Académique Documents
Professionnel Documents
Culture Documents
Electric Power
Common look and feel throughout the product line: 20kW to 5MW Superior features Scalable purchase only what is needed Flexible & configurable to adapt to site specific requirements
EMCP 3 Controls
EMCP 3.1 EMCP 3.2 EMCP 3.3
Basic Controller Textual Display Auto/Start/Stop Genset Metering Engine Monitoring Mult. Languages
+ Modbus + Power Metering + Protective Relaying + Real Time Clock Min. Required for: - UL 2200 - NFPA 99/110
Option
Option
N/A Option
NA
Option
Display Lamp Test Alarm & Shutdown Indications with Acknowledge Key RUNAUTOSTOP Control w/ Status LEDs Navigation Keys Controller Type: 3.1, 3.2 or 3.3
One company. A multitude of solutions.
ENGINE START/STOP CONTROL GEN AC MONITORING & PROTECTION SPEED/FREQ. ADJUST VOLTAGE ADJUST
Controls Auto/Start/Stop Engine Cooldown timer Emergency Stop Engine Cycle Crank
Textual Display
33(h) x 132(w) pixel 24mm x 95mm graphical display Language Capability
Arabic Chinese Danish Dutch English Finnish French German Greek Hungarian Icelandic Italian Japanese Norwegian Portuguese Russian Spanish Swedish EU Languages
A3 Engine Controller
3500B Engines
A4 Engine Controller
C9 C15 C18 (ACERT) C27 C32 C175 Engines
Annunciator
Networked device only, no wiring 16 Points, 32 LEDs (12) Amber and Red LEDs (4) Green and Red LEDs Standard Label for NFPA 99 & 110 compliance All 16 points are configurable to any event that can occur on the network Custom Label Kit available Local or Remote up to 800ft w/o a repeater Up to three (3) Annunciators per EMCP 3
- High Temperature Warning/Shutdown - Resolution/Accuracy: - Two byte parameters - Resolution of 0.03125 C / bit - Range of -273 C to 1735 C. - Accuracy = +/- 1C RTD MODULE: 8-Channels 100 platinum RTDs Configurable for 2, 3, and 4-wire RTDs THERMOCOUPLE MODULE: 20-Channels Configurable for Type J or K Thermocouples
Remote Monitoring & Control Software Single Genset No Charge Option Allows the user to: Monitor Log Graph Control For use on all Windows based operating systems
Stop/Run switch controls start/stop of the engine when the EMCP 3 is in the Auto mode.
Genset Control, Engine Control, Voltage Regulator, and Expansion I/O Modules on the SAME network ALL information and diagnostics on ONE display GSC ALL information and diagnostics through ONE port Modbus ALL servicing, troubleshooting, and configuration with ONE service tool ET