Académique Documents
Professionnel Documents
Culture Documents
Installation
General
If installation requires CFG file upload & download and / or SW file upload & down -
1. 2. 3.
Make sure FTP Server is installed on your PC FTP is configured (RD/WR permissions) Latest SW version is available (FTP root directory)
Site Requirements
IDU must be located indoors
Site Requirements
Heat Dissipation:
The IP-10 IDU overall heat dissipation is 25W max (~85 BTU/h). The ODU heat dissipation is 100W max.
Antenna Location:
As with any type of construction, a local permit may be required before installing an antenna. It is the owners responsibility to obtain any and all permits.
IDU Dimensions
42.60mm
As shown in the illustration, four screws, supplied with the installation kit, are used to secure the IDU to the rack.
Start the installation process from bottom to top, e.g. Main enclosure should be installed first at the bottom of your rack space
8
Proprietary and Confidential
10
11
12
13
14
15
16
17
18
19
20
2. This equipment is designed to permit connection between the earthed conductor of the DC supply circuit and the earthing conductor at the equipment.
3. The equipment shall be connected to a properly grounded supply system 4. The DC supply system is to be local, i.e. within the same premises as the equipment 5. A disconnect device is not allowed in the grounded circuit between the DC supply source and the frame/grounded circuit connection.
21
Power Requirements
When selecting a power source, the following must be considered:
Whether or not the power source provides constant power (i.e., power is secured on weekends or is shut off frequently and consistently).
The power supply must have grounding points on the AC and DC sides. The user power supply GND must be connected to the positive pole in the IDU power supply. Any other connection may cause damage to the system!
22
Power Requirements
Important Make sure to use a circuit breaker to protect the circuit from damage by short or overload.
23
24
read-only access read-write access but cannot add/remove other users read-write access including add/remove other users read-write access including add/remove other users as well as access to a bridge-specific CLI shell
Currently only Admin is defined Other groups or users can be created via CLI only
Thank You !