Académique Documents
Professionnel Documents
Culture Documents
3
(WinXP)
1. Minimum requirements
Hardware:
PENTIUM 500MHz or higher
Min. 256MB RAM
Disk capacity approx. 800MB, including 50MB on the system drive.
CD-ROM drive
Operating system:
Windows XP Professional (Service pack 1)
Screen settings:
Font size for display: "Normal"
Color depth: more than 16 bit
Approved screen resolution: 800x600 or 1024x768 (recommended)
Regional settings:
Select "Start" "Control Panel" "Regional and Language Options":
"Regional Options" tab: English (United States)
After that use "Customize" to change Number of digits after decimal into 3.
(Don't change any other settings of "customize" !)
The languages English, French, German, Italian and Spanish will be installed. You can select a first and second
language. These can be switched online (start-up menu).
3. Uninstall
Close all applications before uninstalling SinuTrain. Then start uninstall by selecting "Start --> Programs -->
SinuTrain Version xx --> Uninstall SinuTrain" After SinuTrain has been uninstalled, the PC must be rebooted.
4. Documentation
You need Acrobat Reader (included on the CD) to read the documentation.
5.1. If you use a full CNC keyboard, change the keyboard language to English.
Select "Start" "Settings" "System Control" "Keyboard":
"Language" tab: Add "English USA" "Set as default language"
5.2. In file "(HD):\SI_TRAIN\Add_On\SinuTr5.ini"
set the following
[F11_F10]
active=1
5.3. The NUM block must be disabled.
5.4. The following key combinations are used:
- Group Channel F11 acts as F10
- Shift + Tab acts as Shift + F9
5.5. AutoTurn should not be selected as the keys listed in 5.4 have no effect.
5.6. When the full CNC keyboard is used, the softkeys must be activated using the mouse.
Start the relevant applications with "SinuTrain START " or "ShopMill START", "ShopTurn START" or "ManualTurn
START".
Ctrl+Alt+Shift+2 Exit
Or:
- Area switchover F10
- ETC Shift + F9
- Exit SinuTrain F8
10.3.2 Simulation
If simulation is prematurely exited by pressing the vertical softkey "End" or with the softkey "Simulation", a
RESET (Ctrl+Alt+Shift+3) then becomes necessary.
Remedy: Use the mouse to select the extended softkey bar via the ">" button located below the horizontal
softkey bar (or use the key combination Shift + F9).