Académique Documents
Professionnel Documents
Culture Documents
Refer to the exhibit. Every time the administrator reboots this router, the boot process
ends in setup mode. What is a possible problem?
There is insufficient RAM for the IOS to load on this router.
A password recovery process should be done on this router.
The bootstrap version and the version of the IOS are different.
The IOS image is damaged and must be reloaded using tftpdnld.
The configuration register is set to ignore the startup configuration.
4. Which option correctly defines the capacity through the local loop guaranteed to a
customer by the service provider?
BE
DE
CIR
CBIR
5.
Refer to the exhibit. A host connected to Fa0/0 is unable to acquire an IP address from
the DHCP server. The output of the debug ip dhcp server command shows "DHCPD:
there is no address pool for 10.1.1.1". What is the problem?
The 10.1.1.1 address is already configured on Fa0/0.
The default router for the 10Network pool is incorrect.
The ip helper-address must be added to Fa0/0 interface.
The pool of addresses for the 10Network pool is incorrect.
6. Which data link layer encapsulation protocol is used by default for serial
connections between two Cisco routers?
ATM
Frame Relay
HDLC
PPP
SDLC
7.
Refer to the exhibit. Which statement correctly describes how Router1 processes an
FTP request that enters interface s0/0/0 and is destined for an FTP server at IP
address 192.168.1.5?
The router matches the incoming packet to the statement that was created by the access-list
201 deny icmp 192.168.1.0 0.0.0.255 any command, continues comparing the packet to the
remaining statements in ACL 201 to ensure that no subsequent statements allow FTP, and
then the router drops the packet.
The router reaches the end of ACL 101 without matching a condition and drops the packet
because there is no statement that was created by the access-list 101 permit ip any any
command.
The router matches the incoming packet to the statement that was created by the access-list
101 permit ip any 192.168.1.0 0.0.0.255 command and allows the packet into the router.
It matches the incoming packet to the statement that was created by the access-list 201
permit ip any any command and allows the packet into the router.
8. Compared with IDS systems, what can IPS systems do to provide further protection
of computer systems?
detect potential attacks
stop the detected attack from executing
update OS patches for computer systems
scan computer systems for viruses and spyware
9. Which IEEE 802.16 broadband wireless technology allows users to connect to the
ISP at speeds comparable to DSL and cable?
Wi-Fi
satellite
WiMAX
Metro Ethernet
10. A network administrator has changed the VLAN configurations on his network
switches over the past weekend. How can the administrator determine if the additions
and changes improved performance and availability on the company intranet?
Conduct a performance test and compare with the baseline that was established previously.
Interview departmental secretaries and determine if they think load time for web pages has
improved.
Determine performance on the intranet by monitoring load times of company web pages from
remote sites.
Compare the hit counts on the company web server for the current week to the values that
were recorded in previous weeks.
11.
Refer
to the exhibit. What is the meaning of the term dynamic in the output of the
command?
The bandwidth capability of the interface increases and decreases automatically based on
BECNs.
The Serial0/0/1 interface acquired 172.16.3.1 from a DHCP server.
The mapping between DLCI 100 and 172.16.3.1 was learned through Inverse ARP.
DLCI 100 will automatically adapt to changes in the Frame Relay cloud.
12. Which type of ACL will permit traffic inbound into a private network only if an
outbound session has already been established between the source and destination?
extended
reflexive
standard
time-based
13. Which two statements are true about IPv6 link local addresses? (Choose two.)
They begin with the 2000::/3 prefix.
They begin with the FE80::/10 prefix.
They are assigned by IANA to an organization.
They must be manually configured by the administrator.
They are assigned to a host by a stateless autoconfiguration process.
14. A company is looking for a WAN solution to connect its headquarters site to four
remote sites. What are two advantages that dedicated leased lines provide compared
to a shared Frame Relay solution? (Choose two.)
reduced jitter
reduced costs
reduced latency
the ability to burst above guaranteed bandwidth
the ability to borrow unused bandwidth from the leased lines of other customers
15.
Refer to the exhibit. From the output of the show interfaces and ping commands, at
which layer of the OSI model is a fault indicated?
application
transport
network
data link
physical
19. Which technology is used to dynamically map next hop, network layer addresses
to virtual circuits in a Frame Relay network?
Inverse ARP
LMI
DLCI
FECN
20. An administrator learns of an e-mail that has been received by a number of users
in the company. This e-mail appears to come from the office of the administrator. The
e-mail asks the users to confirm their account and password information. Which type
of security threat does this e-mail represent?
cracking
phishing
phreaking
spamming
21.
Refer to the exhibit. Results of the show vlan and show vtp status commands for
switches S1 and S2 are displayed in the exhibit. VLAN 11 was created on S1. Why is
VLAN 11 missing from S2?
There is a Layer 2 loop.
The VTP domain names do not match.
Only one switch can be in server mode.
S2 has a higher spanning-tree priority for VLAN 11 than S1 does.
23. What is the result of adding the global command service password-encryption to
the configuration of a router?
Line passwords are encrypted with type 7 encryption.
Enable passwords are encrypted with type 5 encryption.
All services must provide an encrypted password to function.
Only encrypted messages are allowed for router communication.
24. While troubleshooting a problem with an e-mail server, an administrator observes
that the switch port used by the server shows "up, line protocol up". The
administrator cannot ping the server. At which layer of the OSI model is the problem
most likely to be found?
application layer
network layer
data link layer
physical layer
25. Where does a service provider assume responsibility from a customer for a WAN
connection?
local loop
DTE cable on router
demarcation point
demilitarized zone
26. What will be the result of adding the command ip dhcp excluded-address
192.168.24.1 192.168.24.5 to the configuration of a local router that has been
configured as a DHCP server?
Traffic that is destined for 192.168.24.1 and 192.168.24.5 will be dropped by the router.
Traffic will not be routed from clients with addresses between 192.168.24.1 and
192.168.24.5.
The DHCP server will not issue the addresses ranging from 192.168.24.1 to 192.168.24.5.
The router will ignore all traffic that comes from the DHCP servers with addresses
192.168.24.1 and 192.168.24.5.
27.
Refer
to the exhibit. Partial results of the show access-lists and show ip interface
FastEthernet 0/1 commands for router Router1 are shown. There are no other ACLs in
effect. Host A is unable to telnet to host B. Which action will correct the problem but
still restrict other traffic between the two networks?
Apply the ACL in the inbound direction.
Apply the ACL on the FastEthernet 0/0 interface.
Reverse the order of the TCP protocol statements in the ACL.
Modify the second entry in the list to permit tcp host 172.16.10.10 any eq telnet .
28.
Refer to the exhibit. The corporate network that is shown has been assigned network
172.16.128.0/19 for use at branch office LANs. If VLSM is used, what mask should be
used for addressing hosts at Branch4 with minimal waste from unused addresses?
/19
/20
/21
/22
/23
/24
29.
Refer to the exhibit. RIPv2 has been configured on all routers in the network. Routers
R1 and R3 have not received any RIP routing updates. What will fix the issue?
Enable RIP authentication on R2.
Issue the ip directed-broadcast command on R2.
Change the subnet masks to 10.11.12.0/8 and 172.16.40.0/16 on R2.
Enable CDP on R2 so that the other routers will receive routing updates.
30.
Refer to the exhibit. This serial interface is not functioning correctly. Based on the
output shown, what is the most likely cause?
improper LMI type
interface reset
PPP negotiation failure
unplugged cable
31. Which statement is true about PAP in the authentication of a PPP session?
PAP uses a two-way handshake.
The password is unique and random.
PAP conducts periodic password challenges.
PAP uses MD5 hashing to keep the password secure.
32. An administrator is configuring a dual stack router with IPv6 and IPv4 using RIPng.
The administrator receives an error message when trying to enter the IPv4 routes into
RIPng. What is the cause of the problem?
When IPv4 and IPv6 are configured on the same interface, all IPv4 addresses are over-
written in favor of the newer technology.
Incorrect IPv4 addresses are entered on the router interfaces.
RIPng is incompatible with dual-stack technology.
IPv4 is incompatible with RIPng.
33. What is tunneling?
using digital certificates to ensure that data endpoints are authentic
creating a hash to ensure the integrity of data as it traverses a network
using alternate paths to avoid access control lists and bypass security measures
encapsulating an entire packet within another packet for transmission over a network
34. Which statement is true about NCP?
Link termination is the responsibility of NCP.
Each network protocol has a corresponding NCP.
NCP establishes the initial link between PPP devices.
NCP tests the link to ensure that the link quality is sufficient.
35.
Refer
to the exhibit. A network administrator is creating a prototype to verify the new WAN
design. However, the communication between the two routers cannot be established.
Based on the output of the commands, what can be done to solve the problem?
Replace the serial cable .
Replace the WIC on RA.
Configure RA with a clock rate command.
Issue a no shutdown interface command on RB.
36.
Refer to the exhibit. Based on the output as shown, which two statements correctly
define how the router will treat Telnet traffic that comes into interface FastEthernet
0/1? (Choose two).
Telnet to 172.16.10.0/24 is denied.
Telnet to 172.16.20.0/24 is denied.
Telnet to 172.16.0.0/24 is permitted.
Telnet to 172.16.10.0/24 is permitted.
Telnet to 172.16.20.0/24 is permitted.
37. Which Frame Relay flow control mechanism is used to signal routers that they
should reduce the flow rate of frames?
DE
BE
CIR
FECN
CBIR
38.
Refer to the exhibit. A network administrator configures a standard access control list
on Router1 to prohibit traffic from the 192.168.0.0/24 network from reaching the
Internet. The access control list also permits traffic from the 192.168.0.0/24 network to
reach the 192.168.1.0/24 network. On which interface and in which direction should
the access control list be applied?
interface Fa0/0, inbound
interface Fa0/0, outbound
interface S0/0/0, inbound
interface S0/0/0, outbound
39. Which configuration on the vty lines provides the best security measure for
network administrators to remotely access the core routers at headquarters?
Refer to the exhibit. R1 is performing NAT overload for the 10.1.1.0/24 inside network.
Host A has sent a packet to the web server. What is the destination IP address of the
return packet from the web server?
10.1.1.2:1234
172.30.20.1:1234
172.30.20.1:3333
192.168.1.2:80
50. Refer to the exhibit. All devices are configured as shown in the exhibit. PC1 is
unable to ping the default gateway. What is the cause of the problem?
The default gateway is in the wrong subnet.
STP has blocked the port that PC1 is connected to.
Port Fa0/2 on S2 is assigned to the wrong VLAN.
S2 has the wrong IP address assigned to the VLAN30 interface.
51. When Frame Relay encapsulation is used, what feature provides flow control and
exchanges information about the status of virtual circuits?
LCP
LMI
DLCI
Inverse ARP
52. A network administrator is tasked with maintaining two remote locations in the
same city. Both locations use the same service provider and have the same service
plan for DSL service. When comparing download rates, it is noticed that the location
on the East side of town has a faster download rate than the location on the West side
of town. How can this be explained?
The West side has a high volume of POTS traffic.
The West side of town is downloading larger packets.
The service provider is closer to the location on the East side.
More clients share a connection to the DSLAM on the West side.