Académique Documents
Professionnel Documents
Culture Documents
40-1036
CONNECTION
Follow the diagram to connect the speaker.
Woofer Tweeeter
Light, Rigid, Polypropylene Cone extra-durable long-life cone resists moisture and temperature extremes, and withstands greater stress at high volume levels. Rolled Urethane Foam Surround minimizes distortion and improves clarity. Long-Throw Voice Coil delivers clean, solid sound.
INSTALLATION
Use the speaker as a template to mark a mounting hole 3 9 /8 inches (238 mm) in diameter, then cut the hole in the mounting surface.
Note: If you want to connect a midrange and a tweeter, you must also connect a crossover network (available at your local RadioShack store).
SPECIFICATIONS
Impedance ......................................................... 8 Ohms Frequency Response ............................ 30 Hz2,500 Hz Free Air Resonance .............................................. 30 Hz Power Handling ....................................... 60 Watts RMS Input Power ................................. 120 Watts (Maximum) Sensitivity ............................................. 90 2 dB/1w/1m Cone Material ........................................... Polypropylene Acoustic Suspension Enclosure ...................... 1.32 CuFt Bass Reflex: Enclosure .................................................... 1.48 CuFt (225/32 x 1311/16 x 81/2 Inches HWD) Vent Diameter ................................................ 3 Inches Vent Length ................................................ 5.8 Inches Crossover Frequency ........................ 800 Hz and 5K Hz (with 40-1270D Tweeter and 40-1033 Midrange) Dimensions (HWD) ......................... 4 1 /2 10 10 Inches (11.5 25.6 25.6 cm) Magnet Weight .......................................... 12 oz (340 g) Speaker Weight ................................... 49.8 oz (1.41 kg) Specifications are typical; individual units might vary. Specifications are subject to change and improvement without notice.
Input
Crossover
Install the speaker from the cabinet front (with the terminals at the bottom of the speaker) and keep it flush with the baffle face. Secure the speaker with four screws (not supplied).
04/99