Académique Documents
Professionnel Documents
Culture Documents
6 CORPORATE PARKWAY
GOOSE CREEK , SC . 29445
STYLE NUMBER: DE9256K
www . quoizel . com
PREPARATION
Before beginning installation of product, make sure all parts are present. Compare parts with package contents list
and diagram above. If any part is missing or damaged, do not attempt to assemble, install or operate the product.
Contact customer service for replacement part.
Estimated Assembly Time: 20- 30 minutes
Tools Required for Assembly(not included): Flathead Screwdriver , Phillips Screwdriver, Pliers, Electrical Tape,
Wire Cutters, Safety Glasses &1, 150 Watts, Type- A Medium Base Bulbs.
Helpful Tools(not included): Wire Strippers.
ASSEMBLY
Mounting Hole
Cage
Glass Holder
1 OF 2
ASSEMBLY INSTRUCTIONS STYLE NUMBER: DE9256K
STEP 2.
A. Carefully fit the POST FITTER over the end of the POST (not
supplied), making sure the POST FITTER is fully seated.
B. Mark the drill point for the (3 )MOUNTING SCREWS , using
(3 )MOUNTING HOLES as reference . After marking hole
Post Fitter
locations, remove FIXTURE from POST and drill 1/8" pilot holes
for screws. Mounting Screw
C. Refer to Step 6 for wire connections.
D. Coat the top 1" of the POST with CLEAR SILICONE CAULK (not
supplied) and position the POST FITTER onto the POST. Be
sure to seat it completely, aligning the holes in the FITTER with
Post( not supplied)
the 1/16" PILOT HOLES drilled into the POST.
E. Secure the FIXTURE to POST with (3) MOUNTING SCREWS.
STEP 3.
WHITE WIRE WHITE OR RIBBED
* Use Wire Connectors ( not supplied) to connect the wires.
FROM HOUSE FROM FIXTURE
A. Connect the House Ground Wire to the Fixture Ground Wire.
B. Connect the House White Wire to the Fixture Supply Wire
( White or Ribbed Side) . BLACK SIDE
BLACK( OR RED) WIRE
C. Connect the House Black( or Red) Wire to the Fixture Supply
Wire ( Black Side). FROM HOUSE FROM FIXTURE
D. Wrap each connection with approved electrical tape and
carefully stuff all of the connected wires into the Outlet Box.
GROUND WIRE GROUND WIRE
FROM HOUSE FROM FIXTURE
STEP 4.
A. Install the correct Bulb referring to fixture markings and/ or
labels for maximum wattage.
STEP 5.
A. Place Fixture Hood onto top edge of the Cage and make the Finial
Bolts on the top edge of the Cage through the holes on the
Fixture Hood.
B. Thread Lock Balls onto the Bolts and hand tighten until snug to
secure the Fixture Hood and Cage together.
C. Thread the Finial onto the nipple on the top center of the Fixture Fixture Hood
Hood and tighten until snug.
Lock
Ball
Bolt
Cage
2 OF 2