C
880830 Appendix A. Survey of Microprocessor Menu Forms Page A-9
and Error Messages
TEST AND DIAGNOSTICS
Generator
Movements
Memory ace!
1/0 space access
XRA bus access
Sample changer
Reproducibility / stability tests
Special test mode
Selection : Generator
A.3.6 Measurement
‘The measurement form contains information on the measurement results as well as the measurement
status. The channel output is given in kilo counts per second (keps) and the counting statistical error
(CSE) in percent is also displayed. The measured channels can be fixed channels as well as channels
assembled on a PW1661/00 Programmable Goniometer which are assembled in the measuring program,
The measurement form is shown in the next example.
MEASUREMENT Page 1/1 26-may-eo 1
Sample ident : 2031 up glass cuhldr 37
Time (sec?
| Status
en Kers SEZ | Ch kcrs CSE Z | Ch csr x |
Iona 0.147 1-06 | Ain 1-768 0.31 | '
| M9 113020136 | Fe 162137 old | '
lat Toso ol15 | Sra 2is21 0136 | 1
1 8s aale77 0107 | zal olaa 1106 | '
iP oltoa = T137 | 1 '
is oleae? 0150 | 1 '
1K 211760 0.09 | 1 '
| co 6761262 0102 | 1 t
it 01478 0159 | ‘ t
C Edit, Start, Abort, Print, Transmit, +, -, / 1: Bait
The programmable goniometer channel currently being measured will be displayed in the status line of the
measuring program.
The commands in the command line allow the following to happen:
EDIT: allows the input of a new sample identification.
-START: allows starting of the measurement cycle.
~ABORT: terminates the measurement.
-PR
will print the results on a printer. If automatic priority is chosen in the system parameters,
this item will not be present and printing is performed automatically after the measure-
ments are finished.