Académique Documents
Professionnel Documents
Culture Documents
Living
Outside
Play
Technology
Workshop
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
Image Notes 1. Stapler that shoots 5/8" brads. Not necessary, but nice if you have it.
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
Image Notes 1. 1 1/4" 2. 1/2" 3. 1 1/2" 4. 3/8" 5. 11" 6. 1 1/2" 7. 3 1/8" 8. 3 5/8" 9. 9 1/2" 10. 3/8"
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
Image Notes 1. Draw lines every 5" starting from one end. 2. Choose one 11" end to start drawing lines from. 3. Draw arrow pointing from each line toward side you started measuring from.
Image Notes 1. Marked side of bottom ramp (11" x 44 5/8" piece) 2. Marked side of top ramp (9 1/2" x 44 5/8" piece) 3. Align Inner panels with marks on ramps. This is the back of the inner panel.
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
Image Notes 1. 4d finish nail inserted after drilling 1/8" hole 4" from front of inner panel. The nail will pierce all the way through the bottom ramp.
Image Notes 1. Top ramp marked location. 2. Bottom ramp marked location.
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
Image Notes 1. Ramp marked by 4d finish nail point. Use 1/8" drill bit to bore into ramp for finish nail. Image Notes 1. 4d finish nail poking through.
Image Notes 1. Finish nails poking through with wood glue. 2. Finish nails poking through with wood glue.
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
Image Notes 1. Attach back using small brads to hold back in place while glue dries. 2. Inside panel edge to inside panel edge should measure exactly 5".
Image Notes 1. Wood glue bead along back edge of inner and end panels.
Image Notes 1. Attach 4 1/2" x 2 1/2" pieces with small brads to hold in place while gluing. 2. Put a bead of wood glue on back of the 4 1/2" x 2 1/2" piece.
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
Image Notes 1. Small block attached to the back as seen from the top.
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
Image Notes 1. Place bead of wood glue along each top edge to mark.
Image Notes 1. First inner panel 5" spacing from end. 2. Second inner panel 10" spacing from end.
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/
Related Instructables
http://www.instructables.com/id/81-Can-FIFO-Bulk-Can-Dispenser-Organizer/