Académique Documents
Professionnel Documents
Culture Documents
Note: Initially, you can only access router US-R2 through the console connection on US-Admin. a. Configure and verify interface addressing on US-R2. Configure and activate all interfaces for US-R2 that are listed in the addressing table.
b. Configure the correct IP addresses on US-PC2 and US-R1. Configure US-PC2 with the last IP address in the subnet. Configure the Fa0/1 interface on US-R1 with the last IP address in the subnet.
c. Verify connectivity.
b. Modify the default OSPF operation. Configure US-R1 to always be the DR by using a priority of 150. Configure US-R2 to always be the BDR by using a priority of 75. Change the hello interval to 30 seconds on US-R1 and US-R2 for the LAN that these two routers share with ServerLAN. Verify OSPF neighbor status.
c. Verify that OSPF is fully operational. Verify that the routing tables on US-R1, US-R2, and US-HQ contain all the expected routes. It may be necessary to shutdown and then reactivate interfaces to force OSPF to converge.
Based on your performance on this assessment, this table reports your preparedness for taking a hands-on skills exam covering similar networking skills. The estimates are based on expert opinion of the knowledge and skills needed to successfully perform these networking tasks on a repeatable basis. Proficiency Estimates Performance Components None Novice Partial Proficient
OSPF Modification
See Terminology section for an explanation of terms. The following feedback summarizes why you received less than proficient on any of the estimates:
Although you correctly configured passive interfaces and priority, you did not correctly modify the hello intervals.
Scoring
Total Points Possible = 100 Total Earned Points = 93
US-R2 Fa0/1 Addressing Network:US-R2:Ports:FastEthernet0/1:IP Address Network:US-R2:Ports:FastEthernet0/1:Subnet Mask Network:US-R2:Ports:FastEthernet0/1:Power US-R2 S0/0/0 Addressing Network:US-R2:Ports:Serial0/0/0:IP Address Network:US-R2:Ports:Serial0/0/0:Subnet Mask Network:US-R2:Ports:Serial0/0/0:Power US-R2 Lo0 Addressing Network:US-R2:Ports:Loopback0:IP Address Network:US-R2:Ports:Loopback0:Subnet Mask
Correct
Network:US-HQ:OSPF:3:Networks:192.168.20.240 0.0.0.3 0 Network:US-HQ:OSPF:3:Networks:192.168.20.244 0.0.0.3 0 US-R1 Network Statements Network:US-R1:OSPF:3:Networks:192.168.20.0 0.0.0.63 0 Network:US-R1:OSPF:3:Networks:192.168.20.112 0.0.0.7 0 Network:US-R1:OSPF:3:Networks:192.168.20.244 0.0.0.3 0 US-R2 Network Statement Network:US-R2:OSPF:3:Networks:192.168.20.64 0.0.0.31 0 Network:US-R2:OSPF:3:Networks:192.168.20.112 0.0.0.7 0 Network:US-R2:OSPF:3:Networks:192.168.20.240 0.0.0.3 0
Correct