Académique Documents
Professionnel Documents
Culture Documents
Control valve for continuous control of liquids Low hysteresis and high repeatability Control with PWM signal Servo-assisted, tight closing valve
Type 6223 can be combined with
Type 8605
Type 2508
The valve Type 6223 can be used for the control of larger ow quantities. Low hysteresis, high reproducibility and good response sensitivity guarantee good positioning behaviour. The valve closes tight. The push-over coil is easy to replace.
Technical data Orice Body material Seal material Media Media temperature Ambient temperature Port connection Viscosity Operating voltage Power consumption Duty cycle Electrical connection Protection class valve Installation Hysteresis Repeatability Sensitivity Settling time (90%) Span DN 10, 13 and 20 mm Brass, stainless steel on request FKM, others on request Neutral liquids -10 to + 90 C Max. + 55 C G 3/8, G 1/2, G 3/4, G 1 Max. 21 mm2/s 24 V DC See ordering chart Continuous rating 100% Cable plug Type 2508 acc. to DIN EN 175301-803 Form A IP 65 with plug-on module or with cable plug on the valve As required, preferably with actuator in upright position < 5% < 1% FS < 1% FS < 200 ms 1:10
www.burkert.com
p. 1/3
6223
Circuit function
10 13 20
8 8 10 10 15 15
134 229 134 230 132 202 132 640 134 231 134 232
G 3/4 G 3/4 G1
1) Kvs value: Flow rate value for water, measured at +20 C and 1 bar pressure differential over a fully opened valve 2) QNn value: Flow rate value for air with inlet pressure of 6 bar1) , 1 bar pressure differential and +20 C 3) Pressure data [bar]: Overpressure with respect to atmospheric pressure
Please note that the valves are delivered without control electronics unit and cable plug (see accessories below).
6223
Dimensions [mm]
www.burkert.com
0903/2_EU-en_00891754
p. 3/3