Académique Documents
Professionnel Documents
Culture Documents
Fesler Billet makes every effort to ensure that you are provided with
the most accurate and up-to-date technical information. However, all
technical information is approximate and may vary upon application.
Fesler Billet is not responsible for any consequences resulting from
manufacture’s technical mid-year changes. Fesler Billet products
should only be installed by a qualified, licensed auto mechanic
experienced in the installation of such products.
Fesler Billet designs all parts off original OEM applications. Due to the
vast array of manufacturers for aftermarket parts, it is possible that you
INSTALLATION
may have to make some minor adjustments to either our part or your
sheet metal in order for the part to fit properly. INSTRUCTIONS
FBRL-69CAM
1969 Camaro RS Reverse Lights
INSTALLATION INSTRUCTIONS
1969 RS Camaro Reverse Lights
Copyright 2011 © by Fesler Productions, LLC. All rights reserved.
Installation Instructions:
7. Install the inner housing to the body
using the supplied #10 pan head
1. Remove the 2 screws retaining the stock reverse light lens. Remove
screws. Tighten the button head bolts
lens.
on the adjustable tab in the top of the
2. Remove the 2 screws retaining the reverse light housing, remove
housing.
housing and cut the reverse light wire approximately 1” from the light
a. Use this tab to adjust any gap you may
socket. have between the body and the outer
a. If you do not wish to cut the wire you can remove it by lens housing by repeating the following
unplugging it in the trunk and running a new wire from the steps.
plug.
3. Remove the 2 button head screws retaining the new Fesler Billet lens 8. Re install the LED board using the
to the inner housing. screws previously removed (6-32 X
4. Remove the 2 screws retaining the LED board to the inner housing ¼).
and pull the wires back about 4”. MAKE SURE YOU RE-MOUNT
BOARD WITH WRITING AT THE
5. Install the paint gasket to TOP!!!!!
the back of the Fesler Billet Excess wiring should be stored
inner housing. behind the assembly NOT THE
a. The thin part of the BOARD.
gasket will go to
the top of the inner 9. Install the lens housing by sliding the
housing which has locking tabs into the top of the inner
the adjustable housing and then rotating the lens
locking tab. towards the bottom.