbing for 20 rows, end with row 2 of rib  FINISHING  ‐  Sew  in  all  ends  neatly  matching  stripes.  Fold  at 
pat. Break A.   center and block stretching to 7 ins. wide at center back. Block, 
With B, work 1 row even in ribbing ‐ wrong side.   see page 3.  

 
 
 
Style No. 148 
 
MATERIALS: BOTANY NYLON and WOOL SPORT, 7‐1 oz. skeins. 
or BOTANY CLASSIC SPORT, 6‐1 oz. skeins  
 
KNITTING NEEDLES: "Boye" 10‐in. Double Pointed Non‐
Inflammable Needles, 2 pairs Size 2  
‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
 
GAUGE: 10 sts = 1 inch To check gauge, see page 3.  
 
FRONT ‐ Cast on 120 sts. Work k 1, p 1 ribbing until 10 ins. from 
beg.  
Shoulders ‐ Bind off 30 sts at beg. of each of next 2 rows. Place 
remaining 60 sts on holder.  
BACK ‐ Work same as front.  
NECK  ‐  Take  up  120  sts  and  divide  evenly  on  3  needles. 
Continue k 1, p 1 ribbing for 4 ½ ins. Bind off.  
FINISHING  ‐  Sew  shoulder  seams.  From  right side,  work  1 row 
sc on side edges. Steam, see page 3. 
 
 

Digital Restoration © 2009 Purple Kitty LLC 37


Style No. 128 (Continued from Page 21) 
 
Armholes  ‐  Continuing  pat.,  bind  off  6  sts  at  beg.  of  each  of  turning  ridge,  end  with  pat.  row  12.  Bind  off  6  sts  at  beg.  of 
next  2  rows.  Dec.  1  st  each  side  every  2nd  row  6  (6‐9)  times,  each of next 2 rows. Dec. 1 st each side every 2nd row 17 (18‐
with  care  to  carry  out  pat.;  77  (83‐89)  sts.  Work  even  until  19) times; 35 sts. Continue pat., decreasing 1 st each side every 
about 7 ins. above marker, end on wrong side with pat. row 8.   row 12 times; 11 sts. Bind off.  
Divide for Neck ‐ Work 24 (26‐28) sts; place next 29 (31‐33) sts  BACK HALF OF COLLAR ‐ Beg. at right shoulder seam, from right 
on  holder  for  neck  and  remaining  24  (26‐28)  sts  on  holder  for  side, with size 6 needles and A, pick up and k 20 (21‐22) sts on 
left side. Continue pat., with care to carry out pat., decreasing 1  side  edge  of  neck,  take  up  and  work  29  (31‐33)  sts  of  neck, 
st  at  neck  edge  every  2nd  row  4  times;  20  (22‐24)  sts.  Work  twisting the B sts as before, pick up and k 20 (21‐22) sts on side 
even  until  8  ¼  (8  ½‐8  ¾)  ins.  above  marker,  end  at  armhole  edge of neck to shoulder seam; 69 (73‐77) sts. 
edge.   Row 1 ‐ K 1, * p 1, k 1; repeat from * to end.  
Shoulder Shaping ‐ Bind off 5 (4‐6) sts at beg. of next row. Bind  Row 2 ‐ P 1, * k 1, p 1; repeat from * to end.  
off  5  (6‐6)  sts  at  beg.  of  each  of  next  3  rows  worked  from  Row 3 ‐ Same as row 1.  
armhole  edge,  with  care  to  carry  out  pat.  Beg.  at  neck  edge,  Continuing ribbing, dec. 1 st at end of each of next 16 rows; 53 
work left side to correspond to right side.   (57‐61) sts. Work 3 rows even.  
FRONT ‐ With size 4 needles and A, cast on 101 (107‐119) sts.  Continuing ribbing, inc. 1 st at end of each of next 16 rows; 69 
Work same as back. Sew shoulder seams.   (73‐77) sts. Work 3 rows even.  
SLEEVES ‐ With size 4 needles and A, cast on 47 sts. Work facing  Bind off in ribbing 
and turning ridge as on back. Break A. With size 6 needles, work  FRONT HALF OF COLLAR ‐ Work same as back half.  
first 16 rows of pat. Break B. With C, k 2, repeat between *'s of  FINISHING  ‐  Weave  in  all  ends  on  wrong  side.  Sew  underarm 
pat. row 29, end last repeat k 2.   and  sleeve  seams,  matching  pat.  stripes.  Sew  in  sleeves  with 
Inc. row ‐ P, increasing 16 (18‐20) sts evenly spaced across row;  seam  at  underarm  seam,  matching  pat.  stripes.  Turn  under 
63 (65‐67) sts. Beg. with pat. row 31, inc. 1 st each side; 65 (67‐ facings  and  hem  on  wrong  side.  Sew  collar  seams.  Block,  see 
69) sts. Continue pat., increasing 1 st each side every 8th row 8  page 3.  
times;  81  (83‐85)  sts.  Work  even  until  about  15  ½  ins.  above 
 
 
Style No. 141 (Continued from Page 14) 
 
Row 2 ‐ Work k 1, p 1, for 11 (15) sts for seed st, * k 1, p 1; slip  Repeating last 6 rows of pat. on 45 (51) sts on each side of 19 
next  2  sts  to  hook,  hold  at  back  of  work,  k  next  2  sts,  k  2  sts  sts of center panel between markers, work pat. on center 19 sts 
from hook, slip next 2 sts to hook, hold at front of work, k next  as follows:  
2 sts, k 2 sts from hook‐a double cable twist, p 1, k 1, p 5 (7) sts,  Pattern for 19 center panel sts  
k 1, p 1, work double cable twist on next 8 sts, p 1, k 1 *, work k  Row 7 ‐ Work 45 (51) sts; slip marker, p 1, k 4, p 2, k 2, work 5 
1, p 1, for 5 sts for seed st, slip marker to right needle, k 1, p 3,  sts  in  next  st  as  before  for  popcorn,  k  2,  p  2,  k  4,  p  1,  slip 
yarn  to  back;  slip  next  4  sts  to  right  needle,  k  in  back  loop  of  marker, work 45 (51) sts.  
next st, then slip the 4 sts slipped to right needle over the last st  Row 8 ‐ Work 45 (51) sts; slip marker, k 1, p 3, slip next p st to 
knitted  ‐  this  completes  popcorn;  p  2,  slip  next  3  sts  to  hook,  hook, hold at back, k next 2 sts, p st from hook, p 2, complete 
hold  at  front  of  work,  k  next  2  sts,  slip  p  st  from  hook  to  left  popcorn as before, p 2, slip next 2 sts to hook, hold at front, p 
needle  and  p  this  st,  k  2  sts  from  hook,  p  2,  slip  next  4  sts  to  1, k 2 sts from hook, p 3, k 1, slip marker; work 45 (51) sts.  
right  needle  and  complete  popcorn  as  before;  p  3,  k  1,  slip  Row 9 ‐ Work 45 (51) sts; slip marker, p 1, k 3, p 2, k 7, p 2, k 3, 
marker to right needle; work k 1, p 1 for 5 sts for seed st; repeat  p 1, slip marker; work 45 (51) sts.  
between * s once, work k 1, p 1 to end.   Row 10 ‐ Work 45 (51) sts; k 1, p 2, slip next p st to hook, hold 
Row 3 ‐ Work same as row 1 to first marker, slip marker to right  at back, k next 2 sts, p st from hook, p 7, slip next 2 sts to hook, 
needle,  p  1,  k  6,  p  2,  k  1,  p  2,  k  6,  p  1,  slip  marker  to  right  hold at front, p 1, k 2 sts from hook, p 2, k 1; work 45 (51) sts.  
needle, beg. from 2nd marker, complete as for row 1.   Row 11 ‐ Work 45 (51) sts; p 1, k 2, p 2, k 2, work 5 sts in next 
Row 4 ‐ Work seed st for 11 (15) sts, * k 1, p 1, k 8, p 1, k 1, p 1,  st, k 3, work 5 sts in next st, k 2, p 2, k 2, p 1; work 45 (51) sts.  
k  3  (5),  p  1,  k  1,  p  1,  k  8,  p  1,  k  1  *,  work  5  sts  seed  st,  slip  Row 12 ‐ Work 45 (51) sts; k 1, p 1, slip next p st to hook, hold 
marker; k 1, p 5, slip next p st to hook, hold at back, k next 2 sts,  at back, k next 2 sts, p st from hook, p 2, complete popcorn, p 
p st from hook, p 1, slip next 2 sts to hook, hold at front, p 1, k 2  3, complete popcorn, p 2, slip next 2 sts to hook, hold at front, 
sts  from  hook,  p  5,  k  1,  slip  marker;  work  5  sts  in  seed  st;   p 1, k 2 sts from hook, p 1, k 1; work 45 (51) sts.  
repeat   between * s once, work seed st to end.    
Row 5 ‐ Work same as row 1 to first marker, slip marker, p 1, k   (Continued on Next Page)
5,  p  2,  k  3,  p  2,  k  5,  p  1,  slip  marker,  beg.  from  2nd  marker, 
complete as for row 1.  
Row 6 ‐ Same as row 4 to first marker, slip marker; k 1, p 4, slip 
next p st to hook, hold at back, k next 2 sts, p st from hook, p 3, 
slip next 2 sts to hook, hold in front, p 1 st, k 2 sts from hook, p 
4, k 1, slip marker, work 5 sts in seed st, k 1, p 1, k 8, p 1, k 1, p 
1,  k  3  (5),  p  1,  k  1,  p  1,  k  8,  p  1,  k  1,  work  seed  st  to  end. 

Digital Restoration © 2009 Purple Kitty LLC 38


Style No. 141 (Continued from Page 38) 
 
Row 13 ‐ Work 45 (51) sts; p 1, k 1, p 2, k 11, p 2, k 1, p 1; work  Work even in pat. until about 11 ½ (15) ins. above ribbing, end 
45 (51) sts.   on wrong side with pat. row 9. Mark for underarm.  
Row 14 ‐ Work 45 (51) sts; k 1, p 1, k 2, p 11, k 2, p 1, k 1; work  Armhole and Shoulder Shaping ‐ Bind off 12 (15) sts at beg. of 
45 (51) sts.   each of next 2 rows; 85 (91) sts. Work even with care to keep 
Row 15 ‐ Work 45 (51) sts; p 1, k 1, p 2, k 3, work 5 sts in next  pat. until 8 (9) ins. above marker, end with pat. row 17 (1). Bind 
st, k 3, work 5 sts in next st, k 3, p 2, k 1, p 1 ; work 45 (51) sts,   off 9 (10) sts at beg. of each of next 4 rows; 49 (51) sts.  
Row 16 ‐ Work 45 (51) sts; k 1, p 1, slip next 2 sts to hook, hold  COLLAR ‐ With size 4 needles, work k 1, p 1 ribbing for 7 rows. 
at front, p next st, k 2 from hook, p 2, complete popcorn, p 3,  With size 8 needles, continue ribbing, increasing 1 st at end of 
complete  popcorn,  p  2,  slip  next  p  st  to  hook,  hold  at  back,  k  each  of  next  30  (32)  rows;  79  (83)  sts.  Bind  off  loosely  in 
next 2 sts, p st from hook, p 1, k 1; work 45 (51) sts.   ribbing.  
Row 17 ‐ Work 45 (51) sts; p 1, k 2, p 2, k 9, p 2, k 2, p 1; work  FRONT ‐ With size 4 needles, cast on 108 (120) sts. Work same 
45 (51) sts.   as back.  
Row 18 ‐ Work 45 (51) sts; k 1, p 2, slip next 2 sts to hook, hold  SLEEVES ‐ With size 4 needles, cast on 52 (56) sts. Work k 1, p 1 
at  front,  p  next  st,  k  2  from  hook,  p  7,  slip  next  p  st  to  hook,  ribbing for 3 (4) ins. increasing 11 sts evenly spaced across last 
hold at back, k next 2 sts, p st from hook, p 2, k 1; work 45 (51)  row; 63 (67) sts.  
sts.   Pattern ‐ Row 1 ‐ wrong side ‐ With size 8 needles, work seed st 
Row 19‐Work 45 (51) sts; p 1, k 3, P 2, k 3, work 5 sts in next st,  on first 5 (7) sts, *p 1, k 1, p 8, k 1, p 1 *, work 5 seed sts, place 
k 3, p 2, k3,p 1; work 45 (51) sts.   marker  on  needle,  work  next  19  sts  same  as  pat.  row    1  of 
Row 20 ‐ Work 45 (51) sts; k 1, p 3, slip next 2 sts to hook, hold  center panel on back, place 2nd marker on needle, work 5 seed 
at front, p next st, k 2 from hook, p 2, complete popcorn, p 2,  sts, repeat between *s once, work seed st to end.  
slip next p st to hook, hold at back, k next 2 sts, p st from hook,  Row  2‐Work  seed  st  on  first  5  (7)  sts,  *  k  1,  p  1,  work  double 
p 3, k 1; work 45 (51) sts.   cable twist on next 8 sts, p 1, k 1 *, work 5 seed sts, work next 
Row 21 ‐ Work 45 (51) sts; p 1, k 4, p 2, k 5, p 2, k 4, p 1; work  19 sts same as pat. row 2 of center panel on back, work 5 seed 
45 (51) sts.   sts;  repeat  between  *'s  once,  work  seed  st  to  end.  Continue 
Row 22 ‐ Work 45 (51) sts; k 1, p 4, slip next 2 sts to hook, hold  pat.  on  53  center sts  as  for  center  sts  on  back;  increasing  1  st 
at  front,  p  next  st,  k  2  from  hook,  p  3,  slip  next  p  st  to  hook,  each  side  every  10th  row  7  (6)  times;  every  6th  row  6  (10) 
hold at back, k next 2 sts, p st from hook, p 4, k 1; work 45 (51)  times, working added sts in seed st; 89 (99) sts, Work even until 
sts.   16  (18)  ins.  above  ribbing.  Mark  for  underarm.  Work  even  for 
Row 23 ‐ Work 45 (51) sts; p 1, k 5, p 2, k 3, p 2, k 5, p 1 work 45  14 (16) rows. Bind off 6 (7) sts at beg. of each of next 6 rows. 
(51) sts.   Bind off 53 (57) sts.  
Row 24 ‐ Work 45 (51) sts; k 1, p 5, slip next 2 sts to hook, hold  FINISHING  ‐  Sew  seams  on  pullover  and  collar.  Sew  sleeve 
at  front,  p  next  st,  k  2  from  hook,  p  1,  slip  next  p  st  to  hook,  seams to underarm markers. Sew rows worked even on sleeve 
hold  at  back,  k  2,  p  st  from  hook,  p  5,  k  1;  work  45  (51)  sts.  to  bound‐off  sts  of  armhole  and  shaped  edge  of  sleeve  to 
Repeat these 24 rows for pat.   straight  edge  of  armhole,  easing  in  fulness  evenly.  Block,  see 
page 3.  
 
 
Style No.  120 (Continued from Page 6) 
 
  Sizes  34  36  38  40  42 
Work even in ribbing on remaining 9 sts for  ins.  2 ½  2 ¾  3  3  3 ¼ 
Bind off in ribbing.             
RIGHT FRONT ‐ Cast on for lower edge  sts  65  69  73  75  79 
FOR WOMAN'S CARDIGAN ‐ Work ribbing as on left front              
until 5 rows from beg., end on wrong side.              
Buttonhole rows ‐ Row 1 ‐ Work 3 sts, bind off 3 sts for buttonhole, finish row.             
Row 2 ‐ Work across, casting on 3 sts over buttonhole, continue ribbing until 10 rows              
from beg., end on right side.             
FOR MAN'S CARDIGAN ‐ Work ribbing as on left front for 10 rows, end on right side.              
FOR WOMAN'S OR MAN'S CARDIGAN ‐ Inc. row ‐ wrong side ‐ Continue ribbing,              
increasing  sts  4  4  3  4  4 
evenly spaced across row  sts  69  73  76  79  83 
Next row ‐ Work ribbing on first 9 sts, k to end. Continue to correspond to left front              
until 6 ½  ins. from beg., end on wrong side.              
Front dec. row ‐ Work 9 sts ribbing, slip, k and pass, k to end. Complete to correspond to left front (repeating buttonhole rows on Woman's 
cardigan every 23rd and 24th row twice) ; shaping armhole as for left armhole of back.  
FINISHING ‐ Sew underarm and shoulder seams. Sew ends of front borders tog. and sew inner edge to back of neck. Join yarn with slip st at 
lower edge of right front, from right side, * ch 1, skip 1 row, 1 slip st in end of next row; repeat from * up right front, around neck and down 
left front to lower edge, with care to keep work flat. Fasten off. Work same edging around armholes. Work buttonholes in blanket st. Steam, 
see page 3.  
 

Digital Restoration © 2009 Purple Kitty LLC 39


Style No. 150 (Continued from Page 20) 
        
Raglan Shaping ‐ Continuing buttonholes, bind off 2 (3‐3) sts at  Inc. row ‐ K, increasing 5 (7‐7) sts evenly spaced across row; 25 
beg. of next row. K 1 row, p 1 row.   (27‐29) sts. With size 15 needles, work stockinette st ‐ p 1 row, 
Dec. row ‐ Work to within 3 sts of end, k 2 tog., k 1. Work 1 row  k 1 row ‐ for 5 rows.  
even.  Repeat  last  2  rows  8  (9‐10)  times,  end  on  wrong  side  6  2nd Inc. row ‐ Inc. 1 st in first st, k to within 2 sts of end, inc. 1 
rows above 6th buttonhole; 16 (16‐17) sts.   st  in  next  st,  k  1;  27  (29‐31)  sts.  Continue  stockinette  st 
Neck Shaping ‐ Work 7  (7‐8) sts and place on holder for neck,  repeating  2nd  inc.  row  every  6th  row  twice;  31  (33‐35)  sts. 
work to end repeating raglan dec.; 8 sts. P 1 row.   Work  even  until  8  (7  ½‐7  ½)  ins.  above  cuff,  end  with  p  row. 
Next row ‐ Slip, k and pass, work to end repeating raglan dec.; 6  Repeat inc. row; 33 (35‐37) sts. Repeat inc. row every 2nd row 
sts. P 1 row.   2  (3‐3)  times;  37  (41‐43)  sts.  P  1  row,  k  1  row.  Work  raglan 
Repeat  last  2  rows  once;  4  sts.  Work  2  more  rows  working  shaping  as  on  back,  end  with  p  row;  5  sts.  Place  on  holder. 
raglan dec. only; 3 sts.   Break yarn. Sew raglan seams, joining sleeves to back and front. 
Next row ‐ K 2 tog., k 1; 2 sts. P 1 row. Place on holder for neck.   Sew underarm and sleeve seams.  
LEFT FRONT ‐ With size 13 needles, cast on 23 (25‐27) sts, work  NECK  RIBBING  ‐  Beg.  at  left  front  edge,  with  size  13  needle, 
ribbing  as  on  right  front,  omitting  buttonhole,  end  with  row  take up 7 (7‐8) front neck sts, 2 sts of left front, 5 sts of sleeve, 
worked on wrong side underarm edge.   11 sts of back,S sts of sleeve, 2 sts of right front; with free size 
Inc. row ‐ K, increasing 4 sts evenly spaced across first 17 (19‐ 13 needle, beg. at right front, take up 7 (7‐8) front neck sts, join 
21) sts, work ribbing on last 6 sts for front border. With size 15  yarn and pick up and k 5 sts on right neck edge, continue across 
needles, work to correspond to right front up to neck shaping,  as follows: k 1, k 2 tog., k 3, k 2 tog., k 9, k 2 tog., k 3, k 2 tog., k 
working  raglan  shaping  as  on  right  side  of  back,  omitting  1, pick up and k 5 sts on left side of neck, k 1 (1‐2), work ribbing 
buttonholes, end on wrong side, underarm edge; 16 (16‐17) sts.   to end; 45 (45‐47) sts.  
Neck  Shaping  ‐  K  1,  slip,  k  and  pass,  k  to  within  7  (7‐8)  sts  of  Next row ‐ Work ribbing on all sts. Work 7th buttonhole in next 
end, place last 7 (7‐8) sts on holder for neck. Continuing raglan  2 rows. Work 2 rows more. Bind off. Do not break yarn.  
shaping,  k  2  tog.  at  end  of  k  rows  for  neck  shaping  every  2nd  From right side, work 1 row sc on left front edge, working 1 sc 
row twice, end with p row; 3 sts.   in  every  2nd  row.  Fasten  off.  Beg.  at  lower  right  front  edge, 
Next row ‐ K 1, slip, k and pass; 2 sts. P 1 row. Place on holder  from right side, work 1 row sc on right front edge to correspond 
for neck. Break yarn.   to left front.  
SLEEVES ‐ With size 13 needles, cast on 20 (20‐22) sts. Work k  FINISHING ‐ Finish buttonholes in blanket st. Steam, see page 3.
1, p 1 ribbing for 5 rows, about 1 ½ ins.  
  
 
 
Style No. 135 (Continued from Page 18) 
 
COLLAR ‐ With larger size needles, from right side, pick up and k  Inc.  row  ‐  Inc.  1 st  in  first  st,  *  p  1,  inc.  1 st  in  next  st;  repeat 
42  (42‐44)  sts  on  right  side  edge  of  neck;  19  sts  on  back  neck  from * to end; 47 (50‐53) sts.  
edge; 42 (42‐44) sts on left side edge; 103 (103‐107) sts. Work  Next  row  ‐  P  1,  *  k  1,  p  1;  repeat  from  *  to  end.  Continue 
ribbing as on pocket borders for 5 ins. Bind off in ribbing.   ribbing  as  before  until  4  ins.  from  beg.  Bind  off  loosely  in 
FROGS  ‐  With  smaller  size  needles,  cast  on  4  sts.  P  1  row,  k  1  ribbing.  
row for 11 rows, end with p row.   FINISHING ‐ Sew underarm and sleeve seams. Turn back hems 
Row 12 ‐ K 2, k 2 tog.   along turning ridge and hem to wrong side. Turn back 2 ½ sts of 
Bend  cast‐on  end  around  into  a  loop,  with  right  side  toward  front  edges  and  hem  to  wrong  side.  Sew  edges  of  collar  to 
you, pick up and k 4 sts in the 4 cast‐on sts; 7 sts.   bound‐off  sts  of  neck  with  bound‐off  edge  of  collar  even  with 
Next row ‐ wrong side ‐ P 3, k 1, p 3. On following row k 3, p 1, k  front  edges.  Sew  in  sleeves  with  sleeve  seam  at  center 
3.  Repeat  these  2  rows  for  4  ½  ins.,  slightly  stretched,  end  on  underarm. Sew pocket linings to wrong side with lower edge at 
wrong side. On next row, k 4, place remaining 3 sts on holder.  top  of  hem  on  lower  edge  of  fronts.  Sew  ends  of  pocket 
Work  8  rows  even  in  stockinette  st,  end  with  k  row.  P  2,  p  2  borders to right side. Steam seams. Sew edges of Angora collar 
tog.; break yarn, leaving a 10‐in. end for weaving. Bend around  facing to collar as illustrated, sewing cast on edge to neck edge, 
into a loop and weave last 3 sts to 3 sts on holder. Sew edges of  ends  to  front  neck  edge  and  bound‐off  edge  1  ¼  ins.  from 
loops tog. on wrong side. Make 3 frogs.   bound‐off edge of collar. Sew seams of cuff linings. Sew bound‐
  off  edge  of  cuff  lining  to  wrong  side  of  sleeves  4  ½  ins.  above 
GAUGE:   Angora‐5 sts = 1 inch   turning ridge. With top frog over seam of right front neck edge, 
13 rows = 2 inches   lower frog 1 in. above pocket border, center frog spaced evenly 
COLLAR FACING ‐ With smaller size needles and Angora, cast on  between, sew frogs on right front as illustrated, sewing with 2 
103  (103‐107)  sts.  Work  ribbing  as  on  pocket  borders  for  3  ¾  strands  of  Silk  Tweed  through  p  rib  at  center  of  frog  leaving 
ins. Bind off in ribbing.   edges  free  to  roll  over.  Sew  3  buttons  on  left  front  opposite 
CUFF LININGS ‐ With smaller size needles and Angora, cast on  frogs, with right front overlapping 5 ins. Sew a button in loop at 
31  (33‐35)  sts  for  lower  edge.  Work  ribbing  as  on  pocket  end of each frog on right front. Sew seam binding over shoulder 
borders  for  3  ins.,  end  on  right  side  with  plat  beg.  and  end  of  seams. Use shoulder pads.  
row.  

Digital Restoration © 2009 Purple Kitty LLC 40


Style No. 125 (Shown on Page 9)  
Sizes 12, 14, 16. 
 
Instructions are for size 12, changes for sizes 14 and 16 are in parentheses, see body measurement chart, page 3.  
         
  Size 12   Size 14   Size 16  
MATERIALS: BOTANY SAXATONES, 1 oz. skeins   7 skeins   8 skeins   9 skeins  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 3 – 
OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Aluminum Needles, Size 1 for ribbing.  
GAUGE: Size 3 Needles‐  
  8 sts = 1 inch   21 rows = 2 inches  
To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
At bustline   inches   34   36   38  
Width of back at underarm   inches   17   18   19  
Width of sleeves at underarm   inches   12   12 ½    13  
 
BACK ‐ With size 1 needles, cast on 108 (116‐124) sts. Work k 1,  FRONT ‐ Same as back.  
p  1  ribbing  for  3  ins.  Continuing  ribbing,  inc.  14  sts  evenly  SLEEVES ‐ With size 1 needles, cast on 68 (72‐76) sts. Work k 1, 
spaced across row; 122 (130‐138) sts.   p 1 ribbing for 3 ins. Continuing ribbing, inc. 8 sts evenly spaced 
With  size  3  needles,  work  stockinette  st  ‐  k  1  row,  p  1  row‐ across row; 76 (80‐84) sts.  
increasing 1 st each side every 1 in. 7 times; 136 (144‐152) sts.  With  size  3  needles,  work  stockinette  st  increasing  1  st  each 
Work even until 8 ins. above ribbing. Mark for underarm.   side every 1 in. 10 times; 96 (100‐104) sts. Work even until 11 
Armholes ‐ Bind off 5 (6‐7) sts at beg. of each of next 2 rows.  ins. above ribbing. Bind off 5 (6‐7) sts at beg. of each of next 2 
Dec.  1  st  each  side  every  2nd  row  11 (12‐13)  times;  104  (108‐ rows. Dec. 1 st each side every 2nd row 24 (25‐26) times; every 
112) sts. Work even until 5 ¾ (6‐6 ¼) ins. above marker, end on  row 6 times. Bind off 26 sts.  
right side.   BACK NECK RIBBING ‐ With size 1 needle, from right side, pick 
Divide  for  Neck  ‐  P  36  (38‐40)  sts,  place  on  holder,  p  32  sts,  up  and  k  17  sts  on  left  side  of  neck  edge,  k  the  32  sts  from 
place  on  another  holder  for  neck  ribbing,  p  36  (38‐40)  sts.  holder, pick up and k 17 sts on right side of neck edge; 66 sts. 
Continue on right side decreasing 1 st at neck edge every row 8  Work k 1, p 1 ribbing for 3 ins. Bind off loosely in ribbing. Work 
times;  28  (30‐32)  sts.  Work  even  until  6  ¾  (7‐7  ¼)  ins.  above  front neck ribbing in same way.  
marker, end on wrong side.   FINISHING  ‐  Sew  seams.  Sew  in  sleeves  matching  seams.  Sew 
Shoulder ‐ Bind off 4 (6‐8) sts at beg. of next row. Bind off 6 sts  half of collar seams from right side for turnback. Turn back half 
at beg. of each of next 4 rows worked from armhole edge. Beg.  of  neck  and  sleeve  ribbing  to  wrong  side.  Block,  see  page  3. 
at neck edge, work left side to correspond.  
 
Style No. 142 (Shown on Page 19) 
 
MATERIALS: BOTANY SAXATONES, 2, 1‐oz. skeins.  
 
KNITTING NEEDLES: 1 pair "Boye" Aluminum Needles, Size 3 ‐ OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW. 
1 pair "Boye" Aluminum Needles, Size 0 for ribbing.  
 
GAUGE: Size 3 Needles ‐ 8 sts = 1 inch To check gauge, see page 3.  
 
NECKBAND ‐ With size 0 needles, cast on 108 sts. Work k 1, p 1  Repeat  last  2  rows  until  there  are  only  30  sts  on  needle,  end 
ribbing for 3 ½ ins.   with p row. Slip these 30 sts on holder. Break yarn.  
Dividing row ‐ right side ‐ Work first 18 sts in ribbing and place  Border ‐ With right side facing you and size 0 needles, take up 
on holder, * inc. 1 st in next st, k 3; repeat from * 17 times; 90  and work 18 sts of ribbing, pick up and k 40 sts on right side of 
sts; slip last 18 sts of ribbing on holder.   Hood, take up and k 30 sts of center, pick up and k 40 sts on left 
Hood ‐ With size 3 needles, work in stockinette st ‐ p 1 row, k 1  side of Hood, take up and work 18 sts of ribbing; 146 sts. Work 
row  ‐  on  these  90  sts  until  8  ½  ins.  above  ribbing,  end  with  p  k 1, p 1 ribbing for 1 in. Bind off loosely in ribbing.  
row.   FINISHING  ‐  Beg.  at  lower  edge  of  right  front,  from  right  side, 
Top Shaping ‐ Row 1 ‐ K 59, slip, k and pass, turn.   work 8 sc, * ch 3 for buttonloop, skip 3 rows, work 4 sc; repeat 
Row 2 ‐ Slip 1, p 28, p 2 tog., turn.   from  *  twice,  ch  3,  skip  3  rows,  1  slip  st  at  neck  edge.  Fasten 
Row 3 ‐ Slip 1, k 28, slip, k and pass, turn.   off. Work 1 row sc on left front edge. Sew 4 buttons on left side 
opposite buttonholes. Block, see page 3. 

Digital Restoration © 2009 Purple Kitty LLC 41


Style No. 140 (Shown on Page 13) 
Instructions are for sizes 12, 14, 16 and 18, see body measurement chart, page 3 
 
  Sizes  12  14  16  18 
MATERIALS: BOTANY KNITTING WORSTED, 4 oz. skeins……………………………………………………………  skeins  5  5  6  6 
KNITTING NEEDLES: "Boye" Nylon Circular Needle, Size 4      
‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.      
"Boye" Non‐Inflammable Hook, Size G.      
GAUGE: 6 sts = 1 inch To check gauge, see page 3.     
MEASUREMENTS FOR BLOCKING:      
         Width at lower edge …………………………………………………………………………………………………………  inches  44  46  48  50 
         At hipline, 7 ins. below waistline ………………………………………………………………………………………  inches  34  36  38  40 
         At waistline ……………………………………………………………………………………………………………………….  inches  25  26 ½  28  30 
Instructions are for skirt 28 ins. in length. Make any necessary adjustment in length before     
first dec. round.      
With circular needle, cast on for facing …………………………………………………………………………………….  sts  252  264  276  288 
Join with care not to twist sts on needle. Mark end of rounds for center back of skirt.     
K around for 1 in. for facing.      
Inc. round ‐ * K …………………………………………………………………………………………………………………………  sts  20  21  22  23 
inc. 1 st in next st; repeat from * to end. ………………………………………………………………………………….  sts  264  276  288  300 
P 1 round for turning ridge. K around until 5 ins. above turning ridge     
First dec. round ‐ * K ………………………………………………………………………………………………………………..  sts  20  21  22  23 
k 2 tog.; repeat from * to end …………………………………………………………………………………………………..  sts  252  264  276  288 
K 4 ins. even. When measuring always include last dec. round in part worked even.      
2nd dec. round ‐ * K …………………………………………………………………………………………………………………  sts  19  20  21  22 
k 2 tog.; repeat from * to end …………………………………………………………………………………………………  sts  240  252  264  276 
Continue to dec. 12 sts in a round every 4 ins. twice, having 1 st less between decs.      
in each successive dec. round …………………………………………………………………………………………………..  sts  216  228  240  252 
Work even until 20 ins. above turning ridge or 8 ins. less than desired blocked length.     
5th dec. round – Hipline ‐ * K  ………………………………………………………………………………………………….  sts  16  17  18  19 
k 2 tog.; repeat frorn * to end …………………………………………………………………………………………………..  sts  204  216  228  240 
Continue to dec. 12 sts in a round every 1 ¼ ins. 4 times ……………………………………………………….  sts  156  168  180  192 
K 1 in. even.      
10th dec. round ‐ * K ……………………………………………………………………………………………………………….  sts  24  19  13  14 
k 2 tog.; repeat from * to end ………………………………………………………………………………………………….  sts  150  160  168  180 
Work even until 27 ins. above turning ridge or 1 in. less than desired blocked length     
Bind off.      
FINISHING‐Turn back facing along turning ridge and hem to wrong side. Make beading for     
elastic, see page 3. Block, stretching 1 in. in length, see page 3.  
BELT‐With circular needle, cast on 15 sts. Working back and forth on circular 
needle, work stockinette st‐p 1 row, k 1 row‐for   …………………………………………………………………….  ins.  30  31½  33  35 
Bind off.      
Fold cast‐on end of belt into a point and sew. Block, see page 3. Face belt with grosgrain ribbon, 2 ¼ ins. wide. Sew buckle on straight end of 
belt. 
              
Style No. 122 (Continued from Page 34) 
                            
  Sizes  12  14  16  18  20 
Shape same as armholes of back …………………………………………………………………………………….  sts  49  50  52  54  56 
P 1 row after last dec. row.              
Bind off 2 sts at beg. of each of next ……………………………………………………………………………….  rows  4  4  2  2  0 
Bind off 3 sts at beg. of each of next ……………………………………………………………………………….  rows  0  0  2  2  4 
Bind off 16 sts at beg. of each of next 2 rows.             
Work even on remaining …………………………………………………………………………………………………  sts  9  10  10  12  12 
for shoulder insert for …………………………………………………………………………………………………….  ins.  4  4 ¼  4 ½  4 ¾  4 ¾ 
end with k row. Place on holder for neck ribbing. Break yarn.              
Neck Ribbing ‐ Beg. at right front edge, with size 4 needle, take up from holder sts              
of front ……………………………………………………………………………………………………………………………  sts  19  20  20  20  22 
right shoulder insert ………………………………………………………………………………………………………..  sts  9  10  10  12  12 
back neck ………………………………………………………………………………………………………………………..  sts  26  26  26  26  30 
left shoulder insert   …………………………………………………………………………………………………………  sts  9  10  10  12  12 
left front   …………………………………………………………………………………………………………………………  sts  19  20  20  20  22 
Work ribbing as on left front for 3, rows on ……………………………………………………………………  sts  82  86  86  90  98 
Repeat buttonhole in next 2 rows. Work 4 rows even. Bind off tightly in ribbing.              
FINISHING  ‐  Sew  edges  of  shoulder  inserts  to  shoulder  edges.  Sew  shaped  edges  of  sleeves  to  armhole  edges  from  markers  up  with  decs. 
matching; sew bound‐off sts of sleeves to even part of armhole edge. Sew underarm and sleeve seams. Beg. at lower right front edge, from 
right side, work 1 row slip st on front edge to top of neck ribbing. Work 1 row slip st on left front edge. Block, see page 3. Face front edges with 
grosgrain ribbon. Finish buttonholes with blanket st working through double thickness.  

Digital Restoration © 2009 Purple Kitty LLC 42


Style No. 147 (Shown on Page 15) 
Size 8 ½ to 10 ½. 
 
MATERIALS:   BOTANY SAXATONES, 5‐1 oz. skeins.  
BUCILLA NYLON "HEEL 'n TOE" YARN, 1 card.  
 
KNITTING NEEDLES: 1 set "Boye" Aluminum Sock Needles, Size 1 ‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
 
GAUGE: 13 rounds = 1 inch  
 
CUFF ‐ Cast on 84 sts loosely; divide on 3 needles. Join, work k 1, p  dec.  on  each  row,  until  20  sts  remain.  Fasten  off  "Heel  'n  Toe" 
1 ribbing for 1 ½ ins.   Yarn.  
Leg ‐ Round 1 ‐ K 2, * p 2, k 4; repeat from * around, end p 2, k 2.  GUSSETS AND FOOT ‐ With same (heel) needle, pick up and k 16 
Place marker before next st for end of round. Carry up marker.   sts on side edge of heel; continue pat. on 32 instep sts and work to 
Repeat  round  1  for  pat.  Work  until  4½  ins.  from  ribbing,  end  at  1  needle;  with  free  needle,  pick  up  and  k  16  sts  on  other  side  of 
marker.   heel,  k  10  heel  sts  to  same  needle.  Mark  for  end  of  round  and 
* Dec. round ‐ K 2 tog., work pat. to within 2 sts of end of round,  center of sole.  
slip, k and pass. Work 8 rounds even. Repeat from * until there are  There will be 26 sts on each of first and 3rd needles, 32 sts on 2nd 
9 dec. rounds, purling 2 tog. on each side of marker on p ribs; 66  or instep needle. Work 1 round, containing pat. across instep sts.  
sts. Continue pat. until 12 ins. from ribbing, working to within 17  Next round ‐ K to within 3 sts of end of first needle, k 2 tog., k 1; 
sts of marker on last round. Slip last 17 sts and first 17 sts of round  work across instep needle, on 3rd needle, k 1, slip, k and pass, k to 
to 1 needle for heel and remaining 32 sts to 2 needles for instep. K  end. Repeat last 2 rounds 9 times; 64 sts. Continuing pat. on instep 
across heel needle, decreasing 2 sts evenly spaced across, turn; 32  sts, work even until foot measures 1¾ ins. less than desired length 
heel sts. Join "Heel 'n Toe" Yarn. Work heel with both strands.   from tip of heel, allowing these 1¾ ins. for toe.  
HEEL ‐ Row 1 ‐ wrong side ‐ Slip first st as to p, p to end.   There  will  be  16  sts  on  each  of  first  and  3rd  needles,  32  sts  on 
Row 2 ‐ * Holding both strands at back of work, slip 1 as to p, k 1;  instep  needle.  Join  "Heel  'n  Toe"  Yarn  and  work  toe  with  both 
repeat from * to end. Repeat rows 1 and 2 until 30 rows on heel,  strands.  
end with row 2.   TOE ‐ Beg. at center of sole, k to within 3 sts of end of first needle, 
Turn heel as follows: Wrong side ‐ Slip 1, p 18, p 2 tog., p 1, turn.  k 2 tog., k 1; on 2nd needle, k 1, slip, k and pass, k to within 3 sts of 
Slip 1, k 7, slip, k and pass, k 1, turn. Slip 1, p 8, p 2 tog., p 1, turn.  end of needle, k 2 tog., k 1; on 3rd needle, k 1, slip, k and pass, k to 
Slip 1, k 9, slip, k and pass, k 1, turn. Slip 1, P 10, p 2 tog., p 1, turn.  end. K 1 round even. Repeat last 2 rounds until 16 sts remain. K 4 
Continue  to  work  toward  sides  of  heel,  having  1  st  more  before  sts of first needle and slip to 3rd needle. Weave sole and instep sts 
tog., see page 47. Steam, see page 3.  
 
Style No. 141 (Shown on Page 17)  
 

MATERIALS: BOTANY KWILTEE, 1‐2‐oz. skein. 
 

KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 10 ½  ‐ OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
  GAUGE: 9 sts = 2 inches   5 rows = 1 inch  
 
Cast on 3 sts. Work even in garter st ‐ k all rows ‐ until 12 ins. from  Row 12 ‐ K 1, p 1 ribbing to within 2 sts of marker, k 5, work p 1, k 
beg. for tie string.   1 ribbing to end.  
Next Row ‐ Inc. 1 st in each of first 2 sts, k 1. K 1 row.   Row 13 ‐ K 2, work p 1, k 1 ribbing to within 3 sts of marker, inc. 1 
Inc.  row  ‐ Inc.  1  st  in  first  st,  k  to  within  2  sts  of  end,  inc.  1  st  in  st  in  next  st  as  to  p,  p  2,  slip  marker,  inc.  1  st  in  next  st  as  to  p, 
next st, k 1; 7 sts.   work p 1, k 1 ribbing across, end with k 2 instead of k 1; 19 sts.  
Pattern ‐ Row 1 ‐ wrong side ‐ K 2, p 3, k 2.   Repeat last 4 rows until there are 39 sts on needle. Work even in 
Row 2 ‐ K 1, p 1, k 3, p 1, k 1.   pat. for 12 rows, end on wrong side. Piece should measure about 
Row 3 ‐ K 1, inc. 1 st in next st, p 2, inc. 1 st in next st as to p, k 2; 9  9½ ins.  
sts.   First  dec.  row  ‐  right  side  ‐  K  1,  p  1  ribbing  to  within  3  sts  of 
Row 4 ‐ K 1, p 1, k 5, p 1, k 1.   marker, slip 1, p 1, pass slipped st over pst, k 3, k 2 tog., work p 1, 
Row 5 ‐ K 2, inc. 1 st in next st, p 2, inc. 1 st in  next st as to   p, p 1,  k 1 ribbing to end; 37 sts.  
k 2; 11 sts.   Next row ‐ K 2, work p 1, k 1 ribbing to within 3 sts of marker, p 5, 
Row 6 ‐ * K 1, p 1; repeat from * once, k 3, † p 1, k 1; repeat from  continue k 1, p 1 ribbing across, end with k 2.  
† once.   2nd dec. row ‐ K 1, p 1 ribbing to within 3 sts of marker, p 2 tog., k 
Row 7 ‐ K 2, p 1, inc. 1 st in next st as to k, p 2, inc. 1 st in next st as  3, p 2 tog., work k 1, p 1 ribbing to end.  
to p, k 1, p 1, k 2; 13 sts.   Next row ‐ K 2, work p 1, k 1 ribbing to within 2 sts of marker, p 3, 
Row 8 ‐ * K 1, p 1; repeat from * once, k 5, † p 1, k 1; repeat from  continue k 1, p 1 ribbing across, end k 2. Repeat last 4 rows until 9 
† once.   sts remain.  
Row 9 ‐ K 2, p 1, k 1, inc. 1 st in next st as to p, p 2, place a marker  Next row ‐ K 2, p 5, k 2.  
on needle, inc. 1 st in next st as to p, p 1, k 1, p 1, k 2; 15 sts. Carry  On following row, k 1, p 2 tog., k 3, p 2 tog., k 1; 7 sts.  
up marker.   K 1 row, decreasing 1 st each side; 5 sts.  
Row  10  ‐  Work  k  1,  p  1  ribbing  to  within  1  st  of  marker,  k  3,  K 1 row even.  
continue p 1, k 1 ribbing to end.   K 1 row, decreasing 1 st each side; 3 sts.  
Row 11 ‐ K 2, work p 1, k 1 ribbing to within 3 sts of marker, inc. 1  Work even in garter st on these 3 sts until tie string is same length 
st in next st as to k, p 2, slip marker, inc. 1 st in next st as to p, k 1,  as first tie string. Finish all ends neatly. Steam lightly, see page 3.  
p 1 ribbing to within 2 sts of end, k 2; 17 sts.  

Digital Restoration © 2009 Purple Kitty LLC 43


Style No. 144 (Shown on Page 13)  
Size 8 ½ to 10 ½. 
 
MATERIALS:   BOTANY SAXATONES, 1 oz. skeins.  
Color A ‐ 3 skeins   Color B ‐ 2 skeins   Color C ‐ 2 skeins  
BUCILLA HANOI‐WOOL, Art. 026.  
Color D ‐ 3 cards  
BUCILLA NYLON "HEEL 'n TOE" YARN, 1 card  
 
KNITTING NEEDLES: 1 set "Boye" Aluminum Sock Needles, Size 1 ‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
Yarn Bobbins.  
 
GAUGE: 9 sts = 1 inch   13 rows or rounds = 1 inch  
 
Note: Chart and instructions call for cross lines to be knitted in. Cross lines may be embroidered in duplicate st after sock is completed, in 
which case diamonds are worked in solid color and cross lines are embroidered after sock is completed. 
 
CUFF ‐ With A, cast on 86 sts. Using 2 needles only, work back  Place  15  sole  sts  on  each  of  2  needles  and  31  instep  sts  on  1 
and forth in k 1, p 1 ribbing for 1 ½ ins. increasing 1 st at end of  needle.  Join;  k  1  round  decreasing  1  st  at  center  of  instep. 
last row; 87 sts.   Discontinue  pattern.  K  around  on  these  60  sts  until  foot 
Wind 4 bobbins of A, 2 bobbins of B, 2 bobbins of C, 6 bobbins  measures  1  ¾  ins.  less  than  desired  length  from  tip  of  heel, 
of  D.  Use  separate  bobbins  for  each  change  of  color.  Do  not  allowing the 1 ¾ ins. for toe. Join "Heel 'n Toe" Yarn.  
carry colors across on wrong side of work except across single  TOE  ‐  Beg.  at  center  of  sale,  k  to  within  3  sts  of  end  of  first 
st  of  cross  lines.  To  prevent  a  hole  when  changing  colors,  needle, k 2 tog., k 1; on 2nd needle, k 1, slip, k and pass, k to 
always bring color to be used under last color used.   within 3 sts of end of needle, k 2 tog., k 1; on 3rd needle, k 1, 
LEG ‐ Argyle Pattern ‐ Row 1 ‐ right side  ‐ K 1 D, 13 A, 1 B, 13 A,  slip, k and pass, k to end. K 1 round. Repeat last 2 rounds until 
2 D, 13 A, 1 C, 13 A, 2 D, 13 A, 1 B, 13 A, 1 D.   16  sts  remain.  K  4  sts  of  first  needle  and  slip  to  3rd  needle. 
Row 2 ‐ P 1 A, 1 D, 11 A, 3 B, 11 A, 1 D, 2 A, 1 D, 11 A, 3 C, 11 A,  Weave sale and instep sts tog., see page 47.  
1 D, 2 A, 1 D, 11 A, 3 B, 11 A, 1 D, 1 A.   FINISHING ‐ Sew back seam matching pats. Sew seams at each 
Continue  pat.  shifting  colors  every  row  and  repeating  58  rows  side of foot. Steam, see page 3.  
of chart until 5 ½ ins. (70 rows) above ribbing;    
First dec. row ‐ K 1, slip, k and pass, work pat. to within 3 sts of   
end, k 2 tog., k 1.    
Repeat decs. every 6th row 10  times more; 65  sts. Work even 
following chart until about 11 ½ ins. (145) rows above ribbing. 
With A, p 17 sts, slip on extra needle for heel, work next 31 sts 
in  pat.  for  instep,  slip  remaining  17  sts  on  another  needle  for 
other half of heel. Continue pat. on 31 instep sts until there are 
2  complete  diamonds  on  instep  (58  rows).  Break  off  bobbins; 
sew in ends. Leave sts on needle.  
Slip 34 heel sts to 1 needle with side edges at center of needle. 
With A, k 1 row decreasing 4 sts evenly spaced across; 30 heel 
sts.  
Join "Heel 'n Toe" Yarn. Work heel with both strands.  
HEEL – Row 1 ‐ wrong side ‐ Slip first st as to p, p to end.  
Row 2 ‐ Holding both strands at back of work, * slip 1 as to p, k 
1; repeat from * to end.  
Repeat rows 1 and 2 until there are 30 rows.  
 
Turn  heel  as  follows:  Wrong  side  ‐  Slip  1,  p  16,  p  2  tog.,  p  1, 
turn. Slip 1, k 5, slip, k and pass, k 1, turn. Slip 1, P 6, p 2 tog., p 
1, turn. Slip 1, k 7, slip, k and pass, k 1, turn. Slip 1, p 8, p 2 tog., 
p 1, turn. Continue to work toward sides of heel, having 1 more 
st before dec. on each row until 18 sts remain. Fasten off.  
GUSSETS AND FOOT ‐ With free needle and A, from right side, 
pick up and k 15 sts on side edge of heel, k 9 sts of heel to same 
needle; with another needle, k remaining 9 heel sts, pick up and 
k  15  sts  on  other  side  of  heel  to  same  needle;  48  sts,  Turn,  p 
back  across  2  needles.  Turn;  k  1,  slip,  k  and  pass,  k  to  end  of 
first needle; k to within 3 sts of end of 2nd needle, k 2 tog., k 1. 
Repeat  last  2  rows  8  times  more;  30  sts.  Place  all  sts  on  1 
needle for sole. P 1 row, k 1 row until 58 rows from where sts 
were picked up on sides of heel.  

Digital Restoration © 2009 Purple Kitty LLC 44


Style No. 146 (Shown on Page 19 and 20) 
Size 8 ½ to 10 ½. 
 
MATERIALS: BOTANY NYLON 'n WOOL SPORT, 5 ‐ 1 oz. skeins.  
or BOTANY CLASSIC SPORT, 4 ‐ 1 oz. skeins.  
and BUCILLA NYLON "HEEL 'n TOE" YARN, 1 card.  
 
KNITTING NEEDLES: 1 set "Boye" Aluminum Sock Needles, Size 2 ‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
 
GAUGE: Stockinette St ‐ 8 sts = 1 inch  
 
LEG ‐ Cast on 56 sts loosely; divide on 3 needles. Join; work k 2, p 2  needle. Mark for end of round and center of sale. There will be 22 
ribbing for 7 ½ ins., end with p 1. Slip the last 28 sts worked to 2  sts on each of first and 3rd needles, 28 sts on 2nd or instep needle. 
needles for instep, leaving remaining 28 sts on 1 needle for heel. K  K 1 round.  
across  heel  needle,  decreasing  1  st  each  side;  26  sts.  Join  Nylon  Next round ‐ K to within 3 sts of end of first needle, k 2 tog., k 1; k 
"Heel 'n Toe" Yarn and work heel with both strands; turn.   across  instep  sts;  on  3rd  needle,  k  1,  slip,  k  and  pass,  k  to  end. 
HEEL ‐ From wrong side, slip 1 st as to p, p to end.   Repeat  last  2  rounds  until  52  sts  remain.  Work  even  until  foot 
Row 2 ‐ *Holding both strands at back of work, slip 1 st as to p, k  measures  1  ¾  ins.  less  than  desired  finished  length  from  tip  of 
1;  repeat  from  *  to  end.  Repeat  last  2  rows  until  there  are  28  heel, allowing 1 ¾ ins. for toe. Beg. at center of sole, place 13 sts 
rows; end with row 2.   on  each  of  first  and  3rd  needles  and  26  sts  on  2nd  needle.  Join 
Turn heel as follows: From wrong side, slip 1, p 14, p 2 tog., p 1,  "Heel 'n Toe" Yarn and work toe with both strands.  
turn. Slip 1, k 5, slip, k and pass, k 1, turn. Slip 1, p 6, p 2 tog., p 1,  TOE ‐ Beg. at center of sale, k to within 3 sts of end of first needle, 
turn. Slip 1, k 7, slip, k and pass, k 1, turn. Continue to work toward  k 2 tog., k 1; on 2nd needle, k 1, slip, k and pass, k to within 3 sts of 
sides of heel, having 1 st more before dec. on each row until 16 sts  end, k 2 tog., k 1; on 3rd needle, k 1, slip, k and pass, k to end. K 1 
remain. Fasten off "Heel 'n Toe" Yarn.   round even. Repeat last 2 rounds until 12 sts remain. K 3 sts of first 
GUSSETS AND FOOT ‐ With same needle, pick up and k 14 sts on  needle and slip to 3rd needle.  
side  edge  of  heel,  k  28  instep  sts  to  1  needle;  with  free  needle,  Weave sole and instep sts tog., see page 47. Steam, see page 3.  
pick  up  and  k  14  sts  on  other  side  of  heel,  k  8  heel  sts  to  same 
 
 

Style No. 145 (Shown on Page 17)  
Size 8 ½ to 10 ½. 
 
MATERIALS: BOTANY SAXATONES, 5‐1 oz. skeins.  
BUCILLA NYLON "HEEL 'n TOE" YARN, 1 card.  
 
KNITTING NEEDLES: 1 set "Boye" Aluminum Sock Needles, Size ‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
 
GAUGE: 9 sts = 1 inch   13 rounds = 1 inch  
 
CUFF ‐ Cast on 88 sts loosely. Divide on 3 needles. Join, work k 1,  Turn heel as follows:  Wrong side ‐ Slip 1, p 16, p 2 tog., p 1, turn. 
p1 ribbing for 2 ins. increasing 8 sts evenly spaced on last round;  Slip 1, k 5, slip, k and pass, k 1, turn. Slip 1, p 6, p 2 tog., p 1, turn. 
96 sts. Mark end of round.   Slip 1, k 7, slip, k and pass, k 1, turn. Slip 1, p 8, p 2 tog., p 1 , turn. 
LEG  ‐  Cable  Pattern  ‐  Round  1  ‐  K  3,  *  p  2,  k  6;  repeat  from  *  Continue  to  work  toward  sides  of  heel,  having  1  st  more  before 
around, end last repeat k 3.   dec. on each tow until 18 sts remain. Fasten off "Heel 'n Toe" Yarn.  
Repeat round 1 twice.   GUSSETS AND FOOT ‐ With same needle, pick up and k 16 sts on 
Cable Twist Round ‐ K 3, * p 2, slip next 3 sts to extra needle and  side  edge  of  heel;  work  pat.  across  32  sts  of  instep  to  1  needle; 
hold in front of work, k 3, k 3 sts from extra needle, p 2, k 6; repeat  with  free  needle,  pick  up  and  k  16  sts  on  other  side  of  heel,  k  9 
from * around, end  last repeat k 3.   heel sts to same needle. Mark for center of sale; there will be 25 
Repeat round 1, 7 times.   sts on each of first and 3rd needles; 32 sts on instep needle. Work 
Repeat last 8 rounds for pat. Work even in pat. until 4 ½ ins. above  1 round.  
cuff, end at marker.   Next round ‐ K to within 3 sts of end of first needle, k 2 tog., k 1; 
Dec. round ‐ K 2 tog., work to within 2 sts of end of round, slip, k  work  pat.  across  instep;  on  3rd  needle,  k  1,  slip,  k  and  pass,  k  to 
and  pass.  Continuing  pat.  repeat  dec.  round  every  4th  round  15  end.  Repeat  last  2  rounds  until  62  sts  remain,  having  15  sts  on 
times, working p 2 tog. on each side of marker when decreasing in  each  of  first  and  3rd  needles  and  32  sts  on  instep  needle. 
p  ribs;  64  sts.  Work  even  until  12  ½  ins.  above  ribbing,  end  at  Continuing pat. on instep needle, work even until foot measures 2 
center back. Work first 16 sts of round, slip last 32 sts worked to 1  ins.  less  than  desired  finished  length  from  tip  of  heel,  allowing 
needle for heel; slip remaining 32 sts to 2 needles for instep. Join  these 2 ins. for toe. Work 1 round decreasing 1 st at center of each 
Nylon  "Heel  'n  Toe"  Yarn  and  work  with  both  strands.  Turn,  cable  rib;  60  sts.  Join  "Heel  'n  Toe"  Yarn  and  work  toe  with  both 
working  on  heel  sts,  slip  1  st  as  to  p,  p  across  decreasing  1  st  in  strands.  
center of each cable rib; 30 sts.   TOE ‐ Round 1 ‐ Beg. at center of sole, k to within 3 sts of end of 
HEEL ‐ Row 1 ‐ right side ‐ * Holding both strands in back of work,  first needle, k 2 tog., k 1; on 2nd needle, k 1, slip, k and pass, k to 
slip 1 as to p, k 1; repeat from * to end.   within  3  sts  of  end,  k  2  tog.,  k  1;  on  3rd  needle,  k  1,  slip,  k  and 
Row 2 ‐ Slip first st  as to p, p to end. Repeat last 2 rows until there  pass,  k  to  end.  K  1  round  even.  Repeat  last  2  rounds  until  16  sts 
are 31 rows, end with row 1.   remain. K 4 sts of first needle and slip to 3rd needle.  
Weave sole and instep sts tog., see page 47. Steam, see page 3.  

Digital Restoration © 2009 Purple Kitty LLC 45


Style No. 121 (as seen on front cover) 
Instructions are for sizes 34, 36, 38, 40, 42 and 44, see body measurement chart, page 3. 
 
    WOMAN’S  MAN’S 
  Sizes  34  36  38  40  42  44 
MATERIALS: BOTANY SCOTTIE "SHETLAND and WOOL", 2 oz. skeins.  skeins  6  7  7  8  8  9 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 8               
                          ‐OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.               
                           1 pair "Boye" Non‐Inflammable Needles, Size 5 for ribbing.               
GAUGE: Size 8 Needles  ‐   5 sts = 1 inch     7 rows = 1 inch               
To check gauge, see page 3.               
MEASUREMENTS FOR BLOCKING:               
Chest ……………………………………………………………………………………………………… inches  34  36  38  40  42  44 
Width of back at underarm ……………………………………………………………………. inches  17  18  19  20  21  22 
BACK ‐ With size 5 needles, cast on …………………………………………………………………………...... sts  84  88  96  100  104  108 
Work k 2, p 2 ribbing for ………………………………………………………………………………………………. ins.  2 ½  2 ½  2 ½  3  3  3 
increasing in last row ……………………………………………………………………………………………………. sts  2  2  0  0  2  2 
With size 8 needles, work even in stockinette st‐k 1 row, p 1 row‐on ………………………. sts  86  90  96  100  106  110 
until measurement above ribbing is (end with p row) ………………………………………………….. ins.  13  13  13  13  13  13 
Mark for underarm.                
Armholes ‐ K and place on holder for underarm ………………………………………………………….. sts  7  7  8  8  8  8 
K ………………………………………………………………………………………………………………………………….. sts  72  76  80  84  90  94 
place on holder for underarm remaining ……………………………………………………………………… sts  7  7  8  8  8  8 
Work even on ………………………………………………………………………………………………………………. sts  72  76  80  84  90  94 
until measurement above marker is (end with p row) ………………………………………………….. ins.  8  8 ¼  8 ½  9 ½  10  10 ½ 
K and place on holder for right shoulder ………………………………………………………………………. sts  23  25  27  27  30  32 
k for neck …………………………………………………………………………………………………………………….. sts  26  26  26  30  30  30 
place on holder for left shoulder remaining …………………………………………………………………. sts  23  25  27  27  30  32 
Back Neck Ribbing ‐ Row 1 ‐ wrong side ‐ With size 5 needles, p 2, * k 2, p 2;               
repeat from * to end.                
Row 2 ‐ K 2, * p 2, k 2; repeat from * to end. Repeat these 2 rows until there are …... …. rows  8  8  8  10  10  10 
Bind off loosely in ribbing.                
FRONT ‐ Work same as back until measurement above marker is (end with p row)……… Ins.  6  6 ¼  6 ½  6 ¾  7 ¼  7 ¾ 
Divide for Neck ‐ K and place on holder for left side …………………………………………………….. sts  23  25  27  27  30  32 
k and place on holder for neck …………………………………………………………………………………….. sts  26  26  26  30  30  30 
Work even for right side on remaining …………………………………………………………………………. sts  23  25  27  27  30  32 
until armhole is same length as back, end with p row. Break yarn leaving a              
24‐in. end for weaving.               
Place on holder. Beg. at neck edge, work left side to correspond to right side.              
Weave shoulder sts tog., see page 47.               
FRONT NECK RIBBING ‐ Join yarn on left neck edge at shoulder.              
With size 5 needles, pick up and k on left side of neck …………………………………………………. sts  14  14  14  20  20  20 
take up and k ……………………………………………………………………………………………………………….. sts  26  26  26  30  30  30 
pick up and k on right side …………………………………………………………………………………………… sts  14  14  14  20  20  20 
Work ribbing for same number of rows as back neck ribbing on ………………………………..... sts  56  56  56  70  70  70 
Working first row on wrong side as for row 2 on back neck ribbing. Bind off loosely.               
LEFT SLEEVE ‐ With size 8 needles, beg. at left front underarm edge, take up and k              
left front underarm sts, pick up and k on left armhole edge (about 1 st in              
every 2nd row) …………………………………………………………………………………………………………..... sts  58  60  62  68  72  76 
take up and k back underarm sts. P 1 row on ………………………………………………………………. sts  72  74  78  84  88  92 
Dec. row ‐ K 2, slip, k and pass, k to within 4 sts of end, k 2 tog., k 2 ……………………………. sts  70  72  76  82  86  90 
Repeat dec. row every 2nd row ……………………………………………………………………………………. times  2  2  2  2  2  3 
every 10th row …………………………………………………………………………………………………………….. times  10  10  10  0  0  0 
every 12th row …………………………………………………………………………………………………………….. times  0  0  0  10  10  10 
Work even on ………………………………………………………………………………………………………………. sts  46  48  52  58  62  64 
until measurement from picked up row is (end with p row) …………………………………………. ins.  16½  16½  16½  19½  19½  19½ 
Next row ‐ K decreasing across row ……………………………………………………………………………… sts  2  4  4  2  2  4 
With size 5 needles, work k 2, P 2 ribbing on ……………………………………………………………….. sts  44  44  48  56  60  60 
for cuff for  ins.  3 ½  3 ½  3 ½  4  4  4 
Bind off in ribbing.                
RIGHT SLEEVE ‐ Beg. at back underarm edge, work right sleeve to correspond to              
left sleeve.               
FINISHING ‐ Sew underarm and sleeve seams sewing seam on right side for               
turn‐back of cuff, from lower edge for ………………………………………………………………………….  ins.  1 ¾  1 ¾  1 ¾  2  2  2 
Block, see page 3.                

Digital Restoration © 2009 Purple Kitty LLC 46


 
Style No. 137 (Shown on Page 31) 
 Sizes 10‐12 and 14‐16. 
Instructions are for size 10‐12, changes for size 14‐16 are in parentheses. 
 
MATERIALS:  BOTANY KNITTING WORSTED, 4 oz. skeins, Color A ‐ 4 skeins.  
BUCILLA HANDI‐YARN, ART. 028, Color B ‐ 2 cards for Cords.  
 
KNITTING NEEDLES: 1 pair "Boye" Non‐Inflammable Needles, Size 8  ‐ OR SIZE YOU REQUIRE TO KNIT TO GAUGE GIVEN BELOW.  
1 pair "Boye" Non‐Inflammable Needles, Size 4. "Boye" Steel Hook, Size 1.  
 
GAUGE: Size 8 Needles ‐ 6 rows = 1 inch To check gauge, see page 3.  
 
MEASUREMENTS FOR BLOCKING:  
Length from top to lower edge, measured on outer edge of leg, 36 inches.  
 
RIGHT  HALF  ‐  With  size  4  needles,  cast  on  77  (82)  sts  for  LEFT  HALF  ‐  With  size  4  needles,  cast  on  77  (82)  sts  for 
waistband.   waistband.  
Rib Pattern ‐ Row 1 ‐ wrong side ‐ K 2, * p 3, k 2; repeat from *  Work  rib  pat.  same  as  right  half  for  3  ins.,  end  on  wrong 
to end.   side.  
Row 2 ‐ P 2, * k 3, p 2; repeat from * to end.   With size 8 needles, work 1 row. Begin short rows.  
Repeat  these  2  rows  for  pat.  Work  pat.  even  until  3  ins.  from  Row 1 ‐ wrong side ‐ Work pat. for 7 sts, turn.  
beg., end on right side. With size 8 needles, work 1 row. Begin  Row  2  and  all even  numbered  rows  ‐  Slip  1,  work  pat.  to 
short rows.   end.  
Row 1 ‐ right side ‐ Work pat. for 7 sts, turn.   Continue  short  rows  to  correspond  to  right  half,  end  on 
Row 2 and all even numbered rows ‐ Slip 1, work pat. to end.   right side. Work 1 row from wrong side.  
Always work slip st tog. with st directly below to prevent a hole.   Inc.  row  ‐  Same  as  on  right  half.  Finish  left  half  to 
Row 3 ‐ Work pat. for 12 sts, turn.   correspond to right half.  
Row  5  ‐  Work  pat.  for  17  sts,  turn.  Continue  in  this  way,  FINISHING  ‐  Sew  leg  seams  from  lower  edge  to  crotch 
working  5  sts  more  every  2nd  row  3  (4)  times  more,  end  on  markers.  Sew  short  sides  tog.  from  crotch  to  top  of 
right  side,  turn.  Slip  1,  work  pat.  to  end.  This  completes  short  waistband  for  front  and  long  sides  tog.  for  back.  Make 
rows.   casing for elastic on waistband, see page 3. Block, see page 
Inc. row ‐ right side ‐ Inc. 1 st in first st, work pat. to within 1 st  3.  
of  end,  inc.  1  st  in  last  st;  79  (84)  sts.  Continue  pat.  repeating  BEADING ‐ With A, from right side, work 1 row sc on side 
inc.  row  every  1  ½  ins.  4  times,  with  care  to  carry  out  pat.  on   opening working 13 sc from lower edge to bind‐off, 1 sc in 
added  sts;  87  (92)  sts.  Repeat  inc.  row  every  4th  row  5  times;  bind‐off and 13 sc on other edge of opening; 27 sc.  
every  row  10  times;  117  (122)  sts.  Place  marker  for  end  of  Row 2 ‐ Ch 1, turn, work 1 slip st in first sc, * ch 3, skip 1 sc, 
crotch.   1  slip  st  in  next  sc;  repeat  from  *  12  times  ‐  making  6 
LEG ‐ Continue pat., decreasing 1 st each side every 2nd row 5  eyelets each side and 1 at center.  
times; every 4th row 25 times; 57 (62) sts. Work even until 33  CORDS  ‐  With  B,  ch  32  ins.  Work  1    slip  st  in  horizontal 
ins. from beg., measured at center, end on wrong side.   thread of each st. Fasten off. Make 2. Beg. at bottom, lace 
Dividing row ‐ side opening ‐ Work 28 (30) sts, place on holder  cords through eyelets on side openings, drawing both ends 
for  one side,  bind  off  1  (2)  sts,  work  to  end;  28  (30)  sts.  Work  through center eyelet and tie into a bow at top.  
even  following  pat.  until  3  ins.  from  opening.  Bind  off  in  pat. 
Beg. at center, finish other side to correspond.  
 
 
 
 
 
WEAVING STOCKINETTE STITCH ‐ Thread a tapestry needle and bring pieces to be joined close together. 
Draw up yarn in first st on upper piece, inserting needle from wrong side; insert needle from right side in 
first st on lower piece and bring up through next st from wrong side ‐draw up yarn; * insert needle from 
right side in same st as before on upper piece and bring up through next st from wrong side ‐ draw up 
yarn; insert needle from right side in same st as before on lower piece and bring up through next st‐draw 
up yarn; repeat from * until all sts are joined, and fasten yarn well before breaking off.  
 
WEAVING  TOE  ‐  Thread  end  of  yarn  into  tapestry  needle  and  weave  sts  together  as  follows:  *  Pass 
needle through first st of front needle as if to k and slip st off, pass through 2nd st of front needle as if to 
p but leave st on needle, draw yarn through, pass needle through first st of back needle as if to p, slip st 
off, pass through 2nd st of back needle as if to k, leave st on needle, draw yarn through; repeat from * 
until all sts are joined. Fasten off.  
 
FRINGE ‐ Wind yarn around cardboard; cut at one end, see Figure 1. Fold in 
half  and  knot  in  number  of  strands  indicated  in  individual  instruction,  see 
Figure 2. Trim fringe evenly.  

Digital Restoration © 2009 Purple Kitty LLC 47

Vous aimerez peut-être aussi