Académique Documents
Professionnel Documents
Culture Documents
Valve design Type Weight Cost Delivery Connection ends Joints Maintenance Tools Installation Protection Application
Side Entry B4, B5, B7 100 100 Fast Flanged ends More Workshop maintenance Standard N/A Above Ground
Top Entry BT1, BT2 115 140-160 Moderate Welded ends Less Inline maintenance Require Special tools Protective Sleeve Below Ground
Fully Welded B8 85 80-120 Slow Welded ends None N/A N/A N/A Sub sea, Under Ground, buried
Two pieces Allows only Self-Relieving Seat, means only one seat seal. In the event on seal is damaged, the other is forced to leak downstream. By this, NO HOT WORK can be carried out on the downstream line. Teflon / PTFE is used which is very hard material and is not as likely to form the shape of the ball, especially at lower pressure service. Has access to only one seat, the other seat is part of the body & access is not as fast and easy as the GROVE design.
Seal
Maintenance
Three pieces The Double Piston Effect is a safe, means to protect from such circumstances. If the valve seal is damaged, the pressure in the body increases the pressure on the downstream seat & will prevent any leakage downstream. Therefore, even with a damaged seal the GROVE DPE can prevent downstream venting and hot work can be carried out safely. An O-Ring design can seal against the ball, the softness of ORing allows it to form the shape of the ball & eliminate any leak path. Harder seal material is normally required on ANSI # 900 and above. Access to the valve seats is very simple, by unbolting each closure from the body.
TRIM Material Corrosion Resistance Hardness Binding from rubbing Friction Coefficient Secondary Seal Sealing
Stainless Steel Good. Susceptible to galvanic corrosion 280 Vickers Yes, because of the softness More. Required more torque. O-Ring An O-Ring design can seal against the ball, the softness of O-Ring allows it to form the shape of the ball & eliminate any leak path. Harder seal material is normally required on ANSI # 900 and above. Simply replace with O-Ring. Less
Carbon Steel Coated with Electroless Nickel Plating Excellence 780 Vickers No Less. Required much less torque. Teflon / PTFE Teflon / PTFE is used which is very hard material and is not as likely to form the shape of the ball, especially at lower pressure service. The hard seal is pressed into the Metal Seat, this will involve replacement of the Metal Seat & Teflon / PTFE seal as one assembly. More