Académique Documents
Professionnel Documents
Culture Documents
2008-02-25
2008-11-195
Page 1 of 9
To activate the PS services, the APN must be set according to operators setting. In Optus, the APN must be set to 3gdgnet. There are 2 methods to set the APN for terminal:
CONNECTIVITY NETWORK ACCESS POINT PROFILE x. 2) Double click at the Access point name column under PROFILE x menu and enter 3gdgnet. 3) Back to main menu. You can check the PS service by browsing the internet. MENU BROWSER INTERNET SETTING PROFILE y NETWORK ACCESS POINT. 4) Make sure you select the correct profile under NETWORK ACCESS POINT menu, which is PROFILE x in step 1. 5) Back to BROWSER Menu and enter to the Enter URL menu. 6) Type the URL address, e.g., http://www.googles.com 7) The content of the homepage should be display on the screen. 8) You can connect your terminal to the PC/laptop and access the internet through your PC/laptop. Your terminal will become modem in this case. 9) Click on START CONNECT TO All connections. 10) Click at Create a new connection at the Network Tasks column. 11) Follow the wizard to complete the connection setup:
Click Next.
2008-11-195
Page 2 of 9
2008-11-195
Page 3 of 9
Select the correct modem: Mobile Adapter 3G Modem for Huawei U1211 terminal. Click Next.
2008-11-195
Page 4 of 9
Type the ISP Name, e.g., Optus in this example. Click Next.
2008-11-195
Page 5 of 9
There is no need to input User name and password. Skip this step and click Next.
You can add a shortcut to the desktop by checking the box. Click Finish to complete the set up.
2008-11-195 Huawei Confidential. No disclosure without permission. Page 6 of 9
through PC/laptop might be failure. Please follow the second method for activate the APN setting.
2)
2008-11-195
3)
2008-11-195
Page 8 of 9
4) 5)
In the Connect Optus page, click Dial. A Pre-dial Terminal Screen will pop up, as shown in figure below:
6) Configure the APN in the pop up window. The command is: at+cgdcont=1,"ip","****" (press ENTER after input **** is the APN value. **** = 3gdgnet in this case. 7) You should be able to connect to the internet after the setting. 8) To lock the frequency for Data Modem E220: at^u2diag=0 at^freqlock=1, 10837 (xxxx is the DL frequency) 9) For Data Modem E270/E180, the command is: at^freqlock=1, 10837 10) To unlock the frequency, the corresponding command is: at^freqlock=0
2008-11-195
Page 9 of 9