Académique Documents
Professionnel Documents
Culture Documents
Installation of Samsung LCD TVs with Eclipse Sm@rtbox T15 or D35 (ISB protocol)
Version : 1.1 (Rev 1.0 > 1.1 Hotel menu problem added, Appendix A added)
Version : 1.2 Check comm parameter added, TV types updated
Tools for installation: Eclipse Service RC and Samsung standard (consumer) RC.
Installation
RJ12/3.5 mm jack cable to the LCD TV DATA connector (3.5 mm jack - 4 poles). This
connector is located on the back side next to the headphone socket (LE51BH only).
For the R71BH type the Data connector is in the bottom row of connectors next to the S-
video connector.
TV Configuration
Important Note: Hotel mode on will only work when Language is set to ENGLISH.
When TV turns on for the first time it will prompt: PLUG and PLAY installation. Either press
EXIT (when used with a system ) to do it manually or continue (when used as a Stand-
alone TV) but, DO NOT SELECT AN OTHER THAN ENGLISH.
Normally the TV is in Hotel mode from the factory. If not, using a Samsung RC. Press
INFO, MENU, 0, 1, EXIT . The TV will now enter the Hotel mode setup menu.
If Hotel mode does not appear or strange characters appear the TV needs a Reset
because the language was not set correctly - see appendix.
Select menu positions using up and down arrows on Samsung RC. Change values using
arrow left and right.
Select :
1. Hotel mode = ON (Off = consumer mode)
8. Menu On =0 (1 = extended Menu - see text)
9. PowerOn Ch = 1 (fold back program when communication is lost)
If a position 13. Check Comm appear, set this to = 1 This will check if communication
is lost and revert the TV to pgm 1.
Using the 2M Eclipse Service RC pointed towards the ID allocator box. Press MENU key
and the button at the side of the RC simultaneously. The box will now enter the room
set-up mode and the ID allocator will display the current room number.
To alter the room number press OK and change the room number to the correct number
and press OK again to accept. Press the On/Off by key on the service RC to exit.
If RC type needs to be altered do as described above but press arrow down (toggles
between room #, RC type and Audio volume) when room number appears. The Allocator
will respond with RC type:
RC type (first digit), level (second digit)
When using the build in audio amplifier in the T11 Sm@rtbox for e.g. external bathroom
speaker the audio volume can be altered using the allocator box. To alter do as described
above but press arrow down twice (toggles between room #, RC type and Audio
volume).
Audio Level (AL) 00 to 63
Test
Press a program button on Eclipse RC to turn on. The red On LED will now start to blink
and the TV will turn on.
Test the TV by normal operation e.g. shifting channels, volume up, interactive menus etc.
Turn on TV again. TV will now prompt: PLUG and PLAY installation. Either press EXIT
to do it manually or continue but, DO NOT SELECT AN OTHER THAN ENGLISH.