Académique Documents
Professionnel Documents
Culture Documents
step-by-step
free
SUPPLY LIST Hair clip
Assorted ribbons, narrow-width Binder clips PROJECT IDEAS
Fabric stiffener Paintbrush
Three 1/4˝ dowel rods Scissors
Needle and Thread Hot glue gun
1. Tightly wrap
Accessorize
The Four-Layer Loopy Bow
in style!
ribbon around
dowel rods SUPPLY LIST One length of 7/8˝ ribbon for spray, 7˝ long
and secure Two lengths of 3/8˝ wide ribbon, each 30˝ long Hair clip
with clamps at Two lengths of 5/8˝ ribbon for spray, each 7˝ long Fray Check
both ends. Length of 1 ½˝ wide ribbon, 30˝ long Needle and thread
Length of 1 ½˝ wide ribbon, 29˝ long Scissors
One length of 5/8˝ ribbon, 30˝ long Hot glue gun
These are
are even, then hot glue together. Wrap
ribbon layers together. thread around and tie off.
not your
5. Place the wider 6. Layer the ribbons
7” ribbon on and arrange as
bottom, then make desired on top of the
ordinary
an “X” on top with ribbon spray. Wrap a
the two narrow French knot around all
7˝ ribbons. Tack the layers and glue in
hair bows!
together in center. back. Attach hair clip.
Trim ends and apply
Fray Check.
©2010 Hobby Lobby® - The information in these instructions is presented in good faith, but no warranty is given, nor results guaranteed, nor is freedom from any
patent to be inferred. Since we have no control over physical conditions surrounding the application of information herein contained, Hobby Lobby Stores, Inc.
4. Criss-cross the cut curls (as shown) and secure 5. Glue bow to hair clip. Trim curls as needed, and disclaims any liability for untoward results. Follow manufacturer’s instructions in using paints and other materials, keeping them out of reach of children,
5. To make the
tails, cut six pieces
2. For each pattern of ribbon, make a Figure 3. Carefully pinch center and weave needle and thread 4. Stack each of ribbon 7˝ long.
8 as shown, leaving 2˝ of ribbon free on in and out of the layers to secure the loops. tier, sewing Criss-cross ribbons,
3. Lay flat, taking care not to move loops. 4. Wrap gathered center with jewelry wire to one end. middle tier to as pictured, and
Pinch the center of loops to create a gather. secure loops. bottom tier, sew to secure.
then top tier Layer behind bow
to middle to and secure to
secure. bottom tier of bow.