Vous êtes sur la page 1sur 3

Discussion on Call drop reasons in GSM network | TechRepublic

http://www.techrepublic.com/forum/discussions/83-200396

Discussion on: Call

drop reasons in GSM network(/forum/discussions/83-200396)


6 Comments
Go to comment(/forum/discussions/83-200396-3450744)

Just In

TCH Drop-Call Drop telecomfunda(/members/profile/6811431) 13th May Radio Link Time-Out Layer 2 Time-Out MSC Time-Out Assignment to TCH More Info at http://telefunda.blogspot.com/2010/01/dropped-calltch-drop-sdcch-drop.html(http://telefunda.blogspot.com /2010/01/dropped-calltch-drop-sdcch-drop.html) Tags: telecom(/topics/telecom), networking(/topics/networking), gsm(/topics/gsm)
Community Preferences(/members/preferences#community)

+1 Vote +(/util/vote) -(/util/vote)

Call drop reasons in GSM network(/forum/discussions/83-200396-2088364) ravinder.529@...(/members/profile/4568379) 5th Sep 2006 Hey can anyone please tell me in detail about the possible reasons for call drop in GSM network. Reply(/forum/discussions/83-200396-2088364/reply) Favorite(/util/favorite?title=Call+drop+reasons+in+GSM+network&url=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396-2088364&contentType=message& contentId=2088364&path=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396) PreviousNextPreviousNext 0 Votes +(/util/vote) -(/util/vote)

Call drop reasons(/forum/discussions/83-200396-2137356) alcapaino@...(/members/profile/4623849) 14th Dec 2006 Call drops in GSM network can be caused by the following: i) Equipment: GSM radios/Combiners can be a cause of this, solution to this is replacement of the unit. A Mobile Station(phone) can also be a cause.

1 of 3

10/4/2011 10:20 AM

Discussion on Call drop reasons in GSM network | TechRepublic

http://www.techrepublic.com/forum/discussions/83-200396

ii) VSWR (voltage wave standing ratio): VSWR caused by poor connections on feeders, water penetration, fault on antenna etc iii) Transmission problem: If transmission is not perfect, high B.E.R (Bit error ratio) or other factors causing inaccuracy of transmission. iv) Interference: when there's frequency interfere (either co-channel or adjacent interference). v) Hand-over: if hand-over between two sectors is not well defined. For more issues check me at alcapaino@yahoo.com or +255784670979 Reply(/forum/discussions/83-200396-2137356/reply) Favorite(/util/favorite?title=Call+drop+reasons&url=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396-2137356&contentType=message& contentId=2137356&path=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396) 0 Votes +(/util/vote) -(/util/vote)

y(/forum/discussions/83-200396-3216009) ishu_garg_s(/members/profile/6318130) 17th Dec 2009 y Reply(/forum/discussions/83-200396-3216009/reply) Favorite(/util/favorite?title=y&url=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396-3216009&contentType=message& contentId=3216009&path=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396) 0 Votes +(/util/vote) -(/util/vote)

Possible reasons for call drop(/forum/discussions/83-200396-2566664) redwan0207046@...(/members/profile/5035748) 11th Aug 2008 1. If the netwotk is congested and u are low priority user then ur call might be dropped. 2. The signal level for an ideal call is Transmit +43db Receive -60 ~ -80db Some times while receiving call, suppose due to pathloss or shadowing, if ur receiving signal level is -95db, then ur call will be dropeed. During the site survey, Site selection is very much important to avoid the effect of path loss and shadowing. 3. Sometimes there are pockets due to inappropiate radio network planning, in those pockets ur call might be dropped. Appropiate Radio Planning and the adjustment of Antenna's Down Tilt is very much important to resolve this problem.

2 of 3

10/4/2011 10:20 AM

Discussion on Call drop reasons in GSM network | TechRepublic

http://www.techrepublic.com/forum/discussions/83-200396

4. During hanover, if the interferrence from the neighbouring BTS is too high the call might be droped. Appropiate Radio Planning and the adjustment of Antenna's Down Tilt is very much important to resolve this problem 5. Somtimes SACCH, FACCH signalling channels are not available to provide u a TCH channel.In that case call might be dropped. Repeated SACCH, FACCH can solve this problem. 6. Some times it might happen that you are too far from the center of BTS, that is you are at the cell boundary. At that u might face problem to make a call as the transmitted signal from ur MS will not reach BTS. High gain antenna's can solve this problem. there are other different techniques to resolve this problem. But all these solutinos varies from vendor to vendor. Reply(/forum/discussions/83-200396-2566664/reply) Favorite(/util/favorite?title=Possible+reasons+for+call+drop&url=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396-2566664&contentType=message& contentId=2566664&path=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396) 0 Votes +(/util/vote) -(/util/vote)

Hints for Drop Calls(/forum/discussions/83-200396-2671152) info@...(/members/profile/5503985) 2nd Jan 2009 Some quick hints for dropped calls(http://cellphonedropcalls.com/) Reply(/forum/discussions/83-200396-2671152/reply) Favorite(/util/favorite?title=Hints+for+Drop+Calls&url=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396-2671152&contentType=message& contentId=2671152&path=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396) 0 Votes +(/util/vote) -(/util/vote)

TCH Drop-Call Drop(/forum/discussions/83-200396-3450744) telecomfunda(/members/profile/6811431) 13th May Radio Link Time-Out Layer 2 Time-Out MSC Time-Out Assignment to TCH More Info at http://telefunda.blogspot.com/2010/01/dropped-calltch-drop-sdcch-drop.html(http://telefunda.blogspot.com /2010/01/dropped-calltch-drop-sdcch-drop.html) Reply(/forum/discussions/83-200396-3450744/reply) Favorite(/util/favorite?title=TCH+Drop-Call+Drop&url=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396-3450744&contentType=message& contentId=3450744&path=http%3A%2F %2Fwww.techrepublic.com%2Fforum%2Fdiscussions%2F83-200396)

3 of 3

10/4/2011 10:20 AM

Vous aimerez peut-être aussi