Académique Documents
Professionnel Documents
Culture Documents
February 1995
LM3303/LM3403
Quad Operational Amplifiers
Y Four internally compensated operational amplifiers in a
General Description single package
The LM3303 and LM3403 are monolithic quad operational Y Wide power supply range single supply of 3.0V to 36V
amplifiers consisting of four independent high gain, internal- dual supply of g 1.5V to g 18V
ly frequency compensated, operational amplifiers designed Y Class AB output stage for minimal crossover distortion
to operate from a single power supply or dual power sup-
plies over a wide range of voltages. The common mode
Y Short circuit protected outputs
input range includes the negative supply, thereby eliminat- Y High open loop gain 200k
ing the necessity for external biasing components in many Y LM741 operational amplifier type performance
applications.
Applications
Features Y Filters
Y Input common mode voltage range includes ground or Y Voltage controlled oscillators
negative supply
Y Output voltage can swing to ground or negative supply
TL/H/10064 – 2
2
LM3303 and LM3403 (Continued)
Electrical Characteristics TA e 25§ C, VCC e g 15V, unless otherwise specified
The following specifications apply for b40§ C s TA s a 85§ C for the LM3303, and 0§ C s TA s a 70§ C for the LM3403
LM3303 LM3403
Symbol Parameter Conditions Units
Min Typ Max Min Typ Max
VIO Input Offset Voltage 10 10 mV
DVIO/DT Input Offset Voltage
10 10 mV/§ C
Temperature Sensitivity
IIO Input Offset Current 250 200 nA
DIIO/DT Input Offset Current
50 50 pA/§ C
Temperature Sensitivity
IIB Input Bias Current 1000 800 nA
AVS Large Signal Voltage Gain VO e g 10V,
15 15 V/mV
RL t 2.0 kX
VOP Output Voltage Swing RL e 2.0 kX g 10 g 10 V
3
Typical Performance Characteristics
Open Loop Output Voltage
Frequency Response Sine Wave Response vs Frequency
TL/H/10064 – 3
4
Typical Applications
Multiple Feedback Bandpass Filter Comparator with Hysteresis
TL/H/10064 – 6
R1
VIL e (VOL b VREF) a VREF
R1 a R2
TL/H/10064 – 4
fo e center frequency R1
VIH e (VOH b VREF) a VREF
BW e Bandwidth R1 a R2
R in kX R1
C in mF He (VOH b VOL)
R1 a R2
fo
Qe k 10
BW
High Impedance Differential Amplifier
Q
C1 e C2 e
3
R1 e R2 e 1 R3 e 9Q2 b 1
( Using scaling factors in these expressions.
If source impedance is high or varies, filter may be preceded with voltage
follower buffer to stabilize filter parameters.
Design example:
given: Q e 5, fo e 1 kHz
Let R1 e R2 e 10 kX
then R3 e 9(5)2 b 10
R3 e 215 kX
5
Ce e 1.6 nF
3
TL/H/10064 – 7
VOUT e C(1 a a a b)(V2 b V1)
R2 R6
A for best CMRR
R5 R7
R1 e R4
R2 e R5
#1 J
R6 2R1
Gain e a e C (1 a a a b)
R5 R3
TL/H/10064 – 5
1
fo e for fo e 1 kHz
2qRC
R e 16 kX
C e 0.01 mF
TL/H/10064 – 9
R2
AV e 1 a
R1
AV e 11 (as shown)
5
Typical Applications (Continued)
AC Coupled Inverting Amplifier Voltage Reference
TL/H/10064 – 10
# J
R1 Va
VO e e as shown
R1 a R2 2
1
VO e Va
2
TL/H/10064–8
Rf
AV e
R1
AV e 10 (as shown)
TL/H/10064–11
TL/H/10064 – 14
TL/H/10064 – 12
Note 1: Wide Control Voltage Range:
0V s VCO s 2 (V g 1.5V)
6
Typical Applications (Continued)
Function Generator
TL/H/10064 – 13
R1 a R2 R2R1
Note 2: f e if R3 e
4CRfR1 R2 a R1
Bi-Quad Filter
TL/H/10064 – 15
BW Example:
Qe
fo fo e 1000 Hz
where: BW e 100 Hz
TBP e 1
TBP e Center Frequency Gain
TN e 1
TN e Bandpass Notch Gain
R e 160 kX
1 1 R1 e 1.6 MX
fo e , VREF e VCC R2 e 1.6 MX
2qRC 2
R3 e 1.6 MX
R1 e QR C e 0.001 mF
R1
R2 e
TBP
R3 e TNR2
C1 e 10 C
7
8
Physical Dimensions inches (millimeters)
9
LM3303/LM3403 Quad Operational Amplifiers
Physical Dimensions inches (millimeters) (Continued)
NATIONAL’S PRODUCTS ARE NOT AUTHORIZED FOR USE AS CRITICAL COMPONENTS IN LIFE SUPPORT
DEVICES OR SYSTEMS WITHOUT THE EXPRESS WRITTEN APPROVAL OF THE PRESIDENT OF NATIONAL
SEMICONDUCTOR CORPORATION. As used herein:
1. Life support devices or systems are devices or 2. A critical component is any component of a life
systems which, (a) are intended for surgical implant support device or system whose failure to perform can
into the body, or (b) support or sustain life, and whose be reasonably expected to cause the failure of the life
failure to perform, when properly used in accordance support device or system, or to affect its safety or
with instructions for use provided in the labeling, can effectiveness.
be reasonably expected to result in a significant injury
to the user.
National does not assume any responsibility for use of any circuitry described, no circuit patent licenses are implied and National reserves the right at any time without notice to change said circuitry and specifications.