Académique Documents
Professionnel Documents
Culture Documents
1.
Maps are defined as graphic representations of the earths surface drawn to scale on a plane surface. a. True b. False Relating to Civil Drafting, DTM stands for: a. Depth/Time Model b. Dual Technology Map c. Dense Topography Method d. Drafting-Time Mode e. None of the Above A traverse is a series of continuous lines connecting points called _______________. a. Traverse Stations b. Station Points c. Bench Marks d. All of the Above e. A and B
2.
3.
4.
A reading is first taken on the _________ (rod location) and is then added to the elevation of the known point. a. Backsight b. Foresight c. Temporary Bench Marks d. Height of the Instrument e. None of the Above From the previous question, the reading added to the elevation of the known point would give the surveyor the _____________ . a. Backsight b. Foresight c. Temporary Bench Marks d. Height of the Instrument Your plat is an irregular polygon which consists of six sides. The sum of the interior angles is ______________. a. 540 b. 720 c. 900 d. 1080 e. 1260 Metes and Bounds is a method of describing and locating property by measurements from a known starting point called a ___________. a. Bench Mark b. Monument c. Station Point d. Survey Stake e. Turning Point This system of legal description utilizes a base line and principal meridian for reference. a. Metes and Bounds b. Lot and Block c. Rectangular d. Grid System e. Surveyors Plot
5.
6.
7.
8.
Page 1
10. Contour lines connect points of ___________. a. Equal Distance b. Equal Elevation c. Varying Distance d. Varying Elevation e. All of the Above 11. The space between contour lines is termed the Contour _________. a. Level b. Relief c. Interval d. Station e. Gradation 12. Every fifth line on a topographic map is a(n) __________ contour. a. Control Index b. Reference c. Relief d. Supplementary 13. Determining accurately how far the cuts and fills will extend beyond the sides of the road is important in determining the proper amount of land to purchase for the right of way. a. True b. False 14. The angle of repose is basically the ratio of ___________ and is determine primarily by the type of soil or rock to be cut through or used as fill material. a. Width to Height b. Slope to Grade c. Run to Rise d. Plan to Profile e. Level to Incline 15. Profiles perpendicular to the road centerline are usually measured at full stations (every 100 ft), at half stations (every _______ ft), and at breaks or changes in the profile of the centerline. a. 5 b. 10 c. 25 d. 50 e. None of the Above 16. The Civil 3D user must know which of the following in order to use Civil 3D for typical subdivision design? a. AutoCAD b. Geometry concepts c. Surface or DTM concepts d. All of the above
Page 2
Page 3
Page 4
Page 5
Page 6