Académique Documents
Professionnel Documents
Culture Documents
February 1992
DM74LS564
Octal D-Type Flip-Flop with TRI-STATEÉ Outputs
General Description Features
The ’LS564 is a high speed low power octal flip-flop with a Y Inputs and outputs on opposite sides of package allow-
buffered common Clock (CP) and a buffered common Out- ing easy interface with microprocessors
put Enable (OE). The information presented to the D inputs Y Useful as input or output port for microprocessors
is stored in the flip-flops on the LOW-to-HIGH Clock (CP) Y Functionally identical to ’LS574
transition Y Input clamp diodes limit high speed termination effects
This device is functionally identical to the ’LS574, but has Y Fully TTL and CMOS compatible
inverted outputs. For complete discussions of operations,
truth tables, AC and DC electrical specifications, refer to the
’LS374 data sheet.
Dual-In-Line Package
TL/F/10191 – 2
VCC e Pin 20
GND e Pin 10
TL/F/10191 – 1
Order Number DM74LS564WM or DM74LS564N
See NS Package Number M20B or N20A
Electrical Characteristics over recommended operating free air temperature range (unless otherwise noted)
Typ
Symbol Parameter Conditions Min Max Units
(Note 1)
VI Input Clamp Voltage VCC e Min, II e b18 mA b 1.5 V
VOH High Level Output VCC e Min, IOH e Max,
2.4 3.4 V
Voltage VIL e Max
VOL Low Level Output VCC e Min, IOL e Max,
0.35 0.5 V
Voltage VIH e Min
IOL e 12 mA, VCC e Min 0.25 0.4
II Input Current @ Max VCC e Max, VI e 7V
0.1 mA
Input Voltage
IIH High Level Input Current VCC e Max, VI e 2.7V 20 mA
IIL Low Level Input Current VCC e Max, VI e 0.4V b 0.4 mA
IOS Short Circuit VCC e Max
b 30 b 130 mA
Output Current (Note 2)
ICC Supply Current VCC e Max 60 mA
IOZH TRI-STATE Output OFF VCC e Max, VO e 2.4V
20 mA
Current HIGH
IOZL TRI-STATE Output OFF VCC e Max, VO e 0.4V
b 20 mA
Current LOW
Note 1: All typicals are at VCC e 5V, TA e 25§ C.
Note 2: Not more than one output should be shorted at a time, and the duration should not exceed one second.
2
Switching Characteristics
VCC e a 5.0V, TA e a 25§ C
Symbol Parameter Min Max Units
tPLH Propagation Delay 28
ns
tPHL CP to On 28
tPZH Enable Time 28
ns
tPZL OE to On 28
tPHZ Enable Time 20
ns
tPLZ OE to On 25
ts Setup Time
20 ns
Dn to CP
th Hold Time
5 ns
Dn to CP
tw (H) Pulse Width 20
ns
tw (L) (HIGH/LOW) CP 15
3
DM74LS564 Octal D-Type Flip-Flop with TRI-STATE Outputs
Physical Dimensions inches (millimeters) (Continued)
NATIONAL’S PRODUCTS ARE NOT AUTHORIZED FOR USE AS CRITICAL COMPONENTS IN LIFE SUPPORT
DEVICES OR SYSTEMS WITHOUT THE EXPRESS WRITTEN APPROVAL OF THE PRESIDENT OF NATIONAL
SEMICONDUCTOR CORPORATION. As used herein:
1. Life support devices or systems are devices or 2. A critical component is any component of a life
systems which, (a) are intended for surgical implant support device or system whose failure to perform can
into the body, or (b) support or sustain life, and whose be reasonably expected to cause the failure of the life
failure to perform, when properly used in accordance support device or system, or to affect its safety or
with instructions for use provided in the labeling, can effectiveness.
be reasonably expected to result in a significant injury
to the user.
National does not assume any responsibility for use of any circuitry described, no circuit patent licenses are implied and National reserves the right at any time without notice to change said circuitry and specifications.