Académique Documents
Professionnel Documents
Culture Documents
Router#configure terminal
Router(config)#hostname [Nombre]
Nombre(config)#Ctrl + z
Nombre#
Configuración de Password
1.- Enable Password
Nombre#configure terminal
Nombre(config)#enable password [password]
Nombre(config)#Ctrl + z
Nombre#
3.- Terminal
Nombre#configure terminal
Nombre(config)#line vty 0 4
Nombre(config-line)#login
Nombre(config-line)#password [password]
Nombre(config-line)#Ctrl + z
Nombre#
4.- Consola
Nombre#configure terminal
Nombre(config)#line console 0
Nombre(config-line)#login
Nombre(config-line)#password [password]
Nombre(config-line)#Ctrl + z
Nombre#
5.- Auxiliar
Nombre#configure terminal
Nombre(config)#line auxiliary 0
Nombre(config-line)#login
Nombre(config-line)#password [password]
Nombre(config-line)#Ctrl + z
Nombre#
Displaying comand
Entradas a la Novel Cache
show novell cache
Parámetros de Interface Novell
show novell interface [interface unit]
Tabla de enrutamiento Novell (Routing Table)
show novell route
Novell Servers
show novell servers
Tráfico Novell
show novell traffic
Comandos Copy
Comandos de Inicio
Router(config)# config-register 0x2102
Router(config)# boot system flash igs-j-1.111-5
Router(config)# boot system tftp igs-j-1.111-5
Encapsulamiento PPP
Router(config)# interface Serial 0
Router(config-if)# encapsulation ppp
Router# show interface s 0
PPP con autenticación PAP
Router(config)# interface Serial 0
Router(config-if)# encapsulation ppp
Router(config-if)# ppp authentication pap
Router(config-if)# ppp pap sent-username LabB password class
PPP con autenticación CHAP
Router(config)# interface Serial 0
Router(config-if)# encapsulation ppp
Router(config-if)# ppp authentication chap
Router# username LabB password class
ISDN -Configuración del Router Gateway
Router-Gateway(config)# username ISP pass class
Router-Gateway(config)# isdn switch-type bassic-dms100
Router-Gateway(config)# dialer-list 1 protocol ip list 101
Router-Gateway(config)# access-list 101 deny igrp any any
Router-Gateway(config)# access-list 101 permit ip any any
Router-Gateway(config)# ip route 172.30.0.0 255.255.0.0 bri0
Router-Gateway(config)# interface bri0
Router-Gateway(config-if)# ip add 10.0.0.3 255.0.0.0
Router-Gateway(config-if)# encapsulation ppp
Router-Gateway(config-if)# ppp authen chap
Router-Gateway(config-if)# dialer-group 1
Router-Gateway(config-if)# dialer map ip 10.0.0.4 name ISP 8315551234
Router-Gateway(config-if)# isdn spid1 08443 213
Router-Gateway(config-if)# isdn spid2 08132 344
ISDN -Configuración del Router ISP
Router-ISP(config)# username Gateway pass class
Router-ISP(config)# isdn switch-type bassic-5ess
Router-ISP(config)# dialer-list 1 protocol ip list 101
Router-ISP(config)# access-list 101 permit ip any any
Router-ISP(config)# ip route 192.168.15.0 255.255.255.0 10.0.0.3
Router-ISP(config)# interface bri 0
Router-ISP(config-if)# ip add 10.0.0.4 255.0.0.0
Router-ISP(config-if)# encapsulation ppp
Router-ISP(config-if)# ppp authen chap
Router-ISP(config-if)# dialer-group 1
Router-ISP(config-if)# dialer map ip 10.0.0.3 name Gateway 4085559988
Comandos Opcionales ISDN
Router-ISP(config-if)# dial wait-for-carrier time seconds
Cantidad de segundos que la interface espera a la portadora cuando se realiza un
pedido. El vlor por default es de 30 segundos
Router-ISP(config-if)# dialer idle timeout seconds
Especifica la cantidad de segundos de inactividad que se deben esperar antes de
desconectar una llamada. El valor por default es de 120 segundos
Router-ISP(config-if)# dialer load threshhold load [outbound | inboud | either]
Configura el ancho de banda a pedido estableciendo la carga máxima antes de que el
dispositivo de discado realice otra llamada hacia un destino. La carga equivale
a la carga de interface de 1 a 255, donde 255 corresponde al 100 % del ancho de
banda disponible.
Monitoreo y Prueba de ISDN
Router-ISP# show dialer Muestra el estado actual del enlace
Router-ISP# show isdn active Muestra el estado de llamada mientras se está efectua
ndo la misma
Router-ISP# show isdn status Muestra el estado si hay una conexión ISDN
Router-ISP# show dialer map Muestra las sentencias de dialer map ip
Router-ISP# debug q921 Muestra el establecimiento de la conexión de llamada y su d
esconexión
Router-ISP# debug dialer Muestra la configuración y la operación del dispositivo de
marcación
Comandos Para Frame Relay
Router-1
Router-1(config)# interface s 1
Router-1(config-if)# ip add 10.16.0.1 255.255.255.0
Router-1(config-if)# encapsulation frame-relay
Router-1(config-if)# bandwidth 56
Router-1(config-if)# frame-relay map ip 10.16.0.2 110 broadcast ietf
Router-1(config-if)# frame-relay lmi-type ansi (Se necesita para versiones anter
iores a 11.0
IOS 11.0 soporta sensor LMI automático)
Router-1(config)# router rip
Router-1(config-router)# network 10.0.0.0
Router-2
Router-2(config)# interface s 1
Router-2(config-if)# ip add 10.16.0.2 255.255.255.0
Router-2(config-if)# encapsulation frame-relay
Router-2(config-if)# bandwidth 56
Router-1(config-if)# frame-relay map ip 10.16.0.1 110 broadcast ietf
Router-1(config-if)# frame-relay lmi-type ansi (Se necesita para versiones anter
iores a 11.0
IOS 11.0 soporta sensor LMI automático)
Router-1(config)# router rip
Router-1(config-router)# network 10.0.0.0